Party King Grills PKG DLX-SS-JV Owner's Manual

Model PKG DLX-SS-JV

Owner’s Manual

Read Owner’s Manual carefully before you assemble. Failure to follow these instructions could
result in serious bodily injury and/or property damage. This gas grill is intended for outdoor use
only.

1

TABLE OF CONTENTS

SAFETY INSTRUCTIONS……………………………..……….…………………………………….1-2
PRECAUTIONS………………………………………..………………………………………………..2-3
ASSEMBLY INSTRUCTIONS……………………….…….….……………………………………..…3

LEAK TESTING………………..………………………………………………………………………..3-4

OPERATING INSTRUCTIONS…………………………..………………………………………..4 -5
LIGHTING INSTRUCTIONS……………………………..…..………………………………….…….5
ADJUSTING GAS FLOW………………………………………………………………………………..6

CLEANING AND CARE…………………………………..….………………………………………….6
PARTS LIST……………….…………………………………...……………………………………………7
WARRANTY…………………………………………………..…..………………………………………..8

Note: The use and installation of this product must conform to local codes. In absence of
local code, use the National Fuel and Gas Code, ANSIZ223.1, Storage and handling of
liquefied petroleum Gases NFPA/ANSI 58 of Can/cga-B149.1.

WARNING

FOR YOUR SAFETY:

1. This grill is for outside use only, and shall not be used in a building, garage, or any other

enclosed area.

2. Never use charcoal or lighter fluid.

3. The use of alcohol, or prescription or non-prescription drugs may impair the consumer’s ability

to properly assemble or safely operate the appliance.

4. Always open grill lid carefully and slowly as heat and steam trapped within grill can severely

burn you.

5. Always place your grill on a hard, level surface far away from combustibles.

6. Do not attempt to move the grill while it is lit.

7. Do not leave a lit grill unattended and keep children and pets away from grill at all times.

8. Do not use grill in high winds above 5- 10 mph.

9. Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and

tightened.

SAFETY INSTRUCTIONS

DANGER

DO NOT use gas grill for indoor cooking or heating. TOXIC fumes can accumulate and cause
asphyxiation. Do NOT use this grill in or on boats.

2

DANGER

To prevent fire or explosion hazard when testing for a leak:

1. No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

2. Conduct the leak test outdoors in a well-ventilated area.

3. Do not use matches, lighters, or a flame to check for leaks.

Caution: It is essential to keep the grill’s valve compartment, burners, and circulating air
passages clean. Inspect grill before each use.

DANGER

1. Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns,

unless you are wearing protective gear (potholders, gloves, BBQ mittens, etc.).

2. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible

materials, gasoline and other flammable vapors and liquids.

3. Do not alter grill in any manner

4. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion,

wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into
operation. The replacement hose assembly shall be that specified by the manufactur e r.

5. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

6. Never keep a filled propane container in a hot car or car trunk. Heat will cause the gas

pressure to increase, which may open the relief valve and allow gas to escape.

DANGER

Do not store spare LP-gas cylinder within, under or near this grill.
Never fill the cylinder beyond 80 percent full.
A fire causing deaths or serious injury may occur if the above is not followed exactly.

PRECAUTIONS

Never let clothing, pot holders or other flammable materials come in contact with or too close to
any grate, burner or hot surface until it has cooled. Fabric may ignite and result in personal injury.
For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn
while using this appliance. Some synthetic fabrics are highly flammable and should not be worn
while cooking.

Only certain types of glass, heat-proof glass ceramic, earthenware, or other glazed utensils are
suitable for grill use, see the original manufactures recommendations before using on a grill. These
types of materials may break with sudden temperature changes. Use only on low or medium heat
settings according to the manufacturer’s directions.

Do not heat unopened food containers as a build-up of pressure may cause the container to burst.
Use a covered hand when opening the grill lid. Never lean over an open grill.

When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these