Paramount Fitness KLD7003S, KLD7003SS User Manual
USE AND CARE GUIDE
OUTDOOR SPIRAL FLAME HEATER
DANGER: Carbon Monoxide
Hazard. This appliance can produce
carbon monoxide, which has no
odour. Using it in an enclosed space
can kill you. Never use this appliance
in an enclosed space such as a
camper, tent or home.
Item #PH-F122
Model # KLD7003S/
KLD7003SS
DANGER: If you smell gas
□ Shut off gas to the appliance
□ Extinguish any open ame
□ If odour persists, keep away
from the appliance and call your
gas supplier or re department.
WARNING: For outdoor use only.
Questions, problems, missing parts? Before returning to the store, please contact customer service at
customercare@jrhome.com or call 1-800-561-5550 7 a.m. - 4 p.m., PST, Monday – Friday
1-800-561-5550
WWW.PARAMOUNTATHOME.COM
THANK YOU
We appreciate the trust and condence you have placed in Paramount through the purchase of this Outdoor Heater. We strive to continually create
quality products designed to enhance your home. Visit us online to see our full line of products available for your home improvement needs. Thank
you for choosing Paramount!
Table of Contents
Table of Contents ...................................2
Safety Information ..................................2
Warranty
What is covered ...................................3
What is not covered ................................3
Pre-Installation ................................... 2-3
Planning Installation ...............................2
Hardware Included .................................2
Package Contents .................................3
Safety Information
1. This appliance has been tested to and complies with the ANSI Z83.262014/CSA 2.37-2014, Gas-Fired Outdoor Infrared Patio Heaters. The
1.
installation must conform to local codes or in the absence of local
codes to the National Fuel Gas Code. ANS Z223.1. We cannot foresee
2.
every use which may be made of our appliance. Check with your local
3.
re safety authority if you have questions about your appliance use.
Other standards govern the use of fuel gases and heat producing
4.
products for specic uses. Your local authorities can advise you about
5.
these.
6.
2. This manual contains important information about the assembly,
operation and, maintenance of this appliance. General safety
7.
information is presented in these rst few pages and is also
8.
located throughout. Keep this manual for future reference and to
educate new users of this product. This manual should be read in
9.
conjunction with the labeling on the product.
10.
3. Safety precautions are essential when any mechanical or gas
11.
fueled equipment is involved. These precautions are necessary
when using, storing, and servicing. Using the equipment with
12.
the respect and caution demanded will reduce the possibilities
of personal injury or property damage. Always heed these
precautions, as they are essential when using any mechanical
or gas fueled equipment. Failure to comply with the precautions
and instructions provided with this appliance can result in death,
serious bodily injury and property loss or damage from hazards
of re, explosion, burn, asphyxiation, and of carbon monoxide
poisoning. Only persons who can understand and follow the
instructions should use or service this appliance.
4. Keep solid combustibles such as building materials, paper,
or cardboard a safe distance away from the appliance as
recommended by the instructions.
5. Provide adequate clearances around air openings into the
combustion chamber.
6. Never use the appliance in spaces which do or may contain volatile or
airborne combustibles, or products such as gasoline, solvents, paint
thinner, dust particles, or unknown chemicals. During operation, this
appliance can be a source of ignition. Keep appliance area clear and
free from combustible materials, gasoline, paint thinner, cleaning
solvents and other ammable vapors and liquids. Do not use the
appliance in areas with high dust content.
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10
Operation
Pre-operation ....................................11
Leak Test .......................................11
Lighting the heater ................................12
Turning off the heater .............................12
Relighting .......................................12
Operational checklist ..............................13
Post-Operation ...................................13
Maintenance, Care & Cleaning ........................14
Troubleshooting ...................................15
7. Minimum appliance clearances from combustible materials: 2 feet
(24 inches) from the sides & 2 feet (24 inches) from the rear, 6 feet
(72 inches) from ceiling.
8. Never install or remove a propane cylinder while the appliance is
lighted, near ame, pilot lights, or other ignition sources or while
the appliance is hot to the touch. This appliance is red hot during
use and can ignite ammables too close to the burner. Keep
ammables at least 2 feet (24 inches) from top and 2 feet (24
inches) from sides. Keep gasoline and other ammable liquids and
vapors well away from the appliance.
9. Store the propane cylinder outdoors in a well ventilated space out of
the reach of children. Never store the propane cylinder in an enclosed
area (house, garage, etc.). If the appliance is to be stored indoors
disconnect the propane cylinder for outdoor storage.
NOTICE: THD Danger/Warning/Caution/Important/Note Text.[
HelveticaNeueLT STD, 9pt.]
10. Never store propane near high heat, open ames, pilot lights,
direct sunlight, other ignition sources or where temperatures
exceed 120 degrees F (49 degrees C)
DANGER: HAZARDOUS FIRE OR EXPLOSION MAY RESULT
IF INSTRUCTIONS ARE IGNORED.
WARNING: THD Danger/Warning/Caution/Important/Note
Text.[ HelveticaNeueLT STD, 9pt.]
CAUTION: THD Danger/Warning/Caution/Important/Note
Text.[ HelveticaNeueLT STD, 9pt.]
WARNING: Do not store or use gasoline or
WARNING: THD Danger/Warning/Caution/Important/Note
other ammable vapors and liquids in the vicinity
Text.[ HelveticaNeueLT STD, 9pt.]
of this or any other appliance.
Any LP-cylinder not connected for use shall
not be stored in the vicinity of this or any other
appliance.
WARNING: Improper installation, adjustment,
alteration, service or maintenance can cause
property damage, injury or death. Read the
installation, operation and maintenance
instructions thoroughly before installing or
servicing this equipment.
WARNING: This product can expose you to
chemicals, including carbon monoxide, which is
known to the State of California to cause birth
defects or other reproductive harm. For more
information go to www.P65Warnings.ca.gov.
2
Pre-Installation-Tools and Hardware
PLANNING INSTALLATION
Before beginning assembly, be sure to empty contents of carton and make sure all parts are present. Place all parts on a soft, level surface for
assembly. If any parts are missing, please contact Customer Service between 8 a.m. - 7 p.m., EST, Monday – Friday, 9 a.m. – 6 p.m., EST, Saturday.
Estimated Assembly Time: 30 minutes
NOTE: You will need a leak test solution. See page 11 for
instructions.
HARDWARE INCLUDED
WARNING: Keep children away during assembly. This
item contains small parts which can be swallowed by
children.
NOTE: Hardware not shown to actual size.
________II
________AA
________EE
________BB
________CC
________DD
Part Description Quantity
AA M6 x 12mm Bolt 6
BB M6 Nut 22
CC M8 Bolt 3
DD M8 Washer 6
EE Wing Nut 3
FF M8 x 16mm Bolt 2
GG M8 x 12mm Bolt 3
HH M8 Nut 3
II M8 x 45mm Bolt 3
JJ Wrench 1
________FF
________GG
________HH
________JJ
3 PARAMOUNTATHOME.COM
Please contact customercare@jrhome.com or 1-800-561-5550 for further assistance.
Pre-Installation-Package Contents
PACKAGE CONTENTS
A
B
C
D
E
H
G
Part Description Quantity
A
B Emitter Screen 1
C Protection Guard 4
D Glass Tube 1
E Tank Assembly 1
F Wheels 1
G Cylinder Ring 1
H Anchoring Pins 3
I Anchoring Arms 3
4
I
F
1
Assembly
Attaching The Wheels To The Tank
1
Assembly
NOTE: If permanently anchoring the heater to the ground
or patio, skip to step 2.
□ Line up holes in the wheels (F) with the corresponding
holes in the base of the tank assembly (E) and insert two
M8x16 screws (AA) through the holes. Finger tighten the
bolts.
□ Make sure the wheels (F) are parallel to the base of the
tank assembly (E) and then fully tighten the bolts using the
wrench (JJ).
Attaching The Cylinder Ring
2
E
F
□ Attach the cylinder ring (G) to the base of the tank
assembly (E) using three M8x12 screws (GG) and three M8
nuts (HH) which are preassembled with the
□ Adjust the M8x45 screw (II) preassembled in the cylinder ring
(G) to secure the LPG cylinder.
5 PARAMOUNTATHOME.COM
Please contact customercare@jrhome.com or 1-800-561-5550 for further assistance.
cylinder ring (G).
Loading...