Page 1
Report No.:CESMSDS201128019
Material Safety Data Sheet
材料安全数据表
Name of Sample: Li-ion Polymer Battery
产品名称 ： 锂离子聚合物电池
Model Specification:
产品型号： 955565
Client: Guangdong CVATOP New Energy Technology Co., Ltd.
委托单位 ： 广东嘉拓新能源科技有限公司
先进储能材料国家工程研究中心有限责任公司检测中心
Test Center of National Engineering Research Center of Advanced Energy Storage Materials Co., Ltd.
Page 2
说 明
Marking
1. 报告无“报告 专用章 ”无效。
The test report is invalid without “Special seal for report”.
2. 报告无批准人、审核人和编制人签名无效。
The test report is invalid without the signatures of Approver, Reviewer and writer.
3. 报告涂改无效。
The test report is invalid if altered.
4. 对检测报告若有异议，应于收到报告之日起十五天内向检测单位提出。
Objections to the test report must be submitted to Test Center within15 days.
5. 报告仅对送检样品负责。
The test report is Valid for the tested samples only.
6. 未经实验室书面批准，不得部分复制本报告书。
The partial replica of this report is prohibited without the written approval of CES.
检测单位地址：广东省深圳市宝安区新安街道宝石路29号蓝坤集团大厦B栋一楼B102
Lab Address：No.B102, 1/F., Lankun Group Building B, No.29, Baoshi Road, Xin'an Street,
Bao'an District, Shenzhen, Guangdong, China
电话(TEL)：86-755-22678310
传真(FAX)：0755-22678299
邮政编码(Post Code)：518101
网址(Website)：www.cescert.com
E-mail：[email protected]
Page 3
Section 1——Chemical Product and Company Identification
化学品及企业标识
Product Name:
产品名称：
Li-ion Polymer Battery
锂离子聚合物电池
Type/Mode:
样品型号：
955565
3.7V 5000mAh 18.5Wh
Commissioned by:
委托单位：
Guangdong CVATOP New Energy Technology Co., Ltd.
广东嘉拓新能源科技有限公司
Commissioner address:
委托单位地址：
Yongwei mansion, stone row avenue, shipai town, dongguan
city, guangdong province
广东省东莞市石排镇石排大道永威大厦
Manufacturer:
生产单位：
Guangdong CVATOP New Energy Technology Co., Ltd.
广东嘉拓新能源科技有限公司
Inspection according to:
鉴定依据：
EEC Directive 93/112/EC
UN "Recommendations on the TRANSPORT OF DANGEROUS
GOODS"
联合国《关于危险品货物运输的建议书》
Emergency telephone call:
应急电话：
86-769-82296333
Receiving Date:
接样日期：
2020-11-28
Date of issue:
签发日期：
2021-01-04
Material Safety Data Sheet
Report No.：CESMSDS201128019 Page 1 of 8
材料安全数据表
Approved by： Reviewed by： Written by：
Page 4
Section 2. Composition/information on Ingredient
成分/组成信息
Chemical Name
化学品名称
Chemical
Formula
化学式
CAS No.
CAS 号
Composition 成份
(in % by weight)
(重量百分比)
三元材料
/Lithium-nickel-cobalt-manganese oxides
Li(NiCoMn)O2
113066-89-0
25-40
Graphite 石墨
C
7782-42-5
15-25
Organic electrolyte 电解液
--
--
10-15
Aluminum 铝箔
Al
7429-90-5
5-8
PVDF 聚偏氟乙烯
(CH2-CF2)n
24937-79-9
0.5-1
Copper 铜箔
Cu
7440-50-8
5-10
SBR 丁苯橡胶
C12H14
9003-55-8
0.5-1
Polyethylene 聚乙烯
(C2H4)n
9002-88-4
0.1-1
Polypropylene 聚丙烯
(C3H6)n
9003-07-0
0.5-1
Section 3.Hazards Identification
危险性概述
Explosive risk
爆炸危险性
This article does not belong to the explosion dangerous goods
该物品不属于爆炸危险品
Flammable risk
易燃危险性
This article does not belong to the flammable material
该物品不属于易燃危险品
Oxidation risk
氧化危险性
This article does not belong to the oxidation of dangerous goods
该物品不属于氧化危险品
Toxic risk
毒害危险性
This article does not belong to the toxic dangerous goods
该物品不属于毒害危险品
Radioactive risk
放射危险性
This article does not belong to the radiation of dangerous goods
该物品不属于放射危险品
Mordant risk
腐蚀危险性
This article does not belong to the corrosion of dangerous goods
该物品不属于腐蚀危险品
Other risk
其他危险性
This article is the Lithium ion battery.
该物品为锂离子电池。
Section 4. First aid measures
急救措施
Report No.：CESMSDS201128019 Page 2 of 8
Eye: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower
eyelids. Get medical aid.
眼睛：万一接触，立即用大量的清水冲洗至少 15 分钟，翻起上下眼睑，直到化学的残留物消失为止，
Page 5
Section 5. Fire-fighting measures
消防措施
Section 6. Accidental release measures
泄露应急处理
Report No.：CESMSDS201128019 Page 3 of 8
迅速就医。
Skin: Remove contaminated clothes and rinse skin with plenty of water or shower for 15 minutes. Get
medical aid.
皮肤：万一接触，用大量水冲洗至少 15 分钟，同时除去污染的衣物和鞋子，迅速就医。
Inhalation: Remove from exposure and move to fresh air immediately. Use oxygen if available.
吸入：立即从暴露处移至空气清新处，如果呼吸困难给予输氧，立即就医。
Ingestion: Give at least 2 glasses of milk or water. Induce vomiting unless patient is unconscious.
Call a physician
食入：饮用两杯牛奶或水。如果当事人仍然清晰可以采取催吐的方法，并且立即就医。
Flash Point: N/A.
燃点：不适用
Auto-Ignition Temperature: N/A.
自燃温度：不适用
Extinguishing Media: Water, CO2.
灭火介质：大量水（降温），二氧化碳
Special Fire-Fighting Procedures: Self-contained breathing apparatus.
特殊灭火程序：自给式呼吸器
Unusual Fire and Explosion Hazards: Cell may vent when subjected to excessive heat-exposing
battery contents.
异常火灾或爆炸：当电芯暴露于过热的环境中时，安全阀可能会打开。
Hazardous Combustion Products: Carbon monoxide, carbon dioxide, lithium oxide fumes.
燃烧产生的危险物品：一氧化碳，二氧化碳，锂氧化物烟气
Steps to be taken in case Material is Released or Spilled If the battery material is released, remove
personnel from area until fumes dissipate. Provide maximum ventilation to clear out hazardous gases.
Wipe it up with a cloth, and dispose of it in a plastic bag and put into a steel can. The preferred
response is to leave the area and allow the battery to cool and vapors to dissipate. Provide maximum
ventilation. Avoid skin and eye contact or inhalation of vapors. Remove spilled liquid with absorbent
and incinerate.
为防止电池材料泄露或释放采取的措施如果电池内部材料泄露，试验人员应立刻撤离试验区直到烟气消
散。将通风设备打开吹散危险性气体。用抹布擦净试验区，清除溢出的液体，将泄露电池放进塑料袋中，
然后放进钢制容器。避免皮肤和眼睛接触或吸入有害气体。
Waste Disposal Method: It is recommended to discharge the battery to the end, to use up the metal
Page 6
Section 7. Handling and storage
操作处置和储存
Section 8. Exposure controls/personal protection
接触控制/个人防护
Report No.：CESMSDS201128019 Page 4 of 8
lithium inside the battery, and to bury the discharged battery in soil..
废弃物处置方法： 建议将电池完全放电，消耗电池内部的锂金属，并且深埋于土壤中。
The battery should not be opened, destroyed or incinerate, since they may leak or rupture and
release to the environment the ingredients that they contain in the hermetically sealed container. Do
not short circuit terminals, or over charge the battery, forced over-discharge, throw to fire. Do not
crush or puncture the battery, or immerse in liquids.
禁止打开、毁坏或焚烧电池，因为电池有可能在这些处理过程中发生爆炸、破裂或泄露等事故。禁止将
电池短路、过充、强制放电或扔入火中。禁止挤压刺穿电池或将电池浸入溶液中。
Precautions to be taken in handling and storing Avoid mechanical or electrical abuse. Storage
preferably in cool, dry and ventilated area, which is subject to little temperature change. Storage at
high temperatures should be avoided. Do not place the battery near heating equipment, nor expose
to direct sunlight for long periods.
操作处置和储存中的防范措施禁止物理或电滥用，禁止高温储存，最好将电池储存在阴凉、干燥、通风
及温度变化较小的环境中。禁止将电池接触加热设备或将电池直接暴露与阳光中。
Other Precautions The battery may explode or cause burns, if disassembled, crushed or exposed to
fire or high temperatures. Do not short or install with incorrect polarity
其他要注意的防范措施拆解、挤压、直接放入火中或高温条件下，电池可能发生爆炸和燃烧。禁止短接
或将电池正负极错误的安装在设备中。
Respiratory Protection In case of battery venting, provide as much ventilation as possible. Avoid
confined areas with venting cell cores. Respiratory Protection is not necessary under conditions of
normal use.
呼吸防护 当电池排气阀打开时，应尽量使通风设备开至最大，避免将打开排气阀的电芯局限在某一狭
窄空间内。正常操作条件下，呼吸保护是不必要的。
Ventilation Not necessary under conditions of normal use.
通风条件 正常使用条件下不必考虑。
Protective Gloves Not necessary under conditions of normal use.
防护手套 正常使用条件下不必考虑。
Other Protective Clothing or Equipment Not necessary under conditions of normal use.
其他防护服装或设备 正常使用条件下不必考虑。
Personal Protection is recommended for venting battery Respiratory Protection, Protective
Gloves, Protective Clothing and safety glass with side shields.
电池开阀试验时应做好个人防护呼吸防护，防护手套，防护服装和有护边的安全玻璃罩都是要准备的。
Page 7
Section 9. Physical and chemical properties
物理和化学特性
Section 10. Stability and reactivity
稳定性和反应活性
Section 11. Toxicological information
毒理学资料
Report No.：CESMSDS201128019 Page 5 of 8
Appearance: Prismatic
外形：棱柱形
Odour: If leaking, smells of medical ether
气味： 泄漏时，有刺激性气味。
pH: Not applicable as supplied.
酸碱度：不适用
Flash Point: Not applicable unless individual components exposed.
闪点：针对单个组分暴露情况，其他不适用。
Flammability: Not applicable unless individual components exposed.
易燃度：针对单个组分暴露情况，其他不适用。
Relative density: Not applicable unless individual components exposed.
相对密度：针对单个组分暴露情况，其他不适用。
Solubility (water): Not applicable unless individual components exposed
溶解性（水溶性）：针对单个组分暴露情况，其他不适用。
Solubility (other): Not applicable unless individual components exposed.
溶解性（其他）：针对单个组分暴露情况，其他不适用
Stability: Product is stable under conditions described in Section 7.
稳定性：产品在第 7 节所述的条件下稳定。
Conditions to Avoid : Heat above 70°C or incinerate. Deform. Mutilate. Crush. Disassemble.
Overcharge. Short circuit. Expose over a long period to humid conditions.
应避免的条件：加热 70°C 以上或焚烧、变形、毁坏、粉碎、拆卸、过充电、短路，长时间暴露在潮湿
的条件下。
Materials to avoid: Oxidising agents, alkalis, water.
应避免的材料：氧化剂，碱，水。
Hazardous Decomposition Products : Toxic Fumes, and may form peroxides.
危险分解物：有毒烟雾，并可能形成过氧化物。
Hazardous Polymerization : N/A.
聚合危害：不适用
If leaked, forbidden to contact with strong oxidizers, mineral acids, strong alkalies, halogenated
hydrocarbons.
如果发生泄露，避免与强氧化剂，无机酸，强碱，卤代烃接触。
Signs & symptoms: None, unless battery ruptures.
标志及症状：无，除非电池破裂。
In the event of exposure to internal contents, vapour fumes may be very irritating to the eyes and skin.
Page 8
Section 12. Ecological information
生态学资料
Section 13. Disposal consideration
废弃处置
Section 14. Transport information
运输信息
Report No.：CESMSDS201128019 Page 6 of 8
内部物质暴露的情况下，蒸汽烟雾可能对眼睛和皮肤的刺激性。
Inhalation: Lung irritant.
吸入：对肺有刺激性。
Skin contact: Skin irritant.
皮肤接触：对皮肤刺激性。
Eye contact: Eye irritant
眼睛接触：对眼睛有刺激性。
Ingestion: Poisoning if swallowed.
食入：吞下中毒。
Medical conditions generally aggravated by exposure: In the event of exposure to internal contents,
moderate to server irritation, burning and dryness of the skin may occur, Target organs nerves, liver
and kidneys.
下列情况下会危险人员身体健康：如果与电池内部材料直接接触，皮肤可能会出现干燥、灼烧等轻微或
严重的刺激，并且损坏靶器官的神经，肝脏和肾脏。
Mammalian effects: None known at present.
对哺乳动物的影响：目前未知。
Eco-toxicity: None known at present.
生态毒性：目前未知。
Bioaccumulation potential: Slowly Bio-degradable
生物体内积累：慢慢地生物降解。
Environmental fate: None known environmental hazards at present.
环境危害：目前没有已知的环境危害。
Do not incinerate, or subject cells to temperature in excess of 70°C, Such abuse can result in loss of
seal leakage, and/or cell explosion. Dispose of in accordance with appropriate local regulations.
禁止焚烧，或使电池温度超过70°C，这种滥用可导致泄漏和/或电池爆炸。应按照相应的地方性法规处
理。
Label for conveyance: Lithium Battery Label, or Lithium Battery Class 9 Hazard Label, or Cargo
Aircraft Only Label.
运输标签：锂电池标签，或锂电池九类危险品标签，或仅限货机标签
UN Number: UN3480 or UN3481
UN 编号：UN3480 或 UN3481
Packaging Group: Not Applicable
Page 9
Section 15 Regulation information
法规信息
Report No.：CESMSDS201128019 Page 7 of 8
包装等级：不适用
Marine pollutant: No
海洋污染物：无
Proper Shipping name: Lithium Ion Batteries(Including Lithium Polymer Batteries) , Lithium Ion
Battery Packed With Equipment, Lithium Ion Battery Contained In Equipment
正确的装运名称：锂离子电池(包括锂聚合物电池),或锂离子电池与设备包装在一起,或锂离子电池安装
在设备中
Transport information: Lithium ion battery is of a type proved to meet the Requirements of each test
in the UN MANUALOF TESTS AND CRITERIA, PartⅢ,sub-section 38.3.
The lithium-ion battery with a watt-hour rating not exceeding 100Wh or the cell with the watt-hour
rating is not exceeding 20Wh, The lithium-ion battery according to Section II/Section IB of PACKING
INSTRUCTION 965, or Section II of PACKING INSTRUCTION 966~967 of the IATA Dangerous
Goods Regulations 62nd Edition may be transported.
The goods shall be complied with the requirements of special provision 188 of IMDG CODE (Amdt.
40-20) 2020, The goods to be transport as Non-restricted Good
The packaging shall be adequate to avoid mechanical damage during transport, handling and
stacking. The materials and pack design shall be chosen so as to prevent the development of
unintentional electrical conduction, corrosion of the terminals and ingress of moisture.
运输信息：锂离子电池已通过联合国《试验和标准手册》第Ⅲ部分 38.3 小节相应测试要求。
锂离子电池瓦时额定值不超过 100Wh 或者锂离子电芯瓦时额定值不超过 20Wh，根据第 62 版 IATA
DGR 手册 965 第 II 节/第 IB 节或 966〜967 第 II 节的指令可以运输。
货物运输应遵守 IMDG CODE (Amdt. 40-20) 2020 版特殊规定 188 的要求，该货物属于非限制货物。
包装应坚固足以避免在运输，处理和堆放期间的机械损坏。选择合适的包装材料和包装设计，要防止电
池意外导电和端子腐蚀。
Law information
法律信息
《Dangerous Goods Regulations》
《危险物品规则》
《Recommendations on the Transport of Dangerous Goods Model Regulations》
《对危险货物运输的有关规定的建议》
《International Maritime Dangerous Goods》
《国际海运危险货物规则》
《Technical Instructions for the Safe Transport of Dangerous Goods》
《危险品安全运输技术指令》
《Classification and code of dangerous goods》
《危险货物分类和品名编号》
《Occupational Safety and Health Act》(OSHA)
《职业安全卫生法》
Page 10
Section 16 Other information
其他信息
Report No.：CESMSDS201128019 Page 8 of 8
《Toxic Substance Control Act》(TSCA)
《有毒物质控制法》
《Consumer Product Safety Act》(CPSA)
《消费产品安全法》
《Federal Environmental Pollution Control Act》(FEPCA)
《联邦环境污染控制法》
《The Oil Pollution Act》(OPA)
《石油污染法案》
《Superfund Amendments and Reauthorization Act TitleⅢ (302/311/312/313)》(SARA)
《超级基金修正案和再授权法案Ⅲ(302/311/312/313)》
《Resource Conservation and Recovery Act》(RCRA)
《资源保护及恢复法案》
《Safety Drinking Water Act》(CWA)
《安全饮用水法》
《California Proposition 65》
《加州 65 提案》
《Code of Federal Regulations》(CFR)
《美国联邦法规》
In accordance with all Federal, State and local laws
根据所有联邦、州和地方法律。
The commissioner provides the composition information of batteries, and promises its integrity and
accuracy. Users should read this file carefully, and use the batteries in correct method. Test Center of
National Engineering Research Center of Advanced Energy Storage Materials Co., Ltd. doesn’t
assume responsibility for any damage or loss because of misuse of batteries.
该电池的成分信息由委托方提供并承诺其完整性和准确性。用户应仔细阅读此文件，并按照正确的方法
使用电池，如因电池使用不当造成的损害或损失，先进储能材料国家工程研究中心有限责任公司检测中
心（CES）不承担任何责任。
-- End of Report --
Loading...