OZtrail OZ2210 Instruction Manual

NAME OF PARTS

OPERATING INSTRUCTIONS

Fitting Gas Cartridge:

1. Turn the control knob to the OFF position. Make sure that the cartr idge
lever is in the UNLOCK position. If the gas knob is in the ON position the
cartridge cannot be put into positi on.

2. Open the cartridge cover and inser t the gas cartridge. Make sure that the cartridg e slot fits
into the cartridge lever guide on the valve inside the s tove.

(Caution: Use only approved butane gas c artridge UL147B or EN417)

3. When you are ready to use the stove, push the cartridge le ver down to the
FUEL-LOCK position. If a hissing sound or gas smell is evident, check that
cartridge is fitte d correctly. Repeat step 2 to stop the gas leakage. If lever is

hard to push down, do not force it. Ch eck that the cartridge is f itted
correctly and the contr ol is in the OFF position.

Ignition:

1. Turn the control knob towards the IGNITION position until a click is heard f rom the piezo
ignit or.

2. If ignition fails, turn the control knob back to the O FF position and repeat.

Heat Control:

1. The control knob can be positioned on ‘Maximu m’, ‘Minimum’, etc. Adjust it to the suitable
position for cooking.

2. When turning the control knob from ‘Maximum’ to ‘Minimu m’, turn slowly toward ‘Minimum’.

Extinguishing:

1. Turn the control knob to the OFF position. Confirm that the f lame is completely extinguished.

2. Raise the cartridge lever to the UNLOCK position, and t ake out the gas cartridge.

WARNING!!

•

Switch cartridge lever to UNLOCK position when appliance is not in use.

• Do not store cartridge in stove during transportation or storage.

• Replace the nozzle cap back onto the cartridge to protect nozzle and avoid accidental gas

leakage if nozzle is bumped or depressed.

• Avoid boil overs and spillage.

• During use parts may become very hot. Keep young children away.

• When hot only handle the appliance by the control surfaces intended to be touched.

• Allow to cool before moving or handling.

• Do not use as space heater.

• Do not use for any other purpose other than cooking.

• Remove all packaging before use. Do not operate stove in the carry case.

• Caution: Never obstruct the air openings or vents on this appliance.

PRESSURE SENSITIVE SAFETY DEVICE

If the stove is used in a hot area such as outdoors in direct sunlight or incorrectly (not in
accordance with these instructions), the internal pressure of the cartridge will increase.
If the pressure reaches a dangerous level the in-built safety device will activate stopping
the flow of gas and extinguishing the flame. If the in-built safety device activates,
determine and correct the cause before reusing the stove.

Re-igniting the stove after the pressure sensitive safety device has been activated:

1. Remove the gas cartridge from the stove. Push in the noz zle of the cartridge for a second to release p ressure from the cartridge.
Place the cartridge in a cool area for a while to lower the pr essure to normal.

2. Turn the control knob to the ON position to remove excess gas from the valve.

3. Repeat instructions as set out in this manual (Operating Instructions).

PRECAUTIONS

Gas Cartridge:

1. This appliance shall only be used with a butane car tridge certified to UL147B or
EN417 IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF GAS CARTRIDGES.

2. The cartridge should be placed away from f lammable products or direct sunlight.
Never keep cartridge in places where the temperature is over 50˚C.

3. Do not subject the cartridge to imp act or rough handling.

4. Cartridges must be stored ou tdoors in a well ventilated location out of reach
of children.

5. Do not puncture or incinerate empty c artridge.

6. Avoid carrying cartridge in the b oot of a car or any unventilated enclosure.

7. Gas cartridges shall be changed in a well ventilated lo cation, preferably outside,
away from people and any sources of ignition such as naked f lames, electric
heaters/equipment.

8. To check if gas cartridge contains gas, disconnec t from the stove, then hold upright
and shake from side to side. If you can feel or hear liquid movement, it contains gas.

Stove:

1. Check the seals between the appliance and the gas c artridge are in place and in
good condition before connecting t he gas cartridge.

2. Do not use this appliance if it has damaged or worn seals

3. Do not use this appliance if it is leaking, damaged or does not oper ate properly.

4. If there is a leak on your appliance (smell of gas) and you cannot stop the gas flow,
remove the appliance to a well ventilated location away from any ignition source.
Only check for leaks outdoors using a s oapy water solution. Do not try to detect
leaks using a flame.

5. This appliance must only be serviced by an authori sed person.

6. Do not modify this appliance

Use:

1. Do not use for any purpose other than cooking. Incorr ect use may result in
overheating, incomplete combustion and/or a risk of fire or e xplosion.

2. Do not put items such as briquettes or heat beads o n the stove.

3. In the event of a gas leak (smell of gas) immediately turn the control to the
off position and move the cartr idge lever to the unlock position to isolate
the gas supply.

4. Do not move the appliance during operation.

5. The maximum sized vessel (pot or pan) to be used on this stove is 21cm diameter.

OFF

UNLOCK

LOCK

MAX

IGNITION

MIN

OFF

UNLOCK

LOCK

MAX

IGNITION

MIN

OFF

MAX

IGNITION

MIN

OFF

MAX

IGNITION

MIN

OFF

MAX

IGNITION

MIN

OFF

UNLOCK

LOCK

MAX

IGNITION

MIN

Pot Stand (Trivet) Burner Head Valve & Cartridge Guide

Cartridge Cover

Reference Window

Control Knob

Cartridge Lever

Drip Pan

Placement:

1. Do not use the stove in very windy conditions.

2. Do not place or use this appliance on any hot surf ace.

3. Do not use the stove under overhanging shelves etc.

4. Do not use close to combustible materials such as cur tains. No
combustible materials should be within 400 mm from any side
of or 1200mm above the stove.

5. Use stove in the shade or in cool places. Avoid using in direct
sunlight.

6. Only operate this appliance on a flat horizontal sur face to
ensure the aeration opening below the stove is clear and
unobstructed.

7. ONLY USE IN WELL VENTILATED AREAS :

CARBON MONOXIDE HAZARD - THIS APPLIANCE CAN

PRODUCE CARBON MONOXIDE WHICH HAS NO ODOUR.
USING IT IN AN ENCLOSED SPACE (FOR EXAMPLE,
CARAVAN, TENT, CAR, MOBILE HOME) MAY CAUSE DEATH.

ABNORMAL OPERATION

Abnormal operation can be identified by:

Frequent activation of pressure safe ty device
Jamming of cartridge lock lever
Irregular burner flame which is yellow or unst able
Black sooting of cooking utensils
Refer to the trouble shooting section o f this manual for possible solutions.

If the stove does not operate proper ly DO NOT use the appliance.

MAINTENANCE

Precautions:

1. Make sure that the gas cartridge is released be fore cleaning.

2. Never remove safety devices or gas components.

Cleaning:

1. Body: Wipe off with a clean cloth. When ne cessary, use a kitchen cleanser
and then finish with a dry cloth.

2. Pan support and drip pan: After washing, wipe wit h a dry cloth.

3. Burner: Clean the burner top and the burner por ts with a hard brush making
sure that all food particles are removed fr om the burner ports.

TROUBLE SHOOTING

Lack of fuel

Spark point dirty

Dirty burner

Imperfect cartridge
alignment

Renew cartridge

Carefully remove dirt

Clean the burner

Realign cartridge

Use of unsuitable
fuel

Replace with cartridge
containing correct fuel

Internal gas pressure
too high

Functioning of safety
stop mechanism

Improper setting of
spark point

Cool down gas cartridge

Check and reset
mechanism

Set spark point to 2mm
away from burner

No ignition

No burning

Unstable flame

Uneven flame

Slow burning

Gas smell

Flame extinguishes

during use

CAUSE SOLUTION

PROBLEM

400mm

400mm

SPECIFICATIONS

Open side at least
25% of total wall area

Open side at least
25% of total wall area

30 percent or more in total
of the remaining wall area
is open and unrestricted

30 percent or more in total
of the remaining wall area
is open and unrestricted

Figure F4 - Outdoor Area - Example 4

Minimum Enclosed Area Ventilation

If you are still experiencing difficulty with the appliance after trying the above solutions, the appliance
should not be used until it has been inspected and repaired by a suitably qualified person.

AGA APPROVED No: 8205G

Model No: OZ2210

IMPORTANT: Read these instructions for use carefully. Familiarise yourself with the appliance
before connecting it to its gas container. Keep these instruc tions for future reference.

LEISURE PRODUCTS

Portable Gas Stove

Instruction Manual

www.oztrail.com.au

CM2270

Piezo-Electric

325mm (W) x 274mm (D) x 91mm (H)

1.5kg

Safety Governor System/Pressure Sensitive Safety Device

230g/h (11.3MJ/h) (nominal)

Campmaster Butane

0.65mm

Gas Type

Fuel Consumprion

Safety Device

Weight

Dimensions

Ignition Method

Model No.

Injector Size

OZ2210

Fuel Consumption

210g/h (10.5MJ/h) (nominal)

Butane

OZ2210-2015-08-19 V1

ONE YEAR WARRANT Y

OZtrail warrants this product agai nst defects for a period of o ne year from the date of purchase. OZtrail
will repair or replace the produc t, at its discretion, should a war rantable defect arise withi n the warranty
period. If the exact m odel is unavailable a model of equiv alent nature will be substituted at our dis cretion.
This warranty excludes fau lts and failures caused by imprope r use and abuse; fair wear and tear; or failu re
to follow instructions rega rding care and maintenance. Product s used for a commercial nature are not
covered by this warranty against d efects. A warranty may be c laimed by returning the product to i ts place
of purchase, with a detailed pro of-of-purchase clearly showin g the date and detail of the purchase.
You may also contact OZtrail Leisure Products, by p hone: [phone], or in writing: PO Box 1110, Eagle
Farm BC, 4009, QLD, AUSTRALIA, by email: wa [e-mail] . The benefits under OZtrail’s warr anty
against defects are in ad dition to other rights and remedies u nder law in relation to goods.

Our goods come with guarantees t hat cannot be excluded under the Austr alian Consumer Law. You are
entitled to a replacement or refu nd for a major failure and for compensa tion for any reasonably foreseeab le
loss or damage. You are also entitled to have the goo ds repaired or replaced if the good s fail to be of
acceptable quality and the f ailure does not amount to a major failure.

For more detailed information and an explanation of these terms see www.oztrail.com.au/warrant y

OZTrail Leisure Products

71 Charles Ulm Place
EAGLE FARM, QLD, 4009, AUSTRALIA
TEL: [phone]
Made in China