OWI INC
USER MANUAL
OWI
AMP-CAT INSTRUCTIONS
Models
IN-CEILING SPEAKERS
2X2 DROP-IN CEILING SPEAKERS
P-SERIES
NepTune
IN-WALL AMPLIFIER
NOTE: This manual applies also to all the model names listed above.
Established 1978
OWI Incorporated
17141 Kingsview Ave. Carson CA 90746-1207 USA
Tel. 310-515-1900 Fax 310-515-1606
info@owi-inc.com
www.owi-inc.com
Technical Support 310-515-1900
OWI User Manual: Model AMP-CAT Amplified Speaker Series
PROPRIETARY NOTICE
The OWI Inc. product information and design disclosed herein were originated by and are the property of OWI
Inc. OWI Inc. reserves all patent, proprietary design, manufacturing, reproduction, use and sales rights thereto,
and to any article disclosed therein, except to the extent right(s) are expressly granted to others.
COPYRIGHT NOTICE
This manual is Copyright 2014 by OWI Inc. All rights reserved. Reproduction in whole or in part without written
prior permission from OWI, Inc. is prohibited.
UNPACKING AND INSPECTION NOTICE
Immediately upon receipt of the equipment, inspect the shipping container and the contents carefully for any
discrepancies or damage. Should there be any, notify the freight company and OWI, Inc. or the dealer where
purchased at once.
LIMITED WARRANTY
1. This product has been thoroughly tested and inspected at the factory. It is warranted for one year from the
date of purchase.
IT IS THE OWNERS’ RESPONSIBILITY TO ESTABLISH THE DATE OF PURCHASE BY ACCEPTABLE
EVIDENCE AT TIME SERVICE IS SOUGHT.
2. Any unit, which in the judgment of OWI INC, is defective or develops defects under normal use will be replaced
or repaired without cost within the warranty period.
3. This warranty will be considered void if the unit is dropped, misused, abused and altered in any manner,
overdriven with excess amplification exceeding manufacturer’s specification, improperly serviced or
accidentally damaged.
4. OWI Inc. shall have no liability whatsoever for consequential damages. The sole responsibility at the discretion
of OWI Inc. under this warranty shall be limited to the repair of the product or replacement thereof. Any and all
implied warranties including the implied warranty of merchantability are limited to the duration of this express
limited warranty.
OWI, Inc. is NOT liable for incidental or consequential damages of any kind.
5. IMPORTANT: This warranty is void unless the attached card is completed and mailed to OWI Inc. within 10
days following the date of purchase. Units must be sent to OWI Inc. or to the dealer where purchased.
RETURN SHIPPING INSTRUCTIONS, Obtain a RETURN AUTHORIZATION from:
OWI Inc., 17141 Kingsview Ave, Carson, CA 90746.
Phone (310) 515-1900, Fax (310) 515-1606
FCC Notice: This equipment has been tested and found to comply with the limits for a Class A digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful
interference when the equipment is operated in a commercial environment. This equipment generates, uses, and
can radiate radio frequency energy and, if not installed and used in accordance with the instruction manual, may
cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to
cause harmful interference in which case the user will be required to correct the interference at his or own
expense.
Modifications not expressly approved by the manufacturer could void the user’s authority to be operated under
FCC rules.
8-23-2018
OWI INC. 2 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
Description
Page
Proprietary, Copyright Notices
2
Unpacking and Inspection
2
Warranty Information
2
Return Shipping Instructions
2
Table of Contents
3
Important Safety Instructions
4 - 5
Introduction
6
Specifications
7 - 8
Illustration: Connection and Control
9
Chained Self Amplified Speakers Wiring
10
One, Two Speaker Combination Wiring
11
Input Connectors Wiring
12
AMP-CAT Wiring Diagram
13
2X2FG-CAT Integration
14
Volume Control Wiring Diagram
15
Installation
17 – 20
Warranty
21
Back Cover
22
Table of Contents
8-23-2018
OWI INC. 3 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
IMPORTANT SAFETY INSTRUCTIONS
____________________________________________________________________________________________________
CAUTION
RISK OF ELECTRIC SHOCK - DO NOT OPEN
____________________________________________________________________________________________________
NOTE: Installation is to be completed by a qualified electrical technician according to NEC/CEC code and
applicable local codes.
CAUTION: The power supply is not to be used in air handling spaces.
CAUTION: To reduce the risk of electric shock: Do not remove the cover or back: No user-serviceable
parts inside: refer servicing to qualified personnel.
The lighting flash with arrowhead within an equilateral triangle is intended to alert the user to the
presence of uninsulated “dangerous voltage” within the product’s enclosure that may be of sufficient
magnitude to constitute a risk of electric shock to persons.
The exclamation point within an equilateral triangle is intended to alert the user of the presence of
important operating and maintenance (servicing) instructions in the literature accompanying the
appliance.
The apparatus shall not be exposed to dripping or splashing and that no objects filled with liquids, such
as vases, shall be placed on the apparatus.
IMPORTANT SAFETY INSTRUCTIONS
1. Read these instructions. All the safety and operation instructions should be read before this OWI
product is operated.
2. Keep these instructions - The safety and operating instructions should be kept for future reference.
3. Heed all warnings - All warnings on this product and in these operating instructions should be
followed.
4. Follow all instructions - All operating and other instructions should be followed.
5. Do not use this apparatus near water - for example, near a bathtub, washbowl, kitchen sink, laundry
tub, in a wet basement, near a swimming pool, or a swamp.
6. Clean only with dry cloth.
7. Do not block any ventilation openings. Install in accordance with the manufacturer’s instructions. This OWI product should be situated so that its location or position does not interfere with its proper
ventilation. For example, the component should not be situated on a bed, sofa, rug, or similar surface
that may block any ventilation openings, or placed in a built-in installation such as a bookcase or
cabinet that may impede the flow of air through ventilation openings.
8. Do not install the unit near any heat sources such as radiators, heat registers, stoves or other
apparatus (including amplifiers) that produce heat.
8-23-2018
OWI INC. 4 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
9. Do not defeat the safety purpose of the polarized or grounding-type plug. A polarized plug has two
blades with one wider than the other. A grounding type plug has two blades and a third grounding
prong. The wider blade or the third prong is provided for your safety. If the provided plug does not fit
into your outlet, consult an electrician for replacement of the obsolete outlet.
10. Protect the power cord from being walked on or pinched particularly at plugs, convenience
receptacles, and the point where they exit the apparatus.
11. Only use attachment/accessories specified by the manufacturers.
Portable Cart Warning
12. Use only with the cart, stand, tripod, bracket or table specified by the manufacturer, or sold with the
apparatus. When a cart is used, use caution when moving the cart/apparatus combination to avoid
injury from tip-over.
13. Unplug this apparatus during lightning storms or when unused for long periods of time.
14. Refer all servicing to qualified service personnel. Servicing is required when the apparatus has been
damaged in any way, such as power-supply cord or plug is damaged, liquid has been spilled or
objects have fallen into the apparatus, the apparatus has been exposed to rain or moisture, does not
operate normally, or has been dropped. The user should not attempt to service this OWI product
beyond those means described in this operating manual. All other servicing should be referred to the
OWI Service Department.
15. WARNING: To reduce the risk of fire or electric shock, do not expose this apparatus to rain or
moisture.
16. To prevent electric shock, do not use this polarized plug with an extension cord, receptacle or other
outlet unless the blades can fully be inserted to prevent blade exposure.
17. Exposure to extremely high noise levels may cause permanent hearing loss. Individuals vary
considerably in susceptibility to noise-induced hearing loss, but nearly everyone will lose some
hearing if exposed to sufficiently intense noise for a period of time. The U.S. Government’s
Occupational Safety and Health Administration (OSHA) has specified the permissible noise level
exposures shown in the following chart. According to OSHA, any exposure in excess of these
permissible limits could result in some hearing loss. To ensure against potentially dangerous
exposure to high sound pressure levels, it is recommended that all persons exposed to equipment
capable of producing high sound pressure levels use hearing protectors while the equipment is in
operation. Ear plugs or protectors in the ear canals or over the ears must be worn when operating the
equipment in order to prevent a permanent hearing loss if exposure is in excess of the limits set forth
here.
18. OWI recommends that this apparatus be placed on a switched power outlet, one that switches both
sides and has contact separation of at least 3 millimeters.
End of IMPORTANT SAFETY INSTRUCTIONS
8-23-2018
OWI INC. 5 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
SPECIFICATIONS
AMP-CAT on Ceiling SPEAKER
Speaker Diameter
5 or 6.5 inches
Weight of Amplifier/Speaker Assembly
2.85 - 3.15 pounds
Height of Amplifier/Speaker Assembly
4.5 inches
Backcan “Suitable for use in air handling spaces”
UL Listed Enclosure
Tile Bridge “Suitable for use in air handling spaces”
UL Listed Support Truss
ELECTRICAL AMPLIFIER
SPECIFICATIONS
AMP-CAT
Input voltage, nominal
(15 watts) 15 volts DC
Input current, operating (15VDC)
1.45 amperes peak
Input volt-amperes, peak (15VDC)
22 volt-amperes
Input voltage, maximum
16.5 volts, DC
Frequency Response,
EQ set to flat
20Hz to 20 kHz
Bass
NA
Treble
NA
THD + Noise
<1% at 13.5 watts, “A” weighted
S/N
>82 dB
Max Power Output (28V in)
25 watts
DC Power, Standby
1.4 watts
AC Power, Sleep Mode
1.4 watts
Introduction
The OWI AMP-CAT is a two source integratable self-powered speaker/amplifier. This amplified speaker can drive up
two (2) additional speakers connected series parallel to have a net impedance of 8 ohms. With an included UL Listed,
Level 5 (Energy Star), 15-volt, 3.5 ampere power supply, the amplifier can output 15 watts, or 7.5 watts per speaker in
a 2-speaker hook-up.
Special features of the OWI Model AMP-CAT include:
TWO (2) audio inputs: Stereo 3.5 Mini Jack Line Input, Cat 5 input for OWI Products only
Input # 1 Stereo 3.5 Mini Jack Line Input - The JACK LINE IN accepts unbalanced input via 3.5 mini jack. The stereo
channels are summed together. This input is muted when the Priority Override is in use.
Input # 2 Cat 5 input - Proprietary Cat 5 input for OWI Products only. Use only with OWI MC4. Future models will
work with the OWI AMPSTVCW volume control.
Power Amplifier Features
The power amplifier outputs 15 watts at 4 ohms and 15VDC power. The class D power amplifier has reduced radiated
electromagnetic interference (EMI) due to a special feature of the power amplifier, operating in a patented spread
spectrum. The power amplifier protects itself from over-temperature, over-current, over-voltage conditions. The power
amplifier will shut itself down during these conditions.
IMPORTANT NOTE! This amplifier is intended for audio use only! Continuous sine wave drive into a load will
cause the amplifier to shut itself down when it heats up.
SPECIFICATIONS (MODEL AMP-CAT)
Mechanical “UL rating is dependent upon use of the BACKCAN and Tile Bridge”
8-23-2018
OWI INC. 6 www.owi-inc.com
DC Power,
Short Circuit protected
Yes
Over current protected
Yes
Over voltage protected
Yes
Over temperature protected
Yes
Minimum Load Impedance
4.0 Ω (Two 8 Ω Speakers in parallel)
Minimum Input impedance, RJ45 in
150,000 Ω
Minimum Input impedance, mini-jack
37,000 Ω
Warranty
1 year
PS15VDC35AL5
SPECIFICATIONS
Input
100 to 240 VAC, 50-60 Hz, 1.4A
Note: Be sure to use the correct polarity on the power input.
Output
15 VDC, 3.5 amperes
Wire gauge and length
Minimum 18 gauge up to 40 feet maximum length
Electrical, Power Supply
UL Listed, Level 5 (Energy Star)
Weight
0.45 pounds
Size
4.7”H x 2”W x 1.2”D
POWER SUPPLY
CAUTION: The Power Supply is not to be used in air handling spaces.
*Note: Maximum power requires the replacement of the 15 volt supply with a 22 volt supply and Energy Star and
UL approvals no longer apply.
Power Supply Wire Gauge and Length - Minimum 18 gauge up to 40 feet maximum length
PS15VDC35AL5 Grounding Illustration
OWI User Manual: Model AMP-CAT Amplified Speaker Series
8-23-2018
OWI INC. 7 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
NON-AMPLIFIED SPEAKER
SPECIFICATIONS
SPECIFICATIONS
IC6
IC5
DESCRIPTION:
6.5", 2-way, coaxial
5", 2-way, coaxial
IMPEDANCE:
8 ohms
8 ohms
SENSITIVITY (1W/1M):
86 dB
85 dB
DISPERSION:
120 degrees
120 degrees
MAX POWER (8 Ohms)
50 watts
40 watts
NOMINAL POWER (8 Ohms)
25 watts
20 watts
FREQUENCY RESPONSE:
65Hz ~ 20 kHz
80Hz ~ 20 kHz
WOOFER SIZE:
6.5"
5"
WOOFER MATERIAL:
Paper, PP coated
Paper, PP coated
TWEETER SIZE:
0.5"
0.5"
TWEETER MATERIAL:
PEI
PEI
GRILL MATERIAL:
Aluminum
Aluminum
OVERALL DIMENSIONS (Diameter X Height): Inches
Φ 8.93*3.45
Φ 7.95*3.15
CUT OUT SIZE (Diameter): Inches
Φ 7.68
Φ 6.61
WEIGHT: lbs.
2.5
2.26
MOUNTING HARDWARE:
Mounting Clamps
Mounting Clamps
End of Specifications
Neptune In Ceiling Speakers 2x2 Drop Ceiling
AMP-CAT-NEP AMP-CATIC5 AMP-CAT602-1W
AMP-CATIC6
------------------------------------------------------------------------------------------------------------------------------
Front and back of the of Double Gang Box Amplifier P-SERIES
AMP-CAT-1SGB AMP-CAT-602
8-23-2018
OWI INC. 8 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
REV A
3.5 mm
Stereo
input
CAT5 Balanced
Input from OWI
products only
Volume
Control
3.5 mm
output
CAT5 Output to
another OWI
CAT SERIES
Amplifier
3.5 mm
Output
Only 1 will
be here
Power 15V DC
3.5 AMPS
Bass
Treble
3.5 SIGNAL
Gain Control
Output
to
another
Illustration: Connection and Control
AMP-CAT TO ANOTHER AMP-CAT SPEAKER WIRING SINGLE LINE DIAGRAM
8-23-2018
OWI INC. 9 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
VOLUME CONTROL WIRING DIAGRAM
8-23-2018
OWI INC. 10 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
INSTALLATION
NOTE: Installation is to be completed by a qualified electrical technician according to
NEC/CEC code and applicable local codes.
Speaker Placement
Before installing your OWI speakers, consider the placement carefully, taking into effect the
location of electrical, plumbing and other fixtures.
Placement in Ceiling
OWI speakers should be located above the primary listening area.
Mounting your OWI speakers
Determine the best area to mount your OWI speakers. It will be necessary to run your speaker
wires to that location. This location must be free of obstructions, such as electrical conduits,
HVAC ducts, or water lines.
Be sure the mounting surface is between 3/8 and 1 ¼ inches thick and that there is at least a
3inch clearance behind the mounting surface (5 inch if using an OWI backcan). Make sure that
no objects block the back of the speaker.
Remove the round cardboard disc from the template supplied and keep it for later use as a
paint mask, if you decide to paint your speakers.
Use the template to mark the position for the mounting hole at the selected location. If you are
not certain that no obstruction exists (electrical wiring, plumbing, etc.), you should start by
cutting a small hole in the center of your penciled mounting hole with a drywall or keyhole saw,
cutting at a 45 degree angle towards the inside of the hole. Cutting a small hole at this angle
will make drywall repair much easier. Once you have determined there are no obstructions in
your desired mounting location, start cutting the finished hole at a 90 degree angle to the
ceiling surface.
Route the speaker wires from your amplifier to your opening. Avoid routing the speaker wire
near electrical wires. If you have to run them parallel, make certain to space the speaker wires
at least 2 feet from the AC line. Do not nail or staple the speaker wire.
8-23-2018
OWI INC. 11 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
Prepare Your OWI Speakers for Mounting
Insert a paper clip into one of the grille openings, then pull upwards to remove the grille.
Turn the mounting tab 90° and push toward the grill. The grill will safely pop off.
Be sure to position the four Mounting Tabs on your OWI speaker inward then insert the
four (4) screws (supplied) from the front of the speaker into the screw opening.
8-23-2018
OWI INC. 12 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
8-23-2018
OWI INC. 13 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
OWI SPEAKER SYSTEM LIMITED WARRANTY REGISTRATION
(Save this portion for your records)
1. Your OWI Speaker System has been thoroughly tested and inspected at the factory.
It is warranted for 1 year from date of purchase.
IT IS THE OWNERS’ RESPONSIBILITY TO ESTABLISH THE DATE OF PURCHASE BY
ACCEPTABLE EVIDENCE AT TIME SERVICE IS SOUGHT.
2. WHAT WE WILL PAY FOR AND WHAT YOU MUST PAY FOR:
OWI INC. will repair or replace unit(s) covered by this warranty, without charge to the consumer for
labor or materials. YOU ARE RESPONSIBLE FOR ANY INSTALLATION OR REMOVAL CHARGES
AND FOR ANY INITIAL SHIPPING CHARGES if the unit(s) must be shipped for warranty service.
However, we will pay the return shipping charges to any destination within the U.S.A. if the repairs are
covered by the warranty.
3. Any unit which in the judgment of OWI Inc. is defective or develops defects under normal use will be
replaced or repaired without cost within the warranty period.
4. This warranty will be considered void if unit has been dropped, misused, abused, altered in any
manner, overdriven with excessive amplification exceeding manufacturer’s specification, improperly
serviced or accidental damage.
5. OWI Inc. shall have no liability whatsoever for consequential damage. The sole responsibility and
discretion of OWI Inc. under this warranty shall be limited to the repair of the product or replacement
thereof.
8-23-2018
OWI INC. 14 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
6. IMPORTANT: This warranty is void unless the attached card is completed and mailed to OWI Inc.
within 10 days following the date of purchase. Units must be sent to OWI Inc. or to the dealer where
purchased.
OWI INCORPORATED Date Purchased: ________________________
17141 Kingsview Ave Model Number: ________________________
Carson, CA 90746-1207 USA Serial Number: ________________________
(Keep this part for your record)
-------CUT AND MAIL----------------------------------------------------
OWI INCORPORATED
17141 Kingsview Ave
Carson, CA 90746-1207 USA
LIMITED WARRANTY
Model Number:_________________________________
Model Name: __________________________________
Serial No. _____________________________________
Date of Purchase: Month: __________ Day ____ Year ______
Owner’s Name: ______________________________________
Address: ________________________________________
City: _______________________ State __________ Zip_______
Dealer’s Name: _________________________ City______________ State ________
Purchased from (please check one):
Video ____, Electronic ____, Mailorder ___, Mass Merchandiser ___, Installer ___
Others (please specify) __________________________________________________
Remarks: _____________________________________________________________
_____________________________________________________________________
8-23-2018
OWI INC. 15 www.owi-inc.com
OWI User Manual: Model AMP-CAT Amplified Speaker Series
Established 1978
OWI Incorporated
17141Kingsview Ave. Carson CA 90746-1207 USA
Tel. 310-515-1900 Fax 310-515-1606
www.owi-inc.om
8-23-2018
OWI INC. 16 www.owi-inc.com
Loading...