Outdoor Lifestyles ODVILLAG-36T, ODVILLAG-36H, ODVILLAG-42T, ODVILLAG-42H Installation Manual
Pour demander un exemplaire
Installation Manual
Installation and Fireplace Setup
en français de ce Manuel
du propriétaire, visitez www.
heatnglo.com/translations.
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
Model(s):
ODVILLAG-36T ODVILLAG-36H
ODVILLAG-42T ODVILLAG-42H
Outdoor Decorative Gas Appliance
WARNING
HOT SURFACES!
Glass and other surfaces are hot during
operation AND cool down.
Hot glass will cause burns.
• DO NOT touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same area as
replace.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other ammable
materials.
• Keep clothing, furniture, draperies and other ammable
materials away.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open ame.
• If odor continues, leave the area immediately.
• After leaving the area, call your gas supplier or re
department.
• Failure to follow these instructions could result in re
or explosion, which could cause property damage,
personal injury, or death.
WARNING
Do not store or use gasoline or other ammable vapors and liquids in the vicinity of this or any other
appliance
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
WARNING: For outdoor use only.
Installation and service must be performed by a
qualied installer, service agency, or the gas supplier.
WARNING: Improper installation, adjust-
ment, alteration, service or maintenance can cause
injury or property damage. Read the installation,
operating and maintenance instructions thoroughly
before installing or servicing this equipment.
WARNING: If the information in this manual
is not followed exactly, a re or explosion may
result causing property damage, personal injury, or
loss of life.
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
This appliance is only for use with the type(s) of gas indicated
on the rating plate. This appliance is not convertible for use
with other gases, unless a certied kit is used.
NOT for use with solid wood fuel.
1
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the replace or to property.
Table of Contents
1 Welcome
A. Congratulations 4
Listing Label Information/Location 4
B. Warranty 5
2 Product Specic & Important Safety Information
A. Appliance Certication 7
B. BTU Specications 7
C. Non-Combustible Materials 7
D. Combustible Materials 7
E. High Altitude Installations 7
3 Getting Started
A. Design and Installation Considerations 8
Moisture Resistance 8
B. Inspect Appliance and Components 8
4 Framing and Clearances
A. Appliance Dimension Diagram 9
B. Clearances to Combustibles 10
C. Constructing the Appliance Enclosure 11
D. Vent Termination Minimum Clearances 12
E. Securing and Leveling the Appliance 13
F. Non-Combustible Material Installation 13
5 Gas Information
A. Fuel Conversion 14
B. Gas Pressure 14
C. Gas Connections Provision 14
D. High Altitude Installations 15
E. Air Shutter Setting 15
6 Finishing
A. Facing Material 16
B. Mantel and Wall Projections 17
C. Good Faith TV Guidelines 18
7 Appliance Setup
A. Remove the Shipping Materials 20
B. Clean the Appliance 20
D. Install Gas Hearth Kit (provided) 20
E. Install Mesh Door (optional) 20
8 Maintenance and Service
9 Reference Materials
A. Service Parts 22
►
B. Accessories 28
C. Contact Information 29
2 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
Comments communicated to party responsible
• Photographing the installation and copying this checklist for your file.
Combustible materials not installed in non-combustible areas.
Appliance Install
Required non-combustible board is installed (if applicable). (Pg. 13)
Verified all clearances meet installation manual requirements.
Mantels and wall projections comply with installation manual requirements.
Started appliance and verified no gas leaks exist.
Manual bag and all of its contents are removed from the fireplace and given to the party
The enclosure is sealed. (Pg. 8)
Verified clearances to combustibles. (Pg. 10)
Appliance is leveled and secured. (Pg. 12)
ATTENTION INSTALLER:
• That this checklist remain visible at all times on the fireplace until the installation is complete.
All packaging and protective materials removed.
Optional mesh doors properly installed.
Refractory, logs, media and embers installed correctly.
__________________________ by ______________________on _________
(Builder/Gen. Contractor) (Installer) (Date)
Comments:
Follow this Standard Work Checklist
This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this installation
manual.
Customer:
Lot/Address
Model (circle one): ODVILLAG-36T
ODVILLAG-36H
ODVILLAG-42T
ODVILLAG-42H
WARNING! Risk of Fire or Explosion! Failure to install fireplace according to these instructions can lead to a fire
or explosion.
Finishing Section 6 (Pg. 16)
Date Installed:
Location of Appiance
Installer:
Dealer/Distributor Phone #
Serial #:
YES IF NO, WHY?
Appliance Setup
responsible for use and operation.
Hearth & Home Technologies recommends the following:
Section 7 (Pg. 18)
Further description of the issues, who is responsible (Installer/Builder/Other Trades, etc.) and corrective action needed:
4072-171 • Rev B • 09/28/15
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
3
Welcome
1
Read this manual before installing or operating this replace.
Please retain this owner’s manual for future references.
A. Congratulations
Congratulations on selecting a Outdoor Lifestyles decorative gas appliance. The HHT gas appliance you have
selected is designed to provide the utmost in safety and
reliability.
As the owner of a new gas appliance, you'll want to read
and carefully follow all of the instructions contained in this
Owner's Manual. Pay special attention to all Cautions and
Warnings.
Local Dealer Information
This Owner's Manual should be retained for future reference. We suggest that you keep it with your other impor-
tant documents and product manuals.
Your new Outdoor Lifestyles decorative gas appliance will
give you years of durable use and trouble-free enjoyment.
Outdoor Lifestyles is a registered trademark of Hearth &
Home Technologies.
DEALER: Fill in
your name, address,
phone and e-mail
information here and
replace information
Dealer Name: ________________________________________________________
Address: ____________________________________________________________
____________________________________________________________
below.
Phone: _____________________________________________________________
E-mail: _____________________________________________________________
Fireplace Information:
Brand: ________________________________________________ Model Name: ___________________________
Serial Number: __________________________________________ Date Installed: __________________________
Listing Label Information/Location
The model information regarding your specic replace can be found on the
rating plate usually located in the control area of the replace.
Serial
Number
This appliance must be installed in accordance
with local codes, if any; if not, follow ANSI
Outdoor Lifestyles by
Hearth & Home Technologies
7571-215th St. West, Lakeville, MN 55044
Outdoor decorative gas appliance - for
outdoor use only. Not for use with solid fuel.
(Foyer au gaz à évacuation - pour
installation à l'extérieur seulement. Ne doit
pas entre utilise avec un combustible solide.)
WARNING! Improper installation, adjustment, alteration, service or mainte-
!
nance can cause property damage, personal injury or loss of life. Refer to the
owner’s information manual provided with this appliance. Installation and service
must be performed by a qualified installer, service agency, or gas supplier.
AVERTISSEMENT! Une installation, un ajustement, une modification, un
!
service ou un entretien inadéquats peuvent causer des dommages matériels, des
blessures corporelles ou des pertes de vie. Consultez le manuel d'information
du propriétaire fourni avec cet appareil. L'installation et le service doivent être
effectués par un installateur qualifié, une agence de service ou un fournisseur de
gaz.
This product is covered by one or more of the following patents: (Nos produits sont couverts par un ou plusieurs des brevels suivants): (United States) 4,112,913; 4,408,594; 4,422,426; 4,424,792; 4,520,791; 4,793,322; 4,852,548; 4,875,464; 5,000,162; 5,016,609; 5,076,254; 5,191,877;
5,218,953; 5,328,356; 5,429,495; 5,452,708; 5,542,407; 5,613,487; (Australia) 543790; 586383; (Canada) 1,123,296; 1,297,746; 2,195,264; (Mexico) 97-0457; (New Zealand) 200265; or other U.S. and foreign patents pending (ou autres brevets americains et etrangers en attente).
Z223.1 in the USA installation codes.
MH61458
Natural Gas Propane Gas
Min. Gas Supply for Input Adj.: . . . . . . . . . . 5.0 in. w.c. (1.24 kPa) . . . . . . . 11.0 in. w.c. (2.74 kPa)
Max. Gas Supply . . . . . . . . . . . . . . . . . . . . . 10.0 in. w.c. (2.49 kPa) . . . . . . 13.0 in. w.c. (3.23 kPa)
Max. Input (36 in.): . . . . . . . . . . . . . . . . . . . 40,000 BTU/hr (11.72 kW) . . . .40,000 BTU/hr (11.72 kW)
Max. Input (42 in.): . . . . . . . . . . . . . . . . . . . 42,000 BTU/hr (12.31 kW) . . . .42,000 BTU/hr (12.31 kW)
!
WARNING! DO NOT store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the vicinity of
this or any other appliance.
AVERTISSEMENT! Ne pas entreposer ni utiliser de l’essence ni d’autres
!
vapeurs ou liquides inflammables dans le voisinage de l’appareil, ni de tout
autre appareil.
Une bouteille de propane qui n’est pas raccordée en vue de son utilisation,
ne doit pas être entreposée dans le voisinage de cet appareil ou de tout
autre appareil.
ANSI Z21.97-2017
CSA 2.41-2017
Outdoor Decorative
Gas Appliances
Model
(Modele):
Fireplace
Model
Serial (Serie):
Mfg. Date:
MADE
IN USA
ODVILLAG-36T
ODVILLAG-36H
ODVILLAG-42T
ODVILLAG-42H
4072-166D
4 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
B. Warranty
Outdoor Lifestyles by Hearth & Home Technologies™
Limited Lifetime Warranty
Hearth & Home Technologies (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™
brand products (“Products”) that are purchased from an HHT authorized dealer.
WARRANTY COVERAGE:
HHT warrants to the original owner of the Product at the site of installation, and to any transferee taking
ownership of the Product at the site of installation within one year following the date of original purchase,
that the Product will be free from defects in materials and workmanship at the time of manufacture. After
installation, if covered components manufactured by HHT are found to be defective in materials or
workmanship during the applicable warranty period, HHT will, at its option, repair or replace the covered
components. This warranty is subject to conditions, exclusions and limitations as described below.
WARRANTY PERIOD:
The warranty period begins on the earlier of: (i) the date of invoice for the Product;
(ii) in the case of new home construction, the date of first occupancy of the residence or six months after
the date of sale of the Product by an HHT authorized dealer, whichever occurs first; or (iii) the date 24
months following the date of Product shipment from HHT, regardless of the invoice or occupancy date.
WARRANTY CONDITIONS:
• The Limited Lifetime Warranty covers Products that are purchased through a HHT authorized
dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites.
• This warranty is only valid while the Product remains at the site of original installation.
• Contact your installing dealer for warranty service. If the installing dealer is unable to provide
necessary parts, contact the nearest HHT authorized dealer. Additional service fees may apply if
you are seeking warranty service from a dealer other than the dealer from whom you originally
purchased the Product.
• Check with your dealer in advance for any costs to you when arranging a warranty call. Travel
and shipping charges for parts are not covered by this warranty.
• The Product body, metal firebox and heat exchanger carry the Limited Lifetime Warranty from the
date of installation.
• The following components do not carry the Limited Lifetime Warranty but are warranted as follows:
o One Year from Date of Installation:
▪ Gas and Electrical Components or Gaskets
▪ Nickel Plated Materials
• Excludes tarnishing
▪ Glass Breakage, Logs/Refractory/Glass Panels due to thermal breakage
• Surface, hairline cracks, scratches and slight color changes are not covered
▪ Venting, optional accessories, optional glass doors
▪ Labor Associated with Warranty Service Work
WARRANTY EXCLUSIONS:
This warranty does not cover the following:
• Changes in surface finishes as a result of normal use. As a heating appliance, some changes in
color of interior and exterior surface finishes may occur; this is not a flaw and not covered under
warranty.
• Damage to printed, plated, or enameled surfaces caused by fingerprints, accidents, misuse,
scratches, melted items, or other external sources and residues left on surfaces from the use of
abrasive cleaners or polishes.
• Repair or replacement of parts that are subject to normal wear and tear during the warranty
period. These parts include: paint, firebricks, grates, flame guides and the discoloration of glass.
• Minor expansion, contraction, or movement of certain parts causing noise. These conditions are
normal and complaints related to this noise are not covered by this warranty.
Outdoor Lifestyles Warranty - 2108-975C – 6/5/2019 - 1
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
5
• Damages resulting from: (1) failure to install, operate, or maintain the Product in accordance with
the installation instructions, operating instructions, and listing agent identification label furnished
with the Product; (2) failure to install the Product in accordance with local building codes; (3)
shipping or improper handling; (4) improper operation, abuse, misuse, continued operation with
damaged, corroded or failed components, accident, or incorrectly performed repairs; (5) inadequate ventilation, negative pressure or environmental conditions, including, without limitation:
hail, snow, ice, fallen branches, flooding, water damage and fading of color; (6) use of fuels other
than those specified in the operating instructions; (7) installation or use of components not
supplied with the Product or any other components not expressly authorized and approved by
HHT; (8) modification of the Product not expressly authorized and approved by HHT in writing;
and/or (9) interruptions or fluctuations of electrical power supply to the Product.
• Non-HHT venting components, hearth components or other accessories used in conjunction with
the Product.
• Any part of a pre-existing fireplace system in which an insert or a decorative gas appliance is
installed.
• The Product’s capability to heat the desired space. Information is provided to assist the consumer
and the dealer in selecting the proper appliance for the application. Consideration must be given
to the Product’s location and configuration and environmental conditions.
This warranty is void if:
• The Product has been over-fired or operated in atmospheres contaminated by chlorine, fluorine,
or other damaging chemicals. Over-firing can be identified by, but not limited to, warped plates or
tubes, rust colored cast iron, bubbling, cracking and discoloration of steel or enamel finishes and
cracking or spalling of refractory or cementitious materials.
• The Product is subjected to prolonged periods of dampness, condensation, ice or snow.
• There is any damage to the Product or other components due to water or weather damage
which is the result of, but not limited to, improper chimney or venting installation.
LIMITATIONS OF LIABILITY:
Repair or replacement in accordance with the provisions of this warranty will be the owner’s exclusive
remedy for and will constitute HHT’s sole obligation under this warranty, under any other warranty
(express or implied), or in contract, tort or otherwise; provided, however, that if HHT is unable to provide
repair or replacement in an expedient and cost effective manner, HHT may discharge all such obligations
by refunding the purchase price of the Product. No employee, agent, dealer, or other person is authorized
to give any warranty on behalf of HHT. TO THE EXTENT ALLOWED BY LAW, HHT MAKES NO OTHER
WARRANTY, EXPRESS OR IMPLIED, INCLUDING ANY WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE. HHT WILL NOT BE LIABLE FOR ANY CONSEQUENTIAL
OR INCIDENTAL DAMAGES ARISING OUT OF DEFECTS IN OR USE OF THE PRODUCTS. Some
states do not allow exclusions or limitation of incidental or consequential damages, so these limitations
may not apply to you. This warranty gives you specific rights; you also may have other rights, which vary
from state to state. The duration of any implied warranty is limited to the duration of the warranty period
specified herein.
Outdoor Lifestyles Warranty - 2108-975C – 6/5/2019 - 2
6 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
Product Specic & Important Safety Information
2
A. Appliance Certication
MODELS: ODVILLAG-36T, ODVILLAG-36H,
ODVILLAG-42T, ODVILLAG-42H
LABORATORY: Underwriters Laboratories Inc. (UL)
TYPE: Outdoor Decorative Gas Appliance
STANDARD: ANSI Z21.97-2012/ CSA 2.41-2012
This product is listed to ANSI standards for outdoor decorative gas appliances.
Outdoor Lifestyles is a registered trademark of Hearth &
Home Technologies.
When an appliance is for connection to a xed piping
system, the installation must conform with local codes,
or in the absence of local codes with the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, or International Fuel
Gas Code.
B. BTU Specications
This appliance is listed for use with the outdoor decorative hearth kit supplied.
Maximum allowable BTU ratings:
Unit Max BTU/HR
ODVILLAG-36 40,000
ODVILLAG-42 42,000
E. High Altitude Installations
NOTICE: If the heating value of the gas has been reduced,
these rules do not apply. Check with your local gas utility or
authorities having jurisdiction.
When installing above 2000 feet elevation:
• In the USA: Reduce input rate 4% for each 1000 feet
above 2000 feet.
• In CANADA: Input ratings are certified without a
reduction of input rate for elevations up to 4500 feet
(1370 m) above sea level. Please consult provincial and/
or local authorities having jurisdiction for installations at
elevations above 4500 feet (1370 m).
Check with your local gas utility to determine proper
orice size.
WARNING: This product and the
fuels used to operate this product (liquid
propane or natural gas), and the products
of combustion of such fuels, can expose
you to chemicals including benzene, which
is known to the State of California to cause
cancer and reproductive harm. For more
information go to: www.P65Warnings.
ca.gov.
C. Non-Combustible Materials
• Materials which will not ignite and burn, composed of
any combination of the following:
- Steel - Iron
- Brick - Tile
- Concrete - Slate
- Glass - Plasters
• Materials reported as passing ASTM E 136, Standard
Test Method for Behavior of Metals, in a Vertical Tube
Furnace at 750° C
D. Combustible Materials
• Materials made of or surfaced with any of the following
materials:
- Wood - Compressed paper
- Plant bers - Plastic
- Plywood/OSB - Sheet rock (drywall)
• Any material that can ignite and burn; ame proofed or
not, plastered or un-plastered
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
Installation and service of this appliance should be performed by
NOTE: Installation and repair should be done by a qualied
person. The appliance should be inspected before use
and at least annually by a qualied person. More frequent
cleaning may be required as necessary. It is imperative
that the control compartment, burners, and circulating air
passageways of the appliance are kept clean.
7
Getting Started
3
A. Design and Installation Considerations
These appliances must be installed outdoors.
Outdoor spaces - For the purpose of these instructions, an appliance is considered to be outdoors if installed with shelter no
more inclusive than:
1. With walls on all sides, but no overhead cover
2. Within a partial enclosure which includes an overhead cov-
er and no more than two side walls. These side walls may
be parallel, as in a breezeway, or at right angles to each
other; or
3. within a partial enclosure which includes an overhead cover
and three sidewalls, as long as 30 % or more of the horizon-
tal periphery of the enclosure is permanently open.
NOTE: Screen may be used on the open sides of the shelter.
14x18 and 16x18 screen mesh is approved for use. DO NOT
use solar screen or no-see-um screen.
CAUTION
Check building codes prior to installation.
The appliance will not perform as an exterior wall. Moisture penetration must be considered for construction that
places the appliance in structure walls or on moisture
sensitive surfaces.
When installed on exterior walls: Hearth & Home
Technologies recommends that the appliance enclosure
be constructed outside the structure’s weather envelope.
Where the platform meets the wall, use a ashing detail
similar to that required for attached decks. Enclosure
platforms, including hearths should slope away from the
structure at 1/8 in. to 1/4 in. per foot. The appliance can
be shimmed level.
When installed on surfaces where water may collect
or cause damage: Hearth & Home Technologies recom-
mends that a drainage pan be placed under the unit. This
can be constructed of metal, adhesive polymer membrane (such as ice and water shield) or other suitable
materials. A means of drainage out of the pan such as
tubes or weep holes should be provided. A slope of 1/8 in.
to 1/4 in. per foot towards the drain port is suggested. The
appliance can be shimmed level.
Hearths should slope away from the front of the appliance
and enclosure at 1/8 in. to 1/4 in. per foot.
• Installation MUST comply with local, regional,
state and national codes and regulations.
• Consult insurance carrier, local building, fire
ofcials or authorities having jurisdiction about
restrictions, installation inspection, and permits.
Installation MUST comply with local, regional, state and
national codes and regulations. Consult the authorities
having jurisdiction over restrictions, installation inspection
and permits.
Before installing, determine the following:
• Where the appliance is to be installed.
- Clearance to side walls
- Location of indoor appliance terminations, air inlets, gas
meters, etc.
- Doors
- Location of the replace to a door that swings open to
ensure it does not interfere with the replace when opened
- Windows
- Walkways
- Wires
- Possibility of ooding or running water
• Gas supply piping requirements.
• Electrical wiring requirements.
• Framing and nishing details.
Moisture Resistance
This outdoor gas appliance will shed moderate amounts
of water, but is not waterproof. Water and condensing
water vapor may enter the enclosure under certain condi-
tions.
8 Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
B. Inspect Appliance and Components
• Remove the appliance and components from the
packaging and inspect for damage.
• Report any parts damaged in shipment to your dealer.
• Read all the instructions before starting the
installation. Follow these instructions carefully
during the installation to ensure maximum safety
and benet.
WARNING! Risk of Fire or Explosion! Damaged parts
could impair safe operation. DO NOT install damaged, incomplete or substitute components. Keep alliance dry.
Hearth & Home Technologies disclaims any responsibility for, and the warranty will be voided by, the following
actions:
• Installation and use of any damaged appliance.
• Modication of the appliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Improper positioning of the gas logs.
• Installation and/or use of any component part not
approved by Hearth & Home Technologies.
Any such action may cause a re hazard.
WARNING! Risk of Fire or Explosion! DO NOT use this
appliance if any part has been under water. Call a qualied
service technician to inspect the appliance and to replace
any part of the gas control system which has been under
water.
Framing and Clearances
4
A. Appliance Dimension Diagram
Dimensions are actual appliance dimensions. Use for reference only. For framing dimensions and clearances refer to Figures
4.2, 4.3, 4.4, 4.5, 4.6.
ODVILLAG-36
39 1/2 in.
1003 mm
9 1/4 in.
235 mm
7 1/2 in.
191 mm
21 3/8 in.
543 mm
48 1/4 in.
1226 mm
GAS
KNOCKOUT
68°
23 3/4 in.
603 mm
36 in.
914 mm
41 1/8 in.
1045 mm
7 5/8 in.
194 mm
19 3/4 in.
502 mm
20 7/8 in.
530 mm
7 5/8 in.
194 mm
7 1/2 in.
191 mm
9 1/4 in.
235 mm
GAS
KNOCKOUT
ODVILLAG-42
39 1/2 in.
1003 mm
9 1/4 in.
235 mm
7 1/2 in.
191 mm
21 3/8 in.
543 mm
48 1/4 in.
1226 mm
GAS
KNOCKOUT
68°
29 3/4 in.
756 mm
42 in.
1067 mm
47 1/8 in.
1197 mm
7 5/8 in.
194 mm
19 3/4 in.
502 mm
20 7/8 in.
530 mm
7 5/8 in.
194 mm
GAS
KNOCKOUT
7 1/2 in.
191 mm
9 1/4 in.
235 mm
Figure 4.1 Appliance Dimensions
Outdoor Lifestyles • Villa Gas Owners/Installation Manual • 4072-204 • Rev G • 02/21
9
Loading...