Outdoor GreatRoom Company CF-1242AU-N, CF-1242AU-LP, CF-20AU-N, CF-20AU-LP User Manual
Page | 1 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
CF-1242AU
User Manual for: CF-1242AU-N, CF-1242AU-LP
CAUTION
DO NOT DISCARD THIS MANUAL
• Important operating and
maintenance instructions
included.
• Read, understand, and
follow these instructions
for safe installation and
operation.
WARNING
WARNING
If the information in these instructions
is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
• DO NOT USE OR STORE FLAMMABLE MATERIALS
NEAR THIS APPLIANCE.
• DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS
APPLIANCE
• What to do if you smell gas:
Do not try to light any appliance
Do not touch any electrical switch. Do not use
any phone in your building.
Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
Instructions.
If you cannot reach your gas supplier, call the fire
department.
• Installation and service must be performed by authorized
personnel.
HOT! DO NOT TOUCH.
SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass and other surfaces are hot during
operation and cool-down.
• Keep children away.
• CAREFULLY SUPERVISE children near this
appliance.
• Alert children and adults to hazards of high
temperatures.
• DO NOT PLACE ARTICLES ON OR AGAINST THIS
APPLIANCE.
• PRIMARILY A DECORATIVE APPLIANCE- NOT
CERTIFIED AS A SPACE HEATER
WARNING
For outdoor use only
WARNING
It is imperative the burner be kept clean. Keep
covered when not in use. Do not operate in rainy
conditions. Optional glass burner cover available for
purchase
WARNING
Improper installation, adjustment, alteration, service, or
maintenance can cause injury or property damage.
DO NOT
MODIFY THIS APPLIANCE.
Read the installation and
maintenance instructions thoroughly before installing or
servicing this equipment.
THE GUARD IS FITTED TO THIS APPLIANCE TO
REDUCE THE RISK OF FIRE OR INJURY FROM
BURNS AND NO PART OF IT SHOULD BE REMOVED
Page | 2 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
CF-
1242
AU
Outdoor Gas Fire Pit Burner
Certification #:
Gas Type
: LPG: NAT. GAS:
Manufacturer
The Outdoor GreatRoom
Company LLLC 2015
2015 Silver Bell Rd
Eagan MN USA
55122
Gas input
76.0
MJ/h
76.0
MJ/h
Injector size
2.5mm
6.3mm
Inlet Pressure
2.75
kPa 1.13
kPa To be installed by an
authorized person in
accordance to appliance
installation instructions.
Test point pressure
1.75 kPa .5 kPa
IAPMO
- R&T OCEANA
Approval No:
GMK10110
Approval No: code
AS4558 &
AS4565
Notes: Automatic controls/ battery powered fire pit to be installed a
nd used
outdoors only in a well-ventilated area.
Serial #
Date of MFR:
Read this manual before installing or operating this appliance.
Please retain this owner’s manual for future reference.
Congratulations
Congratulations on selecting an Outdoor GreatRoom Company decorative gas appliance. The fire pit burner you
have selected is designed to provide the utmost in safety, reliability, and efficiency.
As the owner of an Outdoor GreatRoom Company fire pit, you’ll want to read and carefully follow all of the
instructions contained in this owner’s manual. Pay special attention to all cautions and warnings.
This owner’s manual should be retained for future reference. We suggest you keep it with other important
documents and product manuals.
This information contained in this owner’s manual applies to the CF-1242AU only.
Your new fire pit will give you years of durable use and trouble-free enjoyment.
Listing Label Information/Location
The model information regarding your specific appliance can be found on the rating plate attached to your
burner via a metal chain. See the sample rating plate below for locations of specifications.
WARNING:
All gas supp
lies must be hard
-
piped to the fire pit. In situations where liquid
propane is used, the fuel storage location must be further than 1 meter from the fire pit.
Never
store fuel inside fire pit.
Page | 3 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
‘
Table of Contents
1. Listing and Code Approvals
a. Appliance certification
b. Specifications
2. Getting Started
a. Design and installation considerations
b. Tools and supplies required
c. Inspection of appliance and components
3. Framing Clearances
4. Appliance setup
a. Burner assembly
b. Glass installation
5. Gas hookup and information
a. Fuel
b. Gas pressure
c. Gas connection
d. LP gas setup
e. Natural gas setup
6. Lighting and Operation
7. Troubleshooting
8. Service and Maintenance
9. Reference Materials
a. Service Parts List
b. Dimensional Information
c. Checking Test Point Pressure
d. Wiring Diagram
e. Limited One Year Warranty
CF-1242AU-N
• 305mm x 1067 burner assembly
• Natural Gas Regulator
• 6.3 mm Injector (NG)
• 3 bags of decorative fire glass
• Flexible metal gas line
• Owner’s Manual
• Glass Guard*
What’s included…
CF-1242AU-LP
• 305mm x 1067 burner assembly
• 2.5mm Injector( Home LP)
• 3 bags of decorative fire glass
• Flexible metal gas line
• Owner’s manual
• Glass Guard kit*
* The Glass Guard fitted to this appliance is to reduce the risk of fire or injury from burns and no part of it
should be removed.
Page | 4 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
1
Listing and Code
A. Appliance Certification B. Specifications
MODEL: Crystal Fire
– CF-1242AU-N, CF-1242AU-LP
TYPE: Decorative Gas-Fired Outdoor Fireplace
Burner
STANDARD: AS4558 & AS4565
Crystal fire burner has been tested in accordance
with IAS requirements for Outdoor Gas Fireplaces,
AS4558 & AS4565
and operation as described in
these installation and operating instructions.
The installation must conform to
AS/NZ5601.1 and
local codes.
Model
Injector Size
LP
NG
CF-
1242AU-
N/LP
2.5mm
Max input
MJ
76 MJ
76 MJ
6.3mm
Page | 5 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
2
Getting Started
This appliance is a Decorative Gas Appliance for
OUTDOOR USE ONLY
and
MUST NOT
be used
for cooking.
Build or position the CF-1242AU burner system on
a flat and stable surface in an outdoor location such
as a patio or deck. This location must be adjacent to
the gas supply line or LP gas supply.
DO NOT
locate the appliance where it will get excessively
wet or submerged in water.
A. Design and Installation Considerations
When planning an appliance installation, it’s necessary to
determine the following information before installing:
•
Where will the appliance be installed? See section 3
•
Gas supply piping. See section 5
•
Framing and finishing details. See section 3
B. Tools and Supplies Required
Before beginning the installation, be sure that the
following tools and supplies are at hand.
•
Gloves
•
Safety Glasses
•
Phillips screwdriver
•
Non-corrosive leak-check solution
•
Wrenches
WARNING
The Outdoor GreatRoom Company
disclaims any responsibility for, and
the warranty will be voided by, the
following actions:
•
Installation and use of any damaged
components.
•
Modification of the burner assembly
•
Installation other than as instructed
by the Outdoor GreatRoom
Company.
Any such action may cause a fire hazard
WARNING
Do NOT use this appliance if any part of it has
been underwater. Have an authorized service
technician inspect the appliance and replace
any part of the control system and any gas
control which has been underwater.
CAUTION
Sharp Edges
Wear protective gloves and safety glasses
during installation.
WARNING
Do not burn solid fuels in this gas appliance
C. Inspect the Appliance and Components
WARNING
Inspect appliance and components for
damage. Damaged parts may impair safe
operation.
•
Do NOT install damaged, incomplete,
or substitute components
Report damaged parts to your dealer.
WARNING
Asphyxiation Risk
•
This gas appliance is for outdoor use in a
well-ventilated space.
•
This unit must not be installed inside an
enclosed structure or unvented appliance
•
Carefully remove all burner
components from packaging.
•
Read all instructions before beginning
installation. Follow these instructions
carefully during installation to ensure
maximum safety and benefit.
Page | 6 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
Clearances above the top burner surface
3
Framing and Clearances
Note:
•
Illustrations reflect typical installations
and are FOR DESIGN PURPOSES ONLY.
•
Illustrations/diagrams are not drawn to
scale.
•
Actual installation may vary due to
individual design preference.
•
THIS APPLIANCE SHALL NOT BE
INSTALLED OR USED INDOORS
Fire Risk
Provide adequate clearance:
•
Around air openings
•
For service access.
Locate appliance away from traffic areas
WARNING
1.8M to overhang from
top
of metal bowl.
.6M .6M
1.8M
If you are not using an
Outdoor GreatRoom
Company table with
this burner, be sure to
mount to a non-
combustible surface
maintaining at least
.2M to combustible
surfaces and framing
below the surface of
burner.
.2M
.2M
.2M
.2M
.2M
BURNER
Walls
Minimum clearance to side
combustibles- 500mm
Minimum clearance to ceiling
combustibles- 1375mm
All materials within the
clearance areas must be
noncombustible and
structurally sound.
Surrounding areas allowed:
Four sided room with no ceiling and at least 10 meters square
Two sided room with ceiling, two sides open 50%
Three sided room 25% open with ceiling and 30% of the three side wall
unobstructed.
750mm above ground
Glass Guard
(required)
Page | 7 www.outdoorrooms.com CF-1242 AU Rev-E 8/24/15
DIAGRAMMATICAL REPRESENTATIONS OF OUTDOOR AREAS.
The following figures are diagrammatical representations of outdoor areas as
described in the definition Clause 1.2.49. Rectangular areas have been used
in these figures – the same principles apply to any other shaped area.
This appliance shall only be used in an outdoor area, and shall not be used in a building,
garage, or any other enclosed area.
This appliance shall only be used in an above ground open
-
air situation with natural
ventilation, without stagnant areas, where gas leakage and products of combustion are
rapidly dispersed by wind and natural convection.
Loading...