Page 1
The QTC-2+
is a three cartridge water treatment system
Snapshot
Food servi ce F i ltra tion Syste ms
with three 15” Qwik-Twist cartridges, plumbed series/
parallel, that reduces sediment down to 0.5 micron and
reduces chlorine, taste & odor at a ow rate of 4.5 gpm
for 45,000 gallons. The system includes a ve micron
PolyTrix Qwik-Twist pre- lter for added protection on water
supplies with excessive dirt and sediment. The system
also reduces turbidity and health-related contaminants
such as cysts.
Model: QTC-2+
Part #: 160-51007
ITEM #: __________________ QTY: ________
JOB NAME/NUMBER_____________________
System Bene ts
l
Improves the quality and consistency of cold and hot
beverages.
• Provides ‘primary’ ltration for combination applications
including cold and hot beverages and ice makers.
l
Reduces maintenance frequency and cost, and extends
equipment life.
l
Five micron Polytrix Qwik-Twist pre lter provides added
protection against excessive sediment found in some
water supplies.
l
Gradient-density depth ltration reduces dirt, rust, and
other debris as small as 1/2 micron to assure clean,
clear water and protect solenoids, valves and other
ttings against wear and plugging.
l
High capacity activated carbon ltration makes water
taste great and protects equipment against corrosive
chlorine.
l
Reduced sediment, chlorine and taste & odor can improve
beverage ingredient ef ciency.
l
White powder-coated mounting bracket and full- ow inlet
shut-off valve makes installation simple.
l
Built-in pressure gauge allows visual monitoring of
operating pressure.
l
1/4 turn QT “Qwik-Twist” bayonet cartridges make
changing the lters quick, easy and sanitary.
Application
FOUNTAIN BEVERAGES - Up to 150 bag-in-box per
month / two carbonators. Includes QT Pre- lter for
water supplies with high turbidity levels.
COMBINATION APPLICATIONS - Provides primary
ltration for multiple points-of use.
Installation Tips
l
Feed-water connection to system should be COLD only.
l
Do not exceed system speci cations for temperature
and pressure.
l
Allow 3” clearance below system for lter cartridge
removal and replacement.
l
Detailed installation, operation & maintenance manual
is included with each system.
l
No activation procedure or ushing is required for
system to perform as speci ed.
• Improves equipment operating ef ciency.
l
NSF Certi ed under Standard 42 & 53.
Page 2
Model: QTC-2+
Food serv ice F iltr ation Sys tems
Part #: 160-51007
Specications
System
Dimensions
(Height x Width X Depth, inches)
Connection - Inlet & Outlet 3/8” NFPT
Operating Pressure Range 10-125 psi
Inlet Water Temperature Range 35o -100
Shipping Weight 19 lbs.
Performance
Chlorine, Taste and Odor
Reduction Capacity
Service Flow Rate 4.5 gpm
Sediment Reduction .5 micron
Reduces Harmful Cysts
Reduces Turbidity
Optional Flush Valve Kit - Part #: 160-52912
21 x 14.3 x 7
(0.7 -8.6 bar)
o
F
o
(2o -38
C)
45,000 gals.
(170,325 liters)
(17 lpm)
(nominal)
Model QTC-2+ is tested and certied
by NSF International against NSF/ANSI
Standard 42 for the reduction of:
Standard 42: Aesthetic Effects,
Chlorine Reduction
Taste and Odor Reduction
Nominal Particulate Reduction, Class 1
Standard 53: Health Effects,
Mechanical Filtration
Cyst & Turbidity Reduction
Dealer/Distributor Info:
Replacement Cartridge(s)
Model Part Number Qty
S5-Q 300-05802 1
XTO-Q 300-05840 2
It is recommended that lters be changed every six
months, when capacity is reached or when efuent
pressure or ow becomes inadequate.
This product is for commercial use only and must be
installed
and maintained according to manufacturers
guidelines.
Do not use on water that is microbiologically unsafe or of
unknown quality without adequate disinfection before or
after the system.
Warranty
Systems have a 3 year warranty against defects in
material and workmanship. Contact OptiPure customer
service or go to the OptiPure website for a copy of the
warranty.
OptiPure, Mfg. by Procam Controls, Inc.
2605 Technology Dr., Bldg 300
Plano, TX 75074
p: 972.881.9797; f: 972.422.6262
www.optipurewater.com
QTC2+spec109
Loading...