Ocean Blue OBLU1013 Owner Manual

1

VACUUM CLEANER

USER’S MANUAL

2

WELCOME

Welcome to the clean world of OceanBlue!

Dear Customer:

Thank you for your confidence in our product. It is our goal to bring you into the clean world of
OceanBlue. If you have been using a “Conventional” cleaning system for dirt removal you might be in for
a surprise!

If you find that you are having to empty the water pan more often than you think that you should, be

aware that, in the beginning, you are picking up more dirt because of the deep dirt that is in your
carpets that was not removed before. After using the OceanBlue for a short time in regular use, you
should find that the amount of dirt will taper off to more “normal” expectations.

You should be aware that deep dirt is the enemy of carpets. The deep dirt left in the carpet acts like little
knives and slowly cuts the tufts of the carpets at the bottom as you walk on the carpet. You may see a

lot of “fuzz” coming up from the carpet in the beginning, but by removing this deep dirt, you are

increasing the life of your carpet.

Remember that the OceanBlue filtration system does not clog up the airflow as you use it. You still have

full power right up to when to empty the water pan.

TABLE OF CONTENTS

Index ........................................................................................................................... 2 - 3

Optional Accessories………………………………………………………………………………………………..3

Technical Specifications .............................................................................................. 4

Get to Know the Parts of Your OceanBlue Vacuum Cleaner .......................................... 5

Important Safety Instructions ........................................................................................ 6

General Precautions and Recommendations ................................................................ 7

Precautions when Vacuuming Liquids .......................................................................... 7

Special Care and Safety Instructions ............................................................................ 8

Servicing of Double Insulated Appliances .................................................................... 8

HydroTurbine Care…………………………………………………………………………………………………… 9
Operation and Handling……………………………………………………………………………………………. 10
Water container/HydroTurbine………………………………………………………………………………… 11

Using the attachments…………………………………………………………………………………...... 12

Hose…………………………………………………………………………………………………………………… 13

3

Using your Vacuum…………………………………………………………………………………………….. 14

Warranty …………………………………………………………………………………………………………….. 15

Troubleshoot ……………………………………………………………………………………………………… 16
For Service and Repair ……………………………………………………………………………………………. 17

OPTIONAL ACCESSORIES

Prolux Storm: The Prolux Storm has incorporated an electronically driven brush roll to this

universal shampoo system. This design allows the shampoo system to agitate the surface which
improves cleaning ability exponentially. This model works just like your regular power nozzle
does, so all you must do is fill it up, and vacuum like you normally would.

Offers much higher power output than other shampooers on the market and offers self-adjusting
brush roll height so you can easily move between surfaces. The self-adjusting design is
exceptionally convenient when using on tile because it allows the brush roll to drop into and
scrub grouted areas.

OceanBlue Water Based Air Purifier: This works as a humidifier, deodorizer, purifier,

aromatherapy and fragrance machine. For aromatherapy or to use as an air freshener, add a
few drops of fragrance into the water bowl and turn on.

This OceanBlue also works as an humidifier by pushing moisture into the air and leaving the
impurities behind in the water bowl to
be disposed of. The best park is that this
purifier does not over dispense
moisture, so you will never have to
worry about water left behind and is
safe to use in any area!

Stair Pro Electric Mini Turbo: Quick

connect button lock to attach to your
wand or vacuum handle. Brush roll is
powered by durable electric motor and
a geared belt that will last the lifetime
of the tool. If you have pet hair you
need to vacuum up this is a must! Not
only do they last for many years but
they deep clean better than almost
anything!

4

TECHNICAL SPECIFICATIONS

• Major Housing Components: ABS plastic, min. thickness 3mm. UL flammability rating:

UL94-HB. Water pan: Top, ABS; bottom, copolyester.

• Agency recognition: UL fi le number E-303875

• Electrical characteristics:

• 120 volt

• Amp, max, 7.6

• Watt, max, 846

• RPM, working, 17,300

• Sealed vacuum, 68”

• CFM, working, 56.8

• CFM, max, 98

• Nano Silver Tech

• Motor rating, Class A

• Basic machine weight: 6.4 Kg (no water); 8.0 Kg (w/water)

5

GETTING TO KNOW THE PARTS

1. Power Button 16. Suction Relief Valve

2. Hose/Cord Hanger 17. Tool Hose/Wet Pickup

3. Blower Output on Back 18. Mini Turbo w/Spinning Brush roll

4. Water Bowl Latch 19. Handheld Shampoo

5. Friction Fit Caddy (Also Holds Tools) 20. Blower/Coil Cleaner

6. Water Basin 21. 32 mm Tool Kit

7. Power Hose Plug

8. Electric Main Hose

9. Power Head Switch

10. Handle Release

11. Extendable Wand Button

12. Wand Release Pedal

13. Electric Power Nozzle

14. Rubber Bumper

15. Pivot Release

6

IMPORTANT SAFETY INSTRUCTIONS

When using an electrical appliance, basic precautions should always be followed, including the following: READ

ALL INSTRUCTIONS BEFORE USING THIS APPLIANCE WARNING: To reduce the risk of fire,

electric shock, or injury:

1. The switch used for controlling the appliance must be pushed to start and pushed to stop.

2. This appliance is for indoor use only. Do not store in wet places.

3. This appliance is for household use only.

4. DO NOT let children use the OceanBlue without adult supervision. This appliance is not a toy.

5. DO NOT leave appliance unattended when plugged in. Unplug from outlet when not in use and before

emptying the water container.

6. USE ONLY as described in this manual. Use only manufacturer’s recommended attachments.

7. DO NOT use with damaged cord or plug. If appliance is not working as it should, has been dropped,

damaged, left outdoors, or dropped into water, return it to a service center.

8. DO NOT pull or carry by the cord, use cord as a handle, close a door on cord, or pull cord around sharp

edges or corners. Do not run appliance over cord. Keep cord away from heated surfaces.

9. DO NOT unplug by pulling on cord. To unplug, grasp the plug, not the cord.

10. DO NOT handle plug or appliance with wet hands.

11. DO NOT put any objects into openings. Do not use with any opening blocked; keep free of dust, lint, hair

and anything that may reduce air flow.

12. KEEP HAIR, loose clothing, fingers, and all parts of body away from openings and moving parts.

13. USE EXTRA care when cleaning on stairs.

14. NEVER use to pick up flammable or combustible liquids such as gasoline or use in areas where they may

be present. See section PRECAUTIONS WHEN VACUUMING LIQUIDS.

15. ALWAYS turn off this appliance before connecting or disconnecting either hose or motorized nozzle

(optional).

16. TURN OFF all controls before unplugging.

17. This appliance is provided with DOUBLE INSULATION. Use only identical replacement parts. See
instructions for SERVICING OF DOUBLE INSULATED APPLIANCES.

18. DO NOT pick up anything that is burning or smoking, such as cigarettes, matches or hot ashes.

19. Before turning on this appliance, make sure the machine is tightly secured by the clamps to the water
container. Failure to do this could cause a risk of injury to persons and would defeat the utility of the
appliance.

20. Your OceanBlue is provided with a safety interlock switch to prevent operating the appliance without
attaching the water container to the appliance. Because the turbine operates at high speed, this is to
protect you from coming into contact with the moving HydroTurbine.

7

GENERAL PRECAUTIONS & RECOMMENDATIONS

IMPORTANT

Please read all instructions before using this machine and keep this manual always at hand.

Follow the instructions manual for the Ocean Blue‘s. Do not try to use it otherwise. The use of

non-authorized accessories by OceanBlue could be dangerous. See section SERVICING OF
DOUBLE INSULATED APPLIANCES.

• DO NOT plug the OceanBlue into the receptacle of an incandescent light bulb, nor use
extensions cords with less electrical capacity than needed.

• The OceanBlue must not be used to clear sewers. An explosion may occur if the machine
suctions sewer gases.

• You must NEVER touch a metallic kitchen sink or washbasin or water pipelines with one
hand while holding the machine with the other hand. The danger is greater if the

person’s skin is wet.

• Take special care when cleaning stairs.

• ATTENTION: It is not recommended to use the OceanBlue for cleaning chimneys or open
stoves, or other devices that have oil or grease, for example, soot or ashes, clay dust,
plaster or other similar materials that are resistant to water action. It must not be used
for vacuuming toxic or volatile substances or near any of these.

PRECAUTIONS WHEN VACUUMING LIQUIDS

Always consider the following precautions:

• DO NOT operate the machine with wet hands or feet or barefoot.

• NEVER use OceanBlue to clean up liquids outdoors, upon an earth floor.

• NEVER vacuum liquids with OceanBlue when you are stepping on water or a wet floor. If
it should be necessary to step on a wet or damp floor to pick up water, do not touch the
metallic parts of ANY electric device, lamp or switch while performing this operation.

• DO NOT carry the machine with your hand while using the machine for cleaning
operations.

• The water container must be empty before you begin picking up liquids. DO NOT
vacuum more than 1.9 liters (2 quarts); the water level MUST NEVER be above the
central post. Excess water in the water container will cause shaking and vibration. If this
occurs, the vibrations are your warning that the water container is overfilled. (If you
have a need to pick up more than 2.5 liters of water frequently, consider the optional 4­liter water container shown on page 18.)

8

SPECIAL CARE & SAFETY INSTRUCTIONS

WATER: Do not operate the OceanBlue for too long without changing the water. When

you notice that the water is getting too full of dust and fuzz, throw it away and replace it
with clean water. The correct level of water is that of the height of the central post of
the water container.

WATER CONTAINER: When you finish cleaning your house, be
careful to put away the OceanBlue‘s motor apart from the water
container between uses. ALWAYS empty the water container after
each use.

THE HYDROTURBINE IS THE HEART OF YOUR MACHINE Unplug the
OceanBlue from the power outlet. Remove and clean the
HydroTurbine after each use. Wash it inside and out with water and
soap, using the brush provided. Dry it and put in place again. Tighten
the nut by hand until the fl at surface of the HydroTurbine is
properly adjusted. Do not over tighten, as the HydroTurbine
automatically tightens upon starting the machine. The HydroTurbine

is the key for separating the dirty water from the airflow and proper

care is important for the performance of your appliance. If the
HydroTurbine should become damaged (CHIPPED OR BROKEN), replace the
HydroTurbine with a factory made turbine from your Service Center. WARNING: The
OceanBlue must NEVER be used without the HydroTurbine. Always place it back after
cleaning it.

SERVICING OF DOUBLE INSULATED APPLIANCES: For your safety and protection, your
OceanBlue is a DOUBLE INSULATED appliance. NEVER attempt service on the electrical
parts of the appliance EXCEPT at your OceanBlue Service Center. There are special
requirements for servicing DOUBLE INSULATED appliances. Failure to do so can cause
safety hazards with your unit.

9

HYDROTURBINE CARE

10

OPERATION AND HANDLING

General guidelines for using OceanBlue:

Fill up the water container with cold water until it almost covers the top of the central post:

correct quantity of water 2.365 liters (2.5 quarts). (fig.1)
The motor unit is placed on top of the water container (fi g.2). The air intake should be lined up

with the notch in the motor unit. The edge of the motor unit should be firmly rest on the top of

the water container and be inside of the retaining ring for correct location, otherwise, the
machine will not work. Engage the two clamps and raise the upper part of the clamps together.
Place the machine on top of the wheeled base. Note: The clamps will not operate properly if

the motor unit is not in the proper position on the water container. If the clamps do not
operate easily, check the location of the motor unit.

Insert the plastic wand into the curved wand with the OceanBlue hose (fi g.3) until the button
fits in place. Insert the plastic end of the OceanBlue hose into the vacuum air intake as shown
(fi g.4), rotating it to right. To disconnect, rotate it to the left and pull it towards you.

11

WATER CONTAINER / HYDROTURBINE

To empty the water container:

1. Release both clamps by pulling the
upper part of the clamp assembly down
and remove motor.

2. Pickup the water container by the
vacuum intake end and empty the water.

3. Place the heavier particles in the
bottom of the water container in a trash
can (such as wet fuzz)

4. Wash, rinse and dry the water
container

5. Keep the motor apart from the
water container until next use.

Care of HydroTurbine:

Take out the turbine after each use and
wash it inside and out with water and
soap, using the special supplied tool. Dry
it and put it back in its place. Tighten the
nut by hand until the turbine is seated
and the rim is flush with the rim of the
metal casting of the motor. Do not over
tighten, as the HydroTurbine
automatically tightens up on starting the
machine.

WARNING: The HydroTurbine must always be positioned back in its place immediately after
you clean it. Do not operate the machine without the HydroTurbine.

12

Using The Attachments

Floor Tool (Fig 1): Soft natural fill which supports the brush over hard floors and makes it

easily maneuverable over uneven surfaces, without damaging the finish. It has wide cleaning
opening which captures large debris and delivers effective cleaning power to the far edges of
the tool.

Duster Brush (Fig 2): The Dusting Brush is used for all types of furniture.

Crevice Tool (Fig 3): Use for cleaning radiators, cracks & crevices along corners, and

baseboards and in-between cushions.

Upholstery Tool (Fig 4): Designed to clean the dirt that becomes embedded in your

furniture and limits the life of the fabric. The tool also comes with slide on bristles, so you can
use it on hard furniture, dusting or to add a more aggressive surface to your tool which can help
in removing pet hair that is entangled in your fabric.

Mini Turbo (Fig 5): This is the best pet hair tool in the business! Perfect tool for upholstery,

stairs and hard to reach places. This is the deluxe model with a geared belt which reduces
slippage and increases the life of your tool. Brush roll is designed to sweep debris to middle of
head for easy pick up. The swiveling bottom plate allows you to use this on your floors as well.
Fits nearly any standard vacuum.

HandHeld Shampooer (Fig 6): This attachment

works great for those small areas that your regular
sized shampooer system is just too big for. Works
great in the car, on rugs, throw pillows, and
furniture.

Blower/Coil Cleaner (Fig 7): This attachment is

a high end tool that works great for cleaning hard to
reach areas. The bristle attachment makes it
especially easy to reach under washer/dryer, behind
your fridge and even in your vents! This tool also
works great as an inflator and detailing blower on
vacuums with blower option.

13

HOSE

Use to vacuum dry and wet materials on
floor, walls, tapestries, electro-domestic
devices, air conditioning ducts, clothes,
etc.

To clean and/or to dry the interior of the hose and of the
stainless curved wand:

1. Remove the discharge air cover of the OceanBlue

vacuum cleaner and introduce the plastic end of the
hose in it as shown.

2. Then connect the other end of the hose into the

vacuum air intake. Turn on the motor and shake the
hose. Any stuck material in the interior of the hose will
be suctioned and submerged into the water container;
OceanBlue’s hose will also become completely dry,
after vacuuming water.

3. This procedure can also be used before using your

OceanBlue hose for any blowing operation.

14

USING YOUR VACUUM

REMEMBER THE FOLLOWING WHEN USING YOUR VACUUM CLEANER:

The functioning of your new cleaning equipment greatly depends on the maintenance given at
home. Only use your OceanBlue equipment according to the instructions provided in this
manual.

• Before using the machine pick up by hand any hard or sharp objects such as pins,

hairpins, thumbtacks, pieces of pencil, etc. that could harm the spinning brush roll.

• Do not lubricate the motor. The motor has permanent lubrication and is sealed.

• Shut down the machine before connecting hose.

• Do not use the machine to clean chimneys, open stoves, or other materials containing

oils, grease, soot, ashes, clay dust, plaster or other water-resistant materials.

• It must not be used either to vacuum volatile or toxic substances, nor to be operated

near them.

• SERVICING OF DOUBLE-INSULATED APPLICANCES

• A double-insulated appliance is marked with one or more of the following: The words

“DOUBLE INSULATION” or “DOUBLE INSULATED” or the double insulation symbol

(square within a square) .

• In a double-insulated appliance, two systems of insulation are provided instead

of grounding. No grounding means its provided on a double-insulated
appliance, nor should a means for grounding be added to the appliance.
Servicing a double-insulated appliance requires extreme care and knowledge
of the system and should be done only by qualified service personnel.

• Replacement parts for a double-insulated appliance must be identical to the

parts they replace.

All service operations, other than cleaning, must be done by an authorized service
agent of OceanBlue.

15

FIVE (5) YEAR LIMITED WARRANTY

(90 days on the motor and body if used commercially)

Prolux warranties this product’s motor free from defects in material and workmanship for a period of five
(5) years on the motor, and two (2) year bumper-to-bumper limited warranty on the body of the vacuum,
free from manufacturer defects in material and workmanship from the original date of purchase, when
utilized for normal household use.

(90 days on the motor and body if used commercially)

Subject to the following conditions, exclusions, and exceptions:

What is Not Covered by the Prolux Warranty - Warranty Exclusions. This limited warranty does not extend to
and expressly excludes:

1. Normal wear and tear and/or replacement attachments or accessories, including, without limitation,
extension cords, hoses, filters, switches, carbon motor brushes and other attachments to the Backpacks.

2. Damage or burnout of the Backpack or Canister motor resulting from failure to clear a blockage occurring
during the normal course of use.

3. Loss or damage to the Backpack or Canister resulting from conditions beyond the control of Prolux including
without limitation, misuse, accidents, abuse, neglect, negligence from the customer, overuse beyond capacity of
the vacuum, or unauthorized modification and/or alteration.

4. Loss or damage to the Backpack or Canister resulting from failure to follow the required maintenance
schedule, or failure to use the Backpack or canister in accordance with written instructions from Prolux,
guidelines or the terms of its Owner’s Manual.

If your appliance fails to operate properly while in use under normal household conditions within the
warranty period, please contact your authorized PROLUX dealer you purchased the unit from. Non­durable parts including, without limitation, filters, accessories, brushes, belts, and electrical parts, which
normally require replacement, are specifically excluded from warranty.

This warranty is limited solely to the cost of the repair or replacement of the unit at Prolux’s option. This

warranty does not cover normal wear of parts and does not apply to any unit that has been tampered (by
unauthorized user) with or used for commercial purposes. This limited warranty does not cover damage
caused by shipping damage, misuse, abuse, negligent handling, or damage due to faulty packaging or
mishandling in transit.

This warranty is extended to the original purchaser of the unit only and is not transferable.

*IMPORTANT:
Before sending unit back for warranty work, contact your authorized PROLUX retailer you bought
the unit from first. Unauthorized warranty claims may be sent back.

Authorized Warranty claims: PROLUX shall be responsible for all parts and labor and the
customer shall be responsible for all shipping charges to and from the PROLUX service center.

Prolux is constantly striving to improve our products. Therefore, the specifications contained herein are
subject to change without notice.

16

Troubleshooting

WARNING: Never use a defective appliance. Always switch off the appliance and disconnect it from the

outlet or remove the battery before you start to troubleshoot.

Fault

Possible Cause(s)

Solution

The vacuum will not turn on.

The plug is not connected to the
electrical wall outlet or the
appliance is not switched to the
“on” position.

Insert the plug into an electrical
wall outlet and flip the “on/off”
switch to the “on” position. See
section “Vacuum Cleaning.”

Electrical wall socket does not
carry current.

Test the vacuum cleaner on
another outlet that you are sure
is carrying current.

The power cord is damaged.

Replace with a new cord by an
authorized service center or
professional technician.

Suction power is low.

The water basin is full or clogged.

Empty/clean the water basin.

The power nozzle, attachment
wand or suction hose is clogged.

Remove the debris that is
causing the clog. If necessary,
use a long wooden stick (e.g. a
broomstick) or coat hanger to do
this.

The water basin container is
installed incorrectly.

Remove water basin container
and reinstall; making sure the
container is locked into place
when reinstalling.

The tool attachment being used,
does not work properly on the
surface you are vacuuming.

Attach the appropriate tool for
the surface you are vacuuming.
See pages 8-9.

The vacuum makes unusual
noises or is louder than usual.

The power nozzle, attachment
wand, or the suction hose are
clogged.

Remove any clogs. If necessary,
use a long wooden stick (e.g. a
broomstick) or coat hanger to do
this.

17

FOR SERVICE AND REPAIRS

To locate a dealer in your area, call 1-800-619-1006

Please visit www.oceanblue.com for complete warranty information.

DEALER

STICKER

HERE