OAKWORKS WOMEN’S IMAGING, GENERAL WITH FOWLER, GENERAL, MULTI-SPECIALTY, ECHOCARDIOGRAPHY Instruction Manual
...
INSTRUCTION MANUAL
OAKWORKS®
Dual Tower Ultrasound Tables
MULTI-SPECIALTY
GENERAL
WOMEN’S IMAGING
GENERAL WITH FOWLER
ECHOCARDIOGRAPHY
GENERAL 3-SECTION
VASCULAR VASCULAR WITH FOWLER
www.oakworksmed.com · 717.235.6807
made in the USA
with US & imported parts
© Copyright 2010
OAKWORKS
®
, Inc.
Manual Part Number
MMMNST0018
English, Printed in USA
All rights are reserved. No part
of this document may be
photocopied, reproduced or
translated to another language
without prior written consent
of OAKWORKS
OAKWORKS
trademark of OAKWORKS®, Inc.
®
, Inc.
®
is a registered
Notice
The information contained in this
document is subject to change
without notice and should not
be construed as a commitment by
OAKWORKS
®
, Inc.
OAKWORKS®, Inc. assumes no
responsibility for any errors that
may appear in this document nor
does it make expressed or implied
warranty of any kind with regard
to this material, including, but not
limited to, the implied warranties
of merchantability and fitness for
a particular purpose.
OAKWORKS
®
, Inc. shall not be
liable for incidental or consequential damages in connection with or
arising out of the furnishing, performance, or use of this document
and the program material which it
describes.
TABLE OF CONTENTS
Symbol Identification ................................................................................................ 1
Important Safety Instructions ........................................................................1 & 2
Section I: Product Description & Photo
General & General with Fowler & General 3 Section ............................. 3
Women’s Imaging ...................................................................................... 4
Multi-Specialty ........................................................................................... 5
Echocardiography ...................................................................................... 6
Vascular with Fowler ................................................................................ 7
Vascular ...................................................................................................... 8
Section II: Installation
Grounding .................................................................................................. 9
Section III: Directions for Use
Control Operations (General) ...................................................................10
Control Operations
(Multi-Specialty, Women’s Imaging, General with Fowler) ..................11
Control Operations
(Tables with Electric Sliding Cardio Panel) ...........................................12
Control Operations
(Vascular table with Fowler) ...................................................................13
Control Operations
(Vascular table with out Fowler) .............................................................14
Handset Safety Lock-Out ..........................................................................15
Side Rail Use ..............................................................................................15
Retractable Foot Rest (stirrup) Use ..........................................................15
Adjustable Angle Back Support ...............................................................16
Central Base Locking System ..................................................................16
Locking Casters ........................................................................................16
Operating the Manual Adjustable 4 Position Leg Section .....................17
Sliding Cardio Panel ..................................................................................17
Integrated Foot Board .......................................................................18 & 19
Patient Restraint Strap ...............................................................................20
Paper Roll Holder ......................................................................................21
Table Extender ...........................................................................................21
QuickLock Face Rest ..................................................................................22
T-Rail Adapter ............................................................................................23
Detachable Arm Board ..............................................................................23
Section V: Troubleshooting
Foot & Hand Control Replacement ..........................................................24
Thermal Limiting Switch ..........................................................................25
If the table will not change position
Questions to ask before calling Customer Service ................................ 25
Section VI: Cleaning - Inspections & Maintenance .................................... 26
Section VII Product Identification
Power Lead Plugs ..................................................................................... 27
List of Parts ................................................................................................27
Section VIII: Specifications ......................................................................28-31
Contact Information
TABLE OF CONTENTS
TABLE OF CONTENTS
...................................................... 25
......................................................................... back cover
SYMBOL IDENTIFICATION
SYMBOL IDENTIFICATION
SYMBOL IDENTIFICATION
This symbol, when used in this manual and on product labels, represents
a caution warning. Be sure to read and comply with all precautions and
warnings.
This symbol, when used in this manual and on product labels, warns
against an electrical shock hazard. Be sure to observe and comply with all
warnings.
This symbol, when used in this manual or on product labels, indicates a
Protective Earth (Ground) Terminal.
This symbol when used in this manual or on product labels, warns that
during transport there should be no stacking of containers.
This symbol, when used in this manual or on product labels, indicates that
the product should be protected from moisture. The humidity specifications
for Transport & Storage are listed on page 31.
~
----
READ AND
SAVE THESE
INSTRUCTIONS
CAUTION
This symbol, when used in this manual or on product labels, indicates that
information is given regarding the recommended temperature limits
during transport and storing.
This symbol, when used in this manual or on product labels, indicates the
date of manufacture of the device.
This symbol, when used in this manual or on product labels, indicates
alternating current (AC).
This symbol, when used in this manual or on product labels, indicates
direct current (DC).
IMPORTANT SAFETY INSTRUCTIONS
The following Instructions are critical for the Safety of the operator, patient, and any
other individuals in the area of this equipment. The equipment operator should
carefully read the Safety Instructions on this page.
Foot section is not designed to support entire patient weight. Do not sit on foot section.
Table is not to be used as a gurney or to transport patient from room to room.
When the footboards are in the down position, it is possible for them to hit the ground
in low height and high tilt conditions. Operate the table with the footboard up if
possible. If not, then check ground clearance to prevent damage to the footboard.
1
IMPORTANT SAFETY INSTRUCTIONS
READ AND
SAVE THESE
INSTRUCTIONS
CAUTION
IMPORTANT SAFETY INSTRUCTIONS CONTINUED
Medical Electrical Equipment needs special precautions regarding EMC and needs to be installed
and put into service according to the EMC information provided in this manual.
Portable and mobile RF communications equipment can affect Medical Electrical Equipment.
The use of Accessories, transducers, and cables other than those specified by the manufacturer, may
result in increased Emissions or decreased Immunity of the Ultrasound Table.
The Ultrasound Table should not be used adjacent to or stacked with other equipment and
that if adjacent or stacked use is necessary, this table should be observed to verify normal
operation in the configuration in which it will be used.
As with any moving mechanism there are potential pinch points around and underneath
the table top. It is the responsibility of the operator of this equipment to insure that
bystanders are not in the area below or around this equipment during operation.
Proper operation of this equipment is very important for the safety of the operator,
patient, and any other individuals in the area of this equipment. Directions for use of this
equipment are described on page 9 through 24. The operator should read these sections
carefully.
Weight Limit: (patient and accessories) 600 lbs. Do not exceed.
Be certain that the table is completely lowered without any tilt being present prior to discharging an ambulatory patient. The patient may lose balance and fall.
This table is not suitable for use in the presence of flammable anesthetic mixture with
air or oxygen or nitrous oxide.
PRODUCT DESCRIPTION
WARNING
DANGER
To reduce the risk of burns, fire, electric shock of injury to persons:
1. Unplug this furnishing from the electrical outlet before cleaning.
2. Unplug from outlet before putting on or taking off parts.
3. Close supervision is necessary when this furnishing is used by, or near
children, invalids, or disabled persons.
4. Use this furnishing only for its intended use as described in these
instructions. Do not use attachments not recommended by the manufacturer.
5. Never operate this furnishing if it has a damaged cord or plug, if it is not working
properly, if it has been dropped or damaged, or dropped into water. Contact
Oakworks Customer Service before use.
6. Keep the cord away from heated surfaces.
7. Never drop or insert any object into any opening.
8. Do not use outdoors
9. Do not operate where aerosol (spray) products are being used or where oxygen
is being administered.
10. This table is not suitable for use in the presence of flammable anesthetic mixture
with air or oxygen or nitrous oxide.
For procedures where accidental table motion is a safety concern, the handset control
must be locked out.
Risk of electric shock - Connect this furnishing to a properly gounded outlet only. See
Grounding Instructions. page 9.
Electrical Shock Hazard. The power supply/control module is located under the table seat.
No user serviceable parts are inside. Refer servicing to qualified personnel. Unplug wall plug prior to
contact with any cables connected to the power supply.
2
PRODUCT DESCRIPTION
General
Shown with Optional Fowler (Backrest)
PRODUCT DESCRIPTION
optional foot control
hand control
Upholstered Top
Electric
Lift Towers (2)
Paper roll
e
l
g
n
a
r
e
l
w
o
F
º
5
7
o
t
p
u
holder (1)
Optional
electric
fowler (1)
Locking
Casters (4)
PRODUCT SPECS
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 22”- 38” (56-97 cm)
WIDTH 27” (69 cm) or 30” (76 cm)
LENGTH 1 SECTION - Rectangular top - 72” (183 cm)
& TOPS 2 SECTION - Fowler - 34” (86 cm), Seat - 38” (97 cm)
3 SECTION - Fowler - 34” (86 cm) ,
Seat - 24” (61 cm), Foot - 13” (33 cm)
TRENDELENBURG/REVERSE ±15º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
™
- over 20 colors
INCLUDED FEATURES
Electric Height Range: 22” - 38”
Width: Specify 30” or 27”
Trendelenburg / Reverse Tilt: ± 15º
Electric Fowler
Locking Casters
Paper Roll Holder
Hand Control
3 or 2 section General - Height, Trendelenburg/Reverse, Fowler
1 section General - Height, Trendelenburg/Reverse
OPTIONS & ACCESSORIES
OPTIONS
Central Base Locking System
Sliding Cardio Panel - Electric or Manual (30”w + Left side only)
Side rails (2)
Adjustable Access/Back Support - Left (3, 2 & 1 section tables only)
Adjustable Access/Back Support-Right (3, 2 & 1 section tables only)
Foot Control (All motions)
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Per End - Fowler end only on G3 model)
Table Extender-12” L
3
PRODUCT DESCRIPTION
Women’s Imaging
hand control
Adjustable
Stirrups (2)
optional foot control
Manual
Adjustable
Four Position
Leg Section
e
l
g
n
a
r
e
l
w
o
F
º
5
7
o
t
p
u
Electronic Lift
Towers (2)
Locking
Casters (4)
Paper roll
holder (1)
Electric
fowler
adjustable
angle back
support (Right
side is standard)
PRODUCT DESCRIPTION
PRODUCT SPECS
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 22”- 38” (56-97 cm)
WIDTH 27” (69 cm) or 30” (76 cm)
LENGTH 72” (183 cm)
TOP 3 SECTION; Fowler - 34” (86 cm) ,
Seat - 24” (61 cm), Foot - 13” (33 cm)
TRENDELENBURG/REVERSE ±15º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
™
- over 20 colors
INCLUDED FEATURES
Electric Height Range: 22” - 38”
Width: Specify 30” or 27”
Trendelenburg / Reverse Tilt: ± 15º
Electric Fowler
Manual Adjustable Four Position Leg Sectioin
Hand Control (Height, Trendelenburg/Reverse, Fowler)
Adjustable Access/Back Support - Right
Retractable Foot Rests (Stirrups)
Locking Casters
Paper Roll Holder
OPTIONS & ACCESSORIES
OPTIONS
Central Base Locking System
Side rails (2)
Sliding Cardio Panel - Electric or Manual (30”w + Left side only)
Adjustable Access/Back Support - Left
Foot Control (All motions)
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Fowler End Only)
Table Extender-12” L
4
PRODUCT DESCRIPTION
Multi-Specialty
PRODUCT DESCRIPTION
hand control
Adjustable
Stirrups (2)
e
l
g
n
a
r
e
l
w
o
F
º
5
7
o
t
p
u
Electronic Lift
Towers (2)
Paper roll
holder (1)
adjustable
angle back
support (2)
Manual
Adjustable
Four Position
Leg Section
foot control
Central Base
Locking System
Locking Casters (4)
PRODUCT SPECS INCLUDED FEATURES
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 22”- 38” (56-97 cm)
WIDTH 27” (69 cm) or 30” (76 cm)
LENGTH 72” (183 cm)
TOP 3 SECTION; Fowler - 34” (86 cm) ,
Seat - 24” (61 cm), Foot - 13” (33 cm)
TRENDELENBURG/REVERSE ±15º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
™
- over 20 colors
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
Electric Height Range: 22” - 38”
Width: Specify 30” or 27”
Trendelenburg / Reverse Tilt: ± 15º
Electric Fowler
Central Base Locking System
Hand Control (Height, Trendelenburg/Reverse, Fowler)
Foot Control (Height, Trendelenburg/Reverse, Fowler)
Manual Adjustable Four Position Leg Section
Adjustable Access/Back Support - Right
Adjustable Access/Back Support - Left
Retractable Foot Rests (Stirrups)
Locking Casters
Paper Roll Holder
OPTIONS & ACCESSORIES
OPTIONS
Side rails (2)
Sliding Cardio Panel - Electric or Manual (30”w + Left side only)
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Fowler End Only)
Table Extender-12” L
5
PRODUCT DESCRIPTION
Echocardiography
Electric
g
l
e
n
a
r
e
l
w
o
F
º
5
7
o
t
p
u
fowler
Paper roll
holder (1)
Sliding
Cardo
Panel
PRODUCT DESCRIPTION
adjustable
hand control
foot control - manual cardio foot control - electric cardio
angle back
support (Right
side is standard)
PRODUCT SPECS
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 22”- 38” (56-97 cm)
WIDTH 30” (76 cm)
LENGTH 72” (183 cm)
TOP 2 SECTION; Fowler - 34” (86 cm), Seat - 38” (97 cm)
TRENDELENBURG/REVERSE ±15º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
™
- over 20 colors
Electronic Lift
Towers (2)
Locking
Casters (4)
INCLUDED FEATURES
Electric Height Range: 22” - 38”
Width: 30” only
Trendelenburg / Reverse Tilt: ± 15º
Electric Fowler
Hand Control (All motions)
Adjustable Access/Back Support - Right
Sliding Cardio Panel - Left side - Manual
Locking Casters
Paper Roll Holder
OPTIONS & ACCESSORIES
OPTIONS
Central Base Locking System
Side rails (2)
Sliding Cardio Panel - Electric Upgrade (30”w + Left side only)
Foot Control (All motions)
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Per End)
Table Extender-12” L
6
PRODUCT DESCRIPTION
Vascular with Fowler
PRODUCT DESCRIPTION
hand control
optional foot control
Side Rail (2)
Integrated
Foot Board (2)
g
r
u
b
n
e
l
e
d
n
e
r
T
e
s
r
e
v
e
r
º
0
7
o
t
p
u
Locking
Casters (4)
Paper roll
holder (1)
Electric
fowler
Patient
Restraint
Strap (1)
Electronic Lift
Towers (2)
PRODUCT SPECS
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 23”- 40” (58-102 cm)
WIDTH 27” (69 cm) or 30” (76 cm)
LENGTH 72” (183 cm)
TOP Fowler - 34” (86 cm), Seat - 38” (97 cm)
TRENDELENBURG 15º
REVERSE TRENDELENBURG up to 70º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
™
- over 20 colors
INCLUDED FEATURES
Electric Height Range: 23” - 40”
Width: Specify 30” or 27”
Trendelenburg: 15º
Reverse Trendelenburg: 40º + Electric Fowler = 70º
Electric Fowler
Integrated Foot Board (split, drop away)
Locking Casters
Patient Restraint Strap
Side Rails (2)
Hand Control (All motions)
Paper Roll Holder
OPTIONS & ACCESSORIES
OPTIONS
Central Base Locking System
Sliding Cardio Panel - Manual (30”w + Left side only)
Adjustable Access/Back Support - Left
Adjustable Access/Back Support-Right
Foot Control (All motions)
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Fowler End Only )
Table Extender-12” L
7
PRODUCT DESCRIPTION
Vascular
Integrated Foot Board
2" or 4" position and easy drop away.
2" position 4" position
b
n
e
u
l
r
e
d
n
e
r
T
e
s
r
e
v
e
r
º
0
4
o
t
p
u
g
Patient
Restraint
Strap (1)
Paper roll
holder (1)
PRODUCT DESCRIPTION
staggered
position
optional foot control
anti-skid
surface
Side Rail (2)
Integrated
Foot Board (2)
PRODUCT SPECS
PATIENT WEIGHT CAPACITY 600 lbs. (272 kg.)
HEIGHT RANGE 23”- 40” (58-102 cm)
WIDTH 27” (69 cm) or 30” (76 cm)
LENGTH & TOP Rectangular top - 72” (183 cm)
TRENDELENBURG 15º
REVERSE TRENDELENBURG 40º
PADDING 3” (8 cm) multi-layer
UPHOLSTERY TerraTouch
TABLE WEIGHT 313 lbs. (142kg.)
WARRANTY 3 years parts, 1 year labor
CERTIFICATIONS FDA listed, cETL approved, CE marked
™
- over 20 colors
Electronic Lift
Towers (2)
Locking
Casters (4)
INCLUDED FEATURES
Electric Height Range: 23” - 40”
Width: Specify 30” or 27”
Trendelenburg: 15º
Reverse Trendelenburg: 40º
Integrated Foot Board (split, drop away)
Locking Casters
Patient Restraint Strap
Side Rails (2)
Hand Control (All motions)
Paper Roll Holder
OPTIONS & ACCESSORIES
OPTIONS
Central Base Locking System
Sliding Cardio Panel - Electric or Manual (30”w + Left side only)
Adjustable Access/Back Support - Left
Adjustable Access/Back Support-Right
Foot Control (All motions)
* Published weight and height may differ slightly due
to options chosen, natural material variations and
padding density.
For electrical specs, see Specifications Chart
ACCESSORIES
Detachable Arm Board
T-Rail Adapter
Quick Lock Head Rest & Pad
Accessory Mounting Plate (Head End Only )
Table Extender-12” L
8
Loading...