Numatic HVR200M, HVR200M-22 Original Instructions Manual

INDEX / About the machine / PPE

Information for dry use Vacuum Cleaners

Schematic Diagram

Certicate of Conformity

Kit / Spare Parts

Page 2

Page 3

Page 5

Page 6

Page 7/8

Ear Protection Safety Footwear Hat Protection Safety Gloves Dust / Allergens Protection Eye Protection Protective Clothing

PPE

(personal protective equipment)
that maybe required for certain operations.

NOTE:

A risk assessment should be conducted to decide
what PPE should be worn.

Caution Floorsign

Safety Critical Components

Mains lead

HO5V2V2 x 10m x 2 x 0.75mm2
10m x 2 x 1.00mm

2

Filter Bag
NVM-1CH >pp< construction 99.6%@0.3µm

Filter

Tritex NVM 604165 >pp< construction 96.0%@0.3µm

Microtex NVM 604311 >pp< construction 99.6%@0.3µm

Microfresh NVM 604170 >pp< construction 98.4%@0.3µm

Page 2

WEEE Legislation ( Waste, Electrical and Electronic Equipment).

Vacuum cleaner, accessories and packaging should be sorted for environmental-friendly
recycling.
Only for EU countries:
Do not dispose of Vacuum cleaner into household waste!
According to the European Directive 2002/96/EC on waste electrical and electronic
equipment and its incorporation into
national law.
Vacuum cleaners that are no longer suitable for use must be separately collected and
sent for recovery in an environmental-friendly manner.

Information for DRY USE Vacuum Cleaners

WARNING:

Read the instruction manual before using the machine.
Operators shall be adequately instructed on the use of thier machine.
As with all electrical equipment, care and attention must be exercised at all times during use, in
addition to ensuring that routine and preventative maintenance is carried out periodically to ensure
safe operation.
Failure to carry out maintenance as necessary, including the replacement of parts to the correct
standard could render this equipment unsafe and the manufacturer can accept no responsibility in

this respect. Maintenance should only be carried out by a qualied person.

This machine is for DRY USE only and must not be stored outside or used in wet conditions.
The machine shall be disconnected from the mains by removing the plug from the supply socket
during cleaning or maintenance and when replacing parts or converting the machine to another
function.
The machine is not to be used by children or persons with reduced physical, sensory or mental
capabilities, or lack of experience or knowledge, unless they have been given supervision or
instruction.
This appliance is intended to be cleaned and maintained by an adult.
Children being supervised are not to play with the machine.
This machine is not a toy.

CAUTION:

This machine is not suitable for picking up hazardous or explosive dust. Contact your local
distributor if you require a machine capable of performing these tasks.

Ensure that the ltration system tted to the machine is suitable for the material being collected.

This vacuum cleaner is intended for indoor use in the collection of dry materials.
This machine should be stored indoors only.

NOTE:

This machine is also suitable for commercial dry use, for example in hotels, schools, hospitals,

factories, shops and ofces for other than normal housekeeping purposes.

This product complies with the requirements of clause 20 of EN 60335-2.69 Stability and
Mechanical Hazards.
This vacuum cleaner is tted with a thermal protection device. If the vacuum cleaner stops work­ing, remove the plug from the wall before investigating where the fault lies.

If the vacuum cleaner has a blockage, switch off, remove the plug from the wall, inspect the oor
tool, tubes and hose for debris. If the oor tool, tubes and hose are clear, replace the dust bag and
clean the lter.

The vacuum cleaner should be inspected after use for damage.
Not suitable for the collection of biological hazards, hazardous, or explosive dusts .
The vacuum cleaner should be stored in a dry place.

Page 3