Nor-Lake AdvantEDGE Full Line Merchandiser Refrigerator User Manual

FULL LINE SWING & SLIDE GLASS DOOR

MERCHANDISER REFRIGERATORS

Installation, Operation and Maintenance Instructions

10/14 Rev A 159218

2

TABLE OF CONTENTS

INTRODUCTION………………………………….……………………………………………………….………………………3

STORE CONDITIONS…………………………….……………….…..……………………………………..…….…………….3

WARNING LABELS AND SAFETY INSTRUCTIONS………..…..…………………………………..………………………4

PRE-INSTALLATION INSTRUCTIONS………………………..…..………………………...................………….…………5

Inspection for Shipping Damage…………………………………………………………….………………………….5

INSTALLATION INSTRUCTIONS………………………………………….……………………………………………………5

General Instructions…………………………………………..…….……………………………………………………5
Mechanical ..………………………………………………………….…………………………………………………..5
Electrical…………...……………………………………….……………………………………………………………..6

Temperature Control…… ……………………………….…….………………………………………………………..6

Leg……………………………………....……………………….………………………………………………………..7

Doors..…………....……………………………………………….……………………………………………………....7

Grill…..…………....……………………………………………….……………………………………………………...7

SERVICE INSTRUCTIONS ……………………………………………………….……………………………………………8

TEMPERATURE CONTROL AND FAN MOTOR REPLACEMENT……………….……………………………………….9

FINAL CHECK LIST……………………………………………………….……………………………………….…………….9

PARTS LIST……………………………………………………………………………………………………………………...10

ACCESSORIES…. ……………………………………………………………………………………………………………...10

SALE AND DISPOSAL ……………………………………………………………………………………………………….11

WIRING DIAGRAM ………………………………………………………………….……..……………….………………12-13

10/14 Rev A 159218

3

INTRODUCTION

This manual contains important instructions for installing, using, and servicing a Merchandiser Refrigerator case. A
parts list is included with this manual. Read all these documents carefully before installing or servicing your
equipment.

STORE CONDITIONS

The Merchandiser Refrigerator cases are designed to operate in the controlled environment of an air-conditioned
store. The store temperature should be at or below +75°F and a relative humidity of 55% or less. At higher
temperature or humidity conditions, the performance of these cases may be affected and the capacity diminished.

The Merchandiser Refrigerator should not be positioned where it is directly exposed to rays of sun or near a direct
source of radiant heat or airflow. This will adversely affect the case and will result in poor performance.

If this case is to be located against a wall, there should be at least 4” space between the wall and the back of the

case. This space will allow for the circulation of air behind the case, which will prevent condensation on the exterior
surfaces.

NOTICE

Read this manual before installing your cabinet. Keep the manual and refer to it before
doing any service on the equipment. Failure to do so could result in personal injury or
damage to the cabinet.

DANGER

Improper or faulty hook-up of electrical components on the refrigeration units can result
in severe injury or death.

All electrical wiring hook-ups must be done in accordance with all applicable local, regional or
national standards.

NOTICE

Installation and service of the refrigeration and electrical components of the cabinet
must be performed by a refrigeration mechanic and/or a licensed electrician.

The portions of this manual covering refrigeration and electrical components contain technical instructions intended
only for persons qualified to perform refrigeration and electrical work.

This manual cannot cover every installation, use or service situation. If you need additional information, call the
Customer Service Department.

10/14 Rev A 159218

4

WARNING LABELS AND SAFETY INSTRUCTIONS

This symbol is the safety-alert symbol. When you see this symbol on your cabinet or in this
manual, be alert to the potential for personal injury or damage to your equipment.

Be sure you understand all safety messages and always follow recommended precautions and safe operating
practices.

NOTICE TO EMPLOYERS
You must make sure that everyone who installs, uses or services your cabinet is

thoroughly familiar with all safety information and procedures.

Important safety information is presented in this section and throughout the manual. The following signal words are
used in the warnings and safety messages:

DANGER: Severe injury or death will occur if you ignore the message.
WARNING: Severe injury or death can occur if you ignore the message.
CAUTION: Minor injury or damage to your cabinet can occur if you ignore the message.
NOTICE: This is important installation, operation or service information. If you ignore the

message, you may damage your cabinet.

The warning and safety labels shown throughout this manual are placed on your cabinet at the factory.
Follow all warning label instructions. If any warning or safety labels become lost or damaged, call your
customer service department for replacements.

This label is located on top of the electrical control This label is attached to the cabinet power cord
label and on the wiring channel. on models with a power cord.

10/14 Rev A 159218