Norlab P10118VM1 User Manual

Identification

Composition, Information on Ingredients, Exposure Limits

Ingredient

% Volume

PEL-OSHA2

TLV-ACGIH3

LD50 or LC

50

Route/Species

Butane
Formula: C4H

10

CAS: 106-97-8
RTECS#: EJ4200000

0.0001 to 10%

Not Available

10000 PPM TWA

276,470 PPM
Inhalation/rat
(4 H)

Nitrogen
Formula: N2
CAS: 7727-37-9
RTECS#: QW9700000

90.0 to 99.9999%

None Established

Simple Asphyxiant

Not Available

Hazards Identification

Skin Contact

No

Skin Absorption

No

Eye Contact

No

Inhalation

Yes

Ingestion

No

Exposure Limits

Yes

Irritant

No

Sensitization

No

Teratogen

No

Reproductive Hazard

No

Mutagen

No

Synergistic Effects
None reported

Emergency Contact: Chemtrec [phone]

Or Norco [phone]

Butane 0.0001% to 10% in Nitrogen

M A T E R I A L S A F E T Y D A T A S H E E T

1125 West Amity Road
Boise, ID 83705

[phone]

Product Name: Butane 0.0001% to 10% in Nitrogen Revision Date: 03/26/04
Chemical Name: Butane in Nitrogen Last Review Date: 03/04/13
Chemical Family: Gas Mixture
CAS Number: N/A
Common Names/Synonyms: N/A
MSDS Identification Code/Number: 2020
Prepared by: Quality Dept.

Exposure Limits1

1

Refer to individual state or provincial regulations, as applicable, for limits that may be more stringent than those listed here.

2

As stated in 29 CFR 1910, Subpart Z (revised July1, 1993)

3

As stated in the ACGIH 2007 Threshold Limit Values for Chemical Substances and Physical Agents

OSHA Regulatory Status: This material is classified as hazardous under OSHA regulations.

Emergency Overview:

Simple Asphyxiant – This product does not contain oxygen and may cause asphyxia if released in a confined area. High
concentrations of butane may have central nervous system effect. Maintain oxygen levels above 19.5%. Contents under pressure.
Use and store below 125 OF (520C). Nonflammable when butane concentration is less than 5.6%, flammable if above 5.6% (CGA
Pamphlet P-23 2003).

Route of Entry:

Health Effects:

Butane 0.0001% to 10% in Nitrogen, Material Safety Data Sheet # 2020, Page 2 of 5

Hazards Identification Continued

First Aid Measures

Carcinogenicity: NTP: No IARC: No OSHA: No

Eye Effects:

Contact with rapidly expanding gas near the point of release may cause frostbite.

Skin Effects:

Contact with rapidly expanding gas near the point of release may cause frostbite with redness, skin color change to gray or white, and
blistering.

Ingestion Effects:

None known. Ingestion is unlikely as product is a gas at room temperature.

Inhalation Effects:

Inhalation of butane vapors may cause dizziness, headache and nausea. High concentrations may depress the central nervous system,
causing a loss of consciousness and respiratory paralysis.

Product is a simple asphyxiant. High concentrations may exclude an adequate supply of oxygen to the lungs. Effects of oxygen
deficiency resulting from simple asphyxiants may include: rapid breathing, diminished mental alertness, impaired muscular
coordination, faulty judgment, depression of all sensations, emotional instability, and fatigue. As asphyxiation progresses, nausea,
vomiting, prostration, and loss of consciousness may result, eventually leading to convulsions, coma, and death.

Oxygen deficiency during pregnancy has produced developmental abnormalities in humans and experimental animals.

Medical Conditions Aggravated by Exposure: None known.

NFPA Hazard Codes HMIS Hazard Codes Ratings System

Health: 0 Health: 0 0: No Hazard
Flammability: 1 Flammability: 1 1: Slight Hazard
Instability: 0 Physical Hazard: 3 2: Moderate Hazard
3: Serious Hazard
4: Severe Hazard

Hazard ratings were assigned in accordance with Compressed Gas Association (CGA) guidelines as published in CGA Pamphlet P­19-2004, CGA Recommended Hazard Ratings for Compressed Gases, 2nd Edition.

Eyes:

None required for gas. If frostbite is suspected, flush eyes with cool water for 15 minutes and obtain immediate medical attention.

Skin:

None required for gas. For frostbite, immerse skin in lukewarm water. DO NOT USE HOT WATER. Obtain medical attention.

Ingestion:

None required.

Inhalation:

PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF OVEREXPOSURE. RESCUE PERSONNEL
SHOULD BE EQUIPPED WITH SELF-CONTAINED BREATHING APPARATUS. Victims should be assisted to an
uncontaminated area and inhale fresh air. Quick removal from the contaminated area is most important. Unconscious persons should
be moved to an uncontaminated area and, if breathing has stopped, administer artificial resuscitation and supplemental oxygen.
Further treatment should be symptomatic and supportive.