Nokia 5120, NSC-1 Service Manual

Programmes After Market Services
Technical Documentation

SERVICE MANUAL

[NMP Part No.0275397 + Update 0275408 + Update 0275430 +
Update 0275503]
NSC-1 Series Cellular Phones
Copyright Nokia Mobile Phones. All Rights Reserved
Programmes After Market Services
Technical Documentation
Copyright Nokia Mobile Phones. All Rights Reserved
Programmes After Market Services
Technical Documentation
Amendment Record Sheet
Amendment
No
Issue 2 03/99 OJuntunen Introduction: 3 leaves Issue 2 03/99 OJuntunen SERVICE TOOLS Section: Dummy
Issue 3 11/99 J Watson Introduction: 3 leaves Issue 3 11/99 J Watson Section 02: ACP-8 data added; repagi-
Issue 3 11/99 J Watson Section 03: US4RSM v.6.0 parts list
Issue 3 11/99 J Watson Section 04: UE4S v.5.0 parts list added;
Issue 3 11/99 J Watson Service SW Instructions: WinTesla
Date Inserted By Comments
10/98 Original
Battery BTD3 added; amendment sheet updated; repaginated.
nated.
added; repaginated.
repaginated.
v5.30 replaced by v.6.03; repaginated.
Issue 3 11/99 J Watson Tuning Instructions: POS Flash concept
added. Tuning target tolerance & testing limits amended; TX Power...repaginated
Issue 3 11/99 J Watson Service Tools: Added XMS-3; FLS-2D;
SCH-5A; XRC-2. Issue 3 11/99 J Watson Troubleshooting: Revised. Issue 3 11/99 J Watson Nonserviceable Accessories: Added
ACP-8; XRC-2; DLR-3; HDC-9P;
repaginated. Issue 4 03/01 J Fraser Introduction: 3 leaves Issue 4 03/01 J Fraser Section 02: New variants and colors
added; repaginated Issue 4 03/01 J Fraser Product Variants: NSW-1NX blue, grey,
SBC blue added; repaginated Issue 4 03/01 J Fraser Tuning: Information update; repaginate Issue 4 04/01 J Fraser HFU-2 and LPS-1/2: Sections incorpo-
rated into Nonserviceable accessories
Copyright Nokia Mobile Phones. All Rights Reserved
Programmes After Market Services
Technical Documentation
NSC-1 Series Cellular Phones
Service Manual – Overall Manual Contents
Service Manual comprising NSC-1 Series Transceiver booklet comprising
Chapter 1: Foreword Chapter 2: General Information Chapter 3: System Module UT4S Chapter 4: UIF Module UE 4S Chapter 5: Transceiver NSC-1 variants Chapter 6: Service Software Instructions Chapter 7: Tuning Instructions Chapter 8: Service Tools Chapter 9: Disassembly/Troubleshooting Instructions Chapter 12: Nonserviceable Accessories Chapter 13: CARK-64 Installation Guide Chapter 14: CARK-91 Installation Guide
Copyright Nokia Mobile Phones. All Rights Reserved
Programmes After Market Services
This document is intended for use by qualified service personnel only.

Company Policy

Our policy is of continuous development; details of all technical modifications will be included with service bulletins.
While every endeavour has been m ade to ensure the accuracy of this do cument, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Ltd should be notified in writing.
Please state:
Technical Documentation
IMPORTANT
Title of the Document + Issue Number/Date of publication Latest Amendment Number (if applicable) Page(s) and/or Figure(s) in error
Please send to: Nokia Mobile Phones Ltd
PAMS Technical Documentation PO Box 86 FIN-24101 SALO Finland
Copyright Nokia Mobile Phones. All Rights Reserved
Programmes After Market Services
Technical Documentation

Warnings and Cautions

Please refer to the phone's user guide for instructions relating to operation, care and maintenance including important safety information. Note also the following:
Warnings:
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/ MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING
Cautions:
1. Servicing and alignment must be undertaken by qualified personnel only.
2. Ensure all work is carried out at an anti-static workstation and that an
3. Ensure solder, wire, or foreign matter does not enter the telephone as
4. Use only approved components as specified in the parts list.
5. Ensure all components, modules screws and insulators are correctly
CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
anti-static wrist strap is worn.
damage may result.
re-fitted after servicing and alignment. Ensure all cables and wires are repositioned correctly.
Copyright Nokia Mobile Phones. All Rights Reserved
Loading...