Nex 720-0145-lp, 720-0145, 720-0145 Owner's Manual

FOR OUTDOOR USE ONLY

Stainless Steel Gas Grill
USE AND CARE GUIDE
MODEL NO.: 720-0145-LP

PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE

®

DO NOT RETURN TO PLACE OF PURCHASE

1~5

5

SECTION TWO

17

Read this Care and Use Manual carefully

TABLE OF CONTENTS

SECTION ONE
Safety Instructions…………………………
Placement of the grill………………………

Rotisserie mount installation………….….6

Side shelf Assembly…………………….7
Side burner Assembly ……………………8
Side shelf handle Assembly……………...9
Rotisserie kit Assembly …………………..9
Spice Tray Assembly ……………………..10
Propane Tank Assembly ………………11

To Match light the Gill……………………..12

SECTION THREE
Gas Hook-Up………………………………13
Leak Testing……………………………….14
Installer Final Check……………………...15

SECTION FOUR
Operating Instructions……………………16

Lighting Instructions……………………....

SECTION FIVE
Using the side burner……………………
Care & Maintenance ……………….
Trouble Shooting…………………………
Check List ………………….

SECTION SIX
Lighting Illustrations……………………….
Exploded View……………………………..
Parts List …………………………………..
Grilling Hints………………………………..
Grill Cooking Chart ……………………….
Grill Recipe Suggestion ………………….

SECTION SEVEN
Limited Warranty ………………………….

18
18
19
20~21

22
23
24
25
26~27
28~29

30

and completely before using your grill to

reduce the risk of fire, burn hazard or
other injury.

fire department.

SAFETY INSTRUCTIONS

***** WARNING *****

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open Lid.

4. If odor continues, immediately call your gas supplier or your

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable vapors and

FOR YOUR SAFETY

liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in

the vicinity of this or any other appliance.

1

SAFETY INSTRUCTIONS

RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

WARNING

Do not try lighting this appliance without first reading the
“LIGHTING INSTRUCTIONS” section of this manual.

DO NOT USE ALUMINUM FOIL TO LINE THE GRILL
RACKS OR GRILL BOTTOM. This can severely upset
combustion airflow or trap excessive heat in the control
area.

INSECT WARNING!!! Spiders and insects can nest in the
burners of this and any other grill, and cause the gas to flow
improperly. This is a very dangerous condition, which can
cause a fire to occur behind and beneath the valve panel,
thereby damaging the grill and making it unsafe to operate.
Inspect the grill twice a year.

LP Gas Cylinder must be fitted with Overfill Protection Device (OPD).

WARNING

a) DO NOT store a spare LP-gas cylinder under or near this appliance.

b) NEVER fill the cylinder beyond 80% full.

c) If the information in “a” and “b” is not followed exactly, a fire causing death or

serious injury may occur.

WARNING

ELECTRICAL GROUNDING INSTRUCTIONS

This appliance (rotisserie motor) is equipped

with a plug and should be plugged directly

into a properly grounded receptacle. DO NOT

cut or remove the grounding prong from this
plug.

Keep the rotisserie motor electric cord away from
the heated surfaces of the grill. When not in use
remove and store the motor in a dry location

CAUTION: REMOVE THE

WARMING RACK WHEN USING THE
ROTISSERIE BURNER. THE HIGH
HEAT COMING FROM THE BURNER
MAY CAUSE THE WARMING RACK TO
BEND.

DO NOT LEAVE THE GRILL
UNATTENDED WHILE COOKING.

2

SAFETY INSTRUCTIONS

RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS

WARNING: Always keep your face and body as far away from the burner as

possible when lighting.

WARNING: IMPORTANT!

BEFORE LIGHTING…

Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear,
or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is
present. Only the pressure regulator and hose assembly supplied with the unit should be
used. Never substitute regulators for those supplied with the grill. If a replacement is
necessary, contact the factory for proper replacement.

Screw the regulator onto the tank. Leak check the hose and regulator connections with a soap
and water solution before operating the grill.

Keep a spray bottle of soapy water near the gas

supply valve and check the connections before

each use.

Do not attempt to light the grill if odor of gas is
present. Call for service 1-800-913-8999.

ROTISSERIE DRIVE MOTOR

USE ONLY FOR OUTDOORS, DO NOT EXPOSE
TO RAIN.

CAUTION: TO ENSURE CONTINUED

PROTECTION AGAINST RISK OF ELECTRIC
SHOCK, CONNECT TO PROPERLY GROUNDED
OUTLETS ONLY, TO REDUCE THE RISK OF
ELECTRIC SHOCK, KEEP EXTENSION CORD
CONNECTION DRY AND OFF THE GROUND.

3

SAFETY INSTRUCTIONS

TESTED IN ACCORDANCE WITH ANSI Z21.58b

LATEST STANDARD and CGA 1.6b-2002

STANDARD FOR OUTDOOR COOKING GAS

APPLIANCES. THIS GRILL IS FOR OUTDOOR
USE ONLY.

Check your local building codes for the proper
method of installation. In the absence of local
codes, with either the National Fuel Gas Code,
ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1,
Natural Gas and propane Installation Code.
Electrical Code, ANSI/NFPA 70.

CALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some
byproducts, which are known by the State of
California to cause cancer or reproductive harm. To
minimize exposure to these substances, always
operate this unit according to the use and care
manual, ensuring you provide good ventilation
when cooking with gas.

SAFETY PRACTICES TO AVOID PERSONAL INJURY

When properly cared for, your grill will give safe,
reliable service for many years. However, extreme
care must be used since the grill produces intense
heat and that can increase accident potential. When
using this appliance basic safety practices must be
followed, including the following:

Do not repair or replace any part of the grill unless
specifically recommended in this manual. All other
service should be referred to a qualified technician.

This outdoor cooking gas appliance is not intended to
be installed in or on recreational vehicles and/or
boats.

CHILDREN SHOULD NOT BE LEFT ALONE OR
UNATTENDED IN AN AREA WHERE THE GRILL IS
BEING USED. NEVER ALLOW THEM TO SIT,
STAND OR PLAY ON OR AROUND THE GRILL AT
ANY TIME.

DO NOT STORE ITEMS OF INTEREST TO
CHILDREN AROUND OR BELOW THE GRILL OR IN
THE CART. NEVER ALLOW CHILDREN TO CRAWL
INSIDE OF THE CART.

Never let clothing, pot holders or other flammable
materials come in contact with or too close to any
grate, burner or hot surface until it has cooled. Fabric
may ignite and result in personal injury.

For personal safety, wear proper apparel. Loose fitting
garments or sleeves should never be worn while
using this appliance. Some synthetic fabrics are
highly flammable and should not be worn while
cooking.

Only certain types of glass, heatproof glass

ceramic, earthenware, or other glazed utensils are

suitable for grill use. Theses types of materials

may break with sudden temperature changes. Use

only on low or medium heat settings according to

the manufacturer’s directions.

Do not heat unopened food containers as a build-up
of pressure may cause the container to burst.

Use a covered hand when opening the grill lid. Never
lean over an open grill.

WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE
ATTENTION TO WHAT YOU ARE DOING. BE
CERTAIN YOU ARE TURNING THE IGNITER
LABELED FOR THE BURNER YOU INTEND ON

4

SAFETY INSTRUCTIONS

When using the grill, do not touch the grill rack, burner
grate or immediate surroundings as these areas become
extremely hot and could cause burns. Use only dry
potholders. Moist or damp potholders on hot surfaces
may cause burns from steam. Do not use a towel or bulky
cloth in place of potholders. Do not let potholders touch
hot portions of the grill rack.

Grease is flammable. Let hot grease cool before
attempting to handle it. Avoid letting excess grease
deposits collect in the grease tray at the bottom of the
grill’s firebox. Clean often.

For proper lighting and performance of the burners keep
the burner ports clean. It is necessary to clean them
periodically for optimum performance. The burners will
only operate in one position and must be mounted
correctly for safe operation.

Clean the grill with caution. Avoid steam burns; do not
use a wet sponge or cloth to clean the grill while it is hot.
Some cleaners produce noxious fumes or can ignite if
applied to a hot surface.

Be sure all grill controls are turned off and the grill is cool
before using any type of aerosol cleaner on or around the
grill. The chemical that produces the
spraying action could, in the presence of heat, ignite or
cause metal parts to corrode.

Do not use the grill for cooking excessively fatty meats or
products, which promote flare-ups. Do not operate the
grill

PLACEMENT OF THE GRILL

under unprotected combustible construction. Use only in well
ventilated areas. Do not use in buildings, garages, sheds,
breezeways or other such enclosed areas. THIS UNIT IS FOR

OUTDOOR USE ONLY.

Keep the area surrounding the grill free from combustible
materials, trash, or combustible fluids and vapors such as
gasoline or charcoal lighter fluid. Do not obstruct the flow of
combustion and ventilation air. If the unit is stored indoors
ensure that it is cool. If propane is used, the cylinder must be
unhooked and the propane cylinder stored outside in a
well-ventilated area, out of the reach of children.

DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILL.

The 720-0153-LP Build-in Grill is designed for optimum
performance without the use of briquettes. Do not place
briquettes on the radiant as this will block off the area for the
grill burners to vent. Adding briquettes can damage ignition
components and knobs, and void the warranty.

Keep the back of the cart free and clear from debris. Keep any
electrical supply cord, or the rotisserie motor cord away from
the heated areas of the grill.

Never use the grill in extremely windy conditions. If located in
a consistently windy area (oceanfront, mountaintop, etc.) a
windbreak will be required (see below). Always adhere to the
specified clearance.

NEVER USE A DENTED OR RUSTY PROPANE TANK

CLEARANCE

To Non-Combustible Construction

A minimum of 3” clearance from the back of the
grill to non-combustible construction is required
for the lid to open fully.
DO NOT INSTALL THIS UNIT INTO
COMBUSTIBLE ENCLOSURES!
MINIMUM CLEARANCE:
24”Clearance from all sides to combustible
material.

LOCATION

When determining a suitable location take into account
concerns such as exposure to wind, proximity to traffic
paths and keeping any gas supply lines as short as
possible. Locate the grill only in a well-ventilated area.
Never locate the grill in a building, garage, breezeway, shed
or other such enclosed areas. During heavy use, the grill
will produce a lot of smoke. Lock the wheels after the grill is
placed in a suitable position.

5

ROTISSERIE MOUNT INSTALLATION

1. The screws for rotisserie mount are already screwed into the left side of the grill.
Remove the screws and install the rotisserie motor mount as shown in the figure

Below.

6

SIDE SHELF ASSEMBLY

1. The screws used to attach the side shelf are already screwed into the two-side

panel(see the figure below).remove the screws from the two-side panel, and
put the side shelf to two-side panel, then tight screws for fixing strongly.

7

panels. Remove the

and

The top two screws insert from inside the fire box while the bottom two screws insert

with the two clips located under the side burner shelf (bottom

SIDE BURNER ASSEMBLY

1. Open the grill lid and remove the side burner from the fire box.

2. The screws used to attach the side burner are already screwed into the side

screws from the side panels.

3. Align the holes of the right side burner with those in the side panels, insert the screws
tighten.
from under the right side burner.

4. Secure the side burner hose
drawing).

8