Nex 420-0048 Owner's Manual

ITEM / ARTICLE / ARTICULO # 286482

STAINLESS STEEL LP OVEN STAINLESS STEEL LP OVEN (page XX) STAINLESS STEEL LP OVEN (página XX)

MODEL / MODÈLE / MODELO # 420-0048

Example only: SERIAL # ________ MFG. DATE ________ PURCHASE DATE: _________

WARNING

To reduce the risk of fire, burn hazard or other injury, read the Care and Maintenance section (page 12) carefully and completely before using your oven.

Questions, problems, missing parts? Before returning to your retailer, call our customer service department at 1-877-323-5263, 8 a.m. - 6 p.m., PST, Monday - Friday, 8 a.m. – 12 p.m. Saturday.

WARNING

FOR OUTDOOR USE ONLY

WARNING

This appliance is not intended to be installed in or on recreational vehicles and/or boats.

TABLE OF CONTENTS

Safety Information….…………………………………………………....………………...……3

Package Contents List………………………………………………………………………….5 Preparation……………….…………………. ……………………….…………….……...……6 Assembly Instructions…………………………………………………………….…..………...6

Installation Instructions…………………………………………………………….....………...8

Operation Instructions…….…………………………………………………….…..…………10 Care and Maintenance………………………………………………….……………………..12 Electrical Wiring Diagram….……..……………………………………..…………………….13 Troubleshooting…………………………………..…………………………..……….……….14 Warranty…..………………………….…………………………………………..……...…..…15 Replacement Parts List………………….…...…………….…………………..…….……….16

WARNING

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If the odor continues, keep away from the appliance and immediately call your gas supplier or local fire de

artment.

WARNING

1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

2. A Liquid Propane cylinder not in use should not be stored in the vicinity of this or any other appliance.

SAFETY INFORMATION

Please read and understand this entire manual before attempting to assemble, operate or install the product. If you have any questions regarding the product please call customer service at 1-877-323-5263, 8 a.m. - 6 p.m., PST, Monday - Friday, 8 a.m. – 12 p.m. on Saturday.

1. Safety Symbols

WARNING – Hazardous or unsafe practices which could result in severe personal injury or death. CAUTION – Hazardous or unsafe practices which could result in property damage.

2. Never attempt to use damaged or obstructed equipment. See your local Liquid Propane dealer for repair.

3. Check all gas supply fittings for leaks before each use. Do not use the oven until all co nnections have been checked and do not leak. Do not smoke while leak testing. Never leak test with an open flame.

4. Do not store or use gasoline or other flammable vapors and liquids in the vicini ty of this or any other appliance.

5. A Liquid Propane cylinder not in use should not be stored in the vicinity of this or any other appliance.

6. Storage of an outdoor cooking gas appliance ind oors is permissible only if the Liquid Propa ne cylinder is disconnected and removed from the outdoor cooking gas appliance.

7. Do not leave the oven unattended while cooking.

8. Liquid Propane cylinder must be stored outdoors and out of the reach of children and must not be stored in a building, garage, or any other enclosed area.

9. This oven is not intended to be installed in or on recreational vehicles and/or boats.

10. Do not install this unit into combustible enclosures. There should be a minimum clearance of 24 inches from all sides to combustible materials.

1 1. Outdoor cooking appliance shall not be used under overhead combustible construction.

12. A Liquid Propane cylinder of approximately 12 inches in diameter by 18-1/2 inches high is the maximum size to use. You must use an OPD Liquid Propane cylinder, which offers an Overfill Prevention Device.

1 3. Keep the electrical supply cords and fuel supply hoses away from any heated surfaces.

14. Spiders and insects can nest inside the burners of the grill and disrupt gas flow. Inspect the grill at least twice a year.

15. The oven must be isolated from the gas supply piping system by closing its individual manual sh ut-off valve during any pressure testing of the gas supply piping system at test pressure eq ual to or less than a 1/2 inch psi. (3.5 kpa).

WARNING Spiders and insects can nest inside the burner of the oven and disrupt gas flow. This very dangerous condition could cause a fire behind the valve panel, thereby damaging the oven and making it unsafe for operation. Inspect at least twice a year.

WARNING

Do not use the oven if the odor of gas is present. Contact customer service at 1-877-323-5263.

CAUTION

1. Before cleaning, make sure the gas supply is “OFF”, the electrical cord is unplugged and the oven has cooled.

2. Do not alter the oven in any manner.

3. Clean and inspect hoses before each use. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior to operation. The replacement hose should be in accordance with the manufacturer’s specifications.

BEFORE LIGHTING

Inspect the gas supply hoses prior to turning on the gas. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use.

Use the pressure regulator and hose assembly supplied with the grill. Never substitute regulators for those supplied with the grill. Contact customer service for proper replacement parts.

Install the regulator (type QCC1) onto the cylinder. Leak test the hose and regulator connections with a one part soap and one part water solution before operating the grill (See “Leak Testing” instructions on page 9).

Do not turn “ON” the gas at the Liquid Propane cylinder unless all gas hoses are properly connected.

TESTED IN ACCORDANCE WITH ANSI Z21.58 LATEST STANDARD and CSA 1.6 - 2007 ANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS OVEN IS FOR OUTDOOR USE ONLY.

Check your local building codes for the proper method of installation. In the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or CSA B149.1, Natural Gas and propane Installation Code. Electrical Code, ANSI/NFPA 70.

CCALIFORNIA PROPOSITION 65-WARNING

The burning of gas fuel generates some byproducts, which are known by the State of California to cause cancer or reproductive harm. To minimize exposure to these substances, always operate this unit according to the care and use manual, ensuring you provide good ventilation when cooking with gas.

SAFETY PRACTICES TO AVOID INJURY

When properly cared for, your oven will provide safe, reliable service for many years. However, extreme care must be used as the oven produces intense heat that can increase accident potential. When using this appliance basic safety practices must be followed, including the following:

• Do not repair or replace any part of the oven unless specifically recommended in this manual. All other service should be referred to a qualified technician.

• The oven is for outdoor use only.

• Children should not be left alone or unattended in an area where the oven is being used. Do not

allow children to sit, stand or play on or around the oven at any time.

• Do not store items of interest to children around the oven. Do not allow children to crawl inside the oven.

• Never let clothing, pot holders or other flammable materials come in contact with or come too close to any grate, burner or hot surface until it has cooled. The fabric could ignite, causing serious personal injury.

• For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.

• Only certain types of glass, ceramic, earthenware, or other glazed utensils are suitable for oven use. Other types of materials may shatter with sudden temperature changes. Use only low or medium heat settings in accordance with the manufacturer’s guidelines.

• Do not heat unopened food containers as a build-up of pressure may cause the containers to burst.

• Do not use aluminum foil to line the oven racks or oven bottom. This can severely upset combustion air flow or trap excessive heat in the control area.

• Clean the oven with caution. To avoid steam burns, do not use a wet sponge or cloth to clean the oven while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.

• Never use a dented or rusty propane cylinder.

• Never attempt to use damaged or obstructed equipment. See your local Liquid Propane dealer for

repair.

• Liquid Propane cylinder must be stored outdoors out of reach of children and must not be stored in a building, garage or any other enclosed area.

Liquid Propane CYLINDER WARNING

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

PACKAGE CONTENTS LIST

A. Oven Body Assembly------1pc.

any other appliance.

• A Liquid Propane cylinder not connected for use should not be stored in the vicinity of this or any other appliance.

• Do not store spare Liquid Propane cylinders under or near this appliance.

• Never fill the cylinder beyond 80 percent capacity.

• Liquid Propane cylinders must be fitted with an Overfill Protection Device (OPD).

• If the information above is not followed exactly, a fire resulting in death or serious injury

could occur.

B. Liquid Propane Tank Barrier Bar----1pc.

C. Control Knob-------1pc.

HARDWARE CONTENTS

Pack Description Quantity

A 5/32-in. x 10-mm Truss Head Screw 2 pcs.

B 5/32-in. Locking Washer 2 pcs. C Set Screw 1pc. D Allen Wrench 1pc.

PREPARATION

Before beginning assembly of product, make sure all parts are present. Compare parts with package contents list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or operate the product. Contact customer service for replacement parts.

• Estimated Assembly Time: 10 minutes

A B

C D

• Tools Required for Assembly: Phillips Screwdriver (not included) and Allen Wrench (included)

ASSEMBLY INSTRUCTIONS

1. Control Knob Assembly

Place the control knob (A) onto the valve stem that is located on the control panel (B) as shown in Fig.1. Insert the set screw from pack C into the control knob and tighten using the Allen wrench found in pack D.

Fig. 1

+ 11 hidden pages