2.5HP AIR COMPRESSOR 24L CT2894
2.5HP AIR COMPRESSOR 24L CT2894
CT2894
ELECTRICAL DIAGRAMS
SPECIFI CAITONS
ATTENTION
SAVE THIS MANUAL
1
MODEL VOLTAGE
POWER
(KW/HP)TANK(L) CYLINDER
AIR
DELIVERY
(L/MIN)
PRESSURE
(PSI/BAR)
SPEED(R.P.M)
CT2894
230V/50Hz
24
1.8/2.5
266 116/8
47*1
2850
your agency.
GENERAL SAFETY WARNINGS AND PRECAUTIONS
2
The brass components of this product contain
lead. A chemical know to the state to cause birth
defects (or other reproductive harm).
When unpacking, check to make sure all parts and included. Refer to the Assembly Drawing and Parts
List at the end of this manual. If any parts are missing or broken, please call your agency as soon as possible.
5
5
8-13
UNPACKING
ASSEMBLY
BEFORE OPERATION CHECK
3
5
5
5
MOVING WAY
OPERATION
4
150
5
AIR COMPRESSOR EXPLOSIVE VIEW
NO
NONO
NO DESCRIPTION
DESCRIPTIONDESCRIPTION
DESCRIPTION QTY
QTYQTY
QTY NO
NONO
NO DESCRIPTION
DESCRIPTIONDESCRIPTION
DESCRIPTION QTY
QTYQTY
QTY
1 Bolt of cylinder cover M8*105 4 43 Rotator 1
2 Spring washer M8 4 44 rear bearing 1
3 Exhaust elbow 1 45 stator 1
4 cylinder cover 1 46 fan 1
5 air
filter 1 47 bearing
block 1
6 gasket of cylinder cover 1 48 spring washer 202 1
7 platen 1 49 shap ring 1
8 valve
sheet 1 50 capacitance 1
9 bolt M4*8 2 51 flat gasket M3 2
10 Spring
washer M4 2 52 spring washer M3 2
11 flat gasket M4 2 53 bolt M3*6 2
12 valve plate 1 54 spring washer M15 4
13 inlet valve sheet 1 55 bolt M5*105 4
14 upper
layer cushion of cylinder 1 56 bolt ST4.2*12 2
15 pin Ø3*6 2 57 bolt M5*16 2
16 cylinder
1 58 plastic cover 1
17 underlay of
cylinder 1 59 outlet valve 2
18 gaseous ring 2 60 regulator
1
19 oil ring 1 61 pressure switch 1
20 piston 1 62 safety valve 1
21 piston pin 1 63 connector of pressure switch 1
22 clamp spring 2 64 nut of pressure switch 1
23 connecting rod 1 65 paper washer 1
24 bolt of connecting 1 66 pressure gague Y40 2
25 crankshaft 1 67 nut M10*1 1
26 nut 3/8 2 68 unloading pipe 1
27 Exhaust pipe 1 69 lead wire of motor 1
28 air-cooling fin 1 70 wiring terminal-U 2
29 bolt of crankcase cover 6 71 wiring terminal-O 1
30 oil sight glass 1 72 lead wire of power supply 1
31 gasket ring 1 73 bolt of wheel 2
32 gasket ring 1 74 wheel 2
33 breather 1 75 spring
washer
M10 2
34 rubber of crankcase cover 1 76 nut M10 2
35 oil seal 1 77 drain cock 1
36 plug-screw M12*16 1 78 air tank 1
37 crankcase 1 79 handle 1
38 nut M8 7 80 plug of air tank 2
39 flat gasket M8 8 81 o-ring 1
40 spring washer M8 4 82 single-way valve 1
41 bolt M8*35 4 83 foot pad 1
42 front bearing 1 84 bolt M8*20 1
6
TROUBLES AND REMEDIES
7
Loading...