Napoleon EFL48, EFC32 Installation And Operating Instructions Manual

INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.

CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.

OPERATING INSTRUCTIONS

CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CSA C22.2 No.46 / UL 1278

EFL48

ELECTRIC FIREPLACE

1

INSTALLATION AND

CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.

SAFETY INFORMATION

!

WARNING

If the information in these instructions are
not followed exactly, a fi re or explosion
may result causing property damage,
personal injury or loss of life.

- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.

Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 4Y8 Canada /

Phone [phone] • Fax [phone] • www.napoleonfi replaces.com • [e-mail]

$10.00

103 Miller Drive, Crittenden, Kentucky, USA, 41030

1.16A

W415-0931 / A / 11.04.10

2

TABLE OF CONTENTS

1.0 INTRODUCTION 3

1.1 DIMENSIONS 4

1.2 LISTING APPROVALS 4

1.3 GENERAL INSTRUCTIONS 5

2.0 LOCATING APPLIANCE 6

2.1 UNPACKING AND TESTING APPLIANCE 6

2.2 GROUNDING APPLIANCE 6

3.0 INSTALLATION 7

3.1 MINIMUM CLEARANCE TO COMBUSTIBLES 7

3.2 MINIMUM MANTEL CLEARANCES 7

3.3 INSTALLING THE APPLIANCE 8

4.0 FINISHING 9

4.1 MEDIA INSTALLATION 9

4.2 GLASS FRONT INSTALLATION 9

5.0 OPERATING INSTRUCTIONS 10

5.1 MAIN POWER SWITCH 10

5.2 OPERATING BY CONTROL PANEL 10

5.3 OPERATING BY REMOTE CONTROL 11

6.0 MAINTENANCE 12

6.1 REPLACING THE LAMP 12

7.0 REPLACEMENT PARTS 13

8.0 TROUBLE SHOOTING 14

9.0 WARRANTY 15

10.0 SERVICE HISTORY 16

NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.

W415-0931 / A / 11.04.10

1.0 INTRODUCTION

• THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF
CONTACTED.

• Do not operate appliance before reading and understanding operating instructions. Failure to operate
appliance according to operating instructions could cause fi re or injury.

• Risk of burns. Power to the appliance should be turned off and the appliance allowed to cool before
servicing. To disconnect power to the appliance, turn controls to off, then remove plug from outlet.

• Do not install damaged, incomplete or substitute components.

• Do not burn wood or other materials in this appliance.

• Young children should be carefully supervised when they are in the same room as the appliance.

Toddlers, young children and others may be susceptible to accidental contact burns. A physical barrier
is recommended if there are at risk individuals in the house. To restrict access to an appliance or stove,
install an adjustable safety gate to keep toddlers, young children and other at risk individuals out of the
room and away from hot surfaces.

• Clothing or other fl ammable material should not be placed on or near the appliance.

• Due to high temperatures, the appliance should be located out of traffi c and away from furniture and
draperies.

• Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot
surfaces.

• Even after the appliance is out, the glass and/or screen will remain hot for an extended period of time.

• Check with your local hearth specialty dealer for safety screens and hearth guards to protect children
from hot surfaces. These screens and guards must be fastened to the fl oor.

• Any safety screen or guard removed for servicing must be replaced prior to operating the appliance.

• It is imperative that the control compartments, circulating blower and its passageway in the appliance
and are kept clean. The appliance should be inspected before use and at least annually by a qualifi ed
service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding
material, etc. The appliance area must be kept clear and free from combustible materials, gasoline and
other fl ammable vapors and liquids.

• Under no circumstances should this appliance be modifi ed.

• Do not use this appliance if any part has been under water. Immediately call a qualifi ed service technician
to inspect the appliance and to replace any part of the control system which has been under water.

• Do not operate the appliance with the glass door removed, cracked or broken. Replacement of the
glass should be done by a licensed or qualifi ed service person.

• Do not strike or slam shut the appliance glass door.

• Keep the packaging material out of reach of children and dispose of the material in a safe manner. As
with all plastic bags, these are not toys and should be kept away from children and infants.

• Servicing should be done only while the appliance is disconnected from the power supply circuit.

• Always unplug appliance when not in use.

• Do not operate this appliance with a damaged cord or plug after the appliance malfunctions, has been
dropped or damaged in any manner. Return appliance to authorized service facility for examination,
electrical or mechanical adjustment, or repair.

• Do not use outdoors.

• Never locate appliance where it may fall into a bathtub or other water container.

• Do not run cord under carpeting. Do not cover cord with throw rugs, runners, or the like. Arrange cord
away from traffi c area and where it will not be tripped over.

• Connect to properly grounded outlets only.

• Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an
electric shock or fi re, or damage the appliance.

• To prevent a possible fi re, do not block air intakes or exhaust in any manner. Do not use on soft
surfaces, like a carpet, where openings may become blocked.

• Always plug appliances directly into a wall outlet/receptacle. Never use an extension cord or
relocatable power tap (outlet/power strip).

• Ensure clearances to combustibles are maintained when building a mantel or shelves above the
appliance. Elevated temperatures on the wall or in the air above the appliance can cause melting,
discolouration or damage to decorations, a T.V. or other electronic components.

!

WARNING

3

3.7C

W415-0931 / A / 11.04.10

4

1.1 DIMENSIONS

Front View

48.0”

1.2 LISTING APPROVALS

This appliance has been tested in accordance with the CSA and UL Standards for fi xed and location-dedicated
electric room appliances in the United States and Canada. If you need assistance during installation, please
contact your local dealer.

NOTE: This appliance must be electrically wired and
grounded in accordance with local codes. In the absence
of local codes, us the current CSA C22.1 Canadian
Electrical Code in Canada or the ANSI/NFPA 70 National
Electrical Code in the United States.

22.0”

Side View

6.5”

FAN

HEAT2

HEAT1

FLAME

FUNCTION

POWER

21.75”

Top View

38.25”

Model Number EFL48

Description Wall-Mount Appliance

Voltage 120V AC / 60HZ

Watts MAX 1500W
Amps 15 AMP Grounded Circuit

Appliance Width 48.0"

Appliance Height 21.75"

Appliance Depth 6.5"

Gross Weight 56 lbs

W415-0931 / A / 11.04.10

1.3 GENERAL INSTRUCTIONS

READ THESE INSTRUCTIONS COMPLETELY BEFORE BEGINNING INSTALLATION. FAILURE TO

FOLLOW THEM COULD CAUSE AN APPLIANCE MALFUNCTION RESULTING IN SERIOUS INJURY

ALL ELECTRIC APPLIANCES HAVE HOT AND ARCING OR SPARKING PARTS INSIDE. DO NOT USE

IT IN AREAS WHERE GASOLINE, PAINT OR FLAMMABLE LIQUIDS ARE PRESENT.

THIS ELECTRIC APPLIANCES IS TESTED AND LISTED FOR USE ONLY WITH THE OPTIONAL

ACCESSORIES LISTED IN THESE INSTRUCTIONS. USE OF OPTIONAL ACCESSORIES NOT

SPECIFICALLY TESTED FOR THIS ELECTRIC APPLIANCE COULD VOID THE WARRANTY AND/OR

DO NOT OPEN. RISK OF ELECTRIC SHOCK. NO USER-SERVICEABLE PARTS INSIDE.

DO NOT USE DAMAGED ELECTRICAL CORDS.

SERVICING SHOULD BE DONE ONLY WHILE THE APPLIANCE IS DISCONNECTED FROM THE

HIGH TEMPERATURE, RISK OF FIRE. KEEP ELECTRICAL CORDS, DRAPERY, FURNISHINGS, AND

OTHER COMBUSTIBLES AT LEAST 3 FEET (0.9M) FROM THE FRONT OF THE APPLIANCE AND

TO PREVENT ELECTRIC SHOCK MATCH THE WIDE BLADE OF PLUG TO WIDE SLOT OF

RECEPTACLE AND FULLY INSERT.

!

WARNING

AND/OR PROPERTY DAMAGE.

RESULT IN A SAFETY HAZARD.

POWER SUPPLY CIRCUIT.

AWAY FROM SIDES AND REAR.

5

This electric appliance meets the construction and safety standards of H.U.D. for application in manufactured
homes when installed according to these instructions.

1. Prior to plugging your appliance into an electrical outlet, verify that the house circuit breakers for the outlet
are on.

2. The appliance may emit a slight, harmless odour when fi rst used. This odour is normal and it is caused by
the initial heating of internal appliance elements and will not occur again.

3. If your appliance does not emit heat, consult the operation section of this manual for further information.

4. Use with a CSA or UL certifi ed surge protector.

4.8

W415-0931 / A / 11.04.10