Multiquip wrs5200 User Manual
PARTS MANUAL
MODEL WRS5200
RIDE-ON ROLLER SCREED
(VANGUARD DM950 DIESEL ENGINE)
Revision #1 (11/12/10)
To find the latest revision of this
publication, visit our website at:
www.multiquip.com
THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
PN: 36861
TABLE OF CONTENTS
Wrs5200 Ride-On
Roller Screed
Table Of Contents .................................................... 2
Parts Ordering Procedures ...................................... 3
Explanation Of Code In Remarks Column .............. 4
Suggested Spare Parts ........................................... 5
Nameplate & Decals (Engine & Operator Ends) .. 6-7
Nameplate & Decals (Rider Guard & Frames) ..... 8-9
Nameplate & Decals (Power Unit) .................... 10-11
Operator Seat Assembly. .................................. 12-13
Throttle Assembly. ............................................. 14-15
Stack Valve Assembly. ...................................... 16-17
Speed Control Valve Assembly. ........................ 18-19
Solenoid Valve Assembly. ................................. 20-21
Drive Tube Motor Assembly. .............................. 22-23
Control Box Assembly. ...................................... 24-25
Power Unit Frame Assembly. ............................ 26-27
Lift Bale Assembly. ............................................ 28-29
Lights Assembly. ...............................................30-31
Fuel Assembly. .................................................. 32-33
Battery Assembly. ............................................. 34-35
Hydraulic Tank / Cooler Assembly. .................... 36-37
Hydraulic Pump Assembly. ...............................38-39
Control Valve Assembly. .................................... 40-41
Loop Flushing Valve Assembly. ......................... 42-43
Strike Tube Motor Assembly. ............................. 44-45
Engine Assembly. .............................................. 46-47
Engine Controller / Power Cable Assembly. ......48-49
Pressure Washer Assembly. ............................. 50-51
5' Frame Assembly. (Operator End) ................. 52-53
5' Frame Assembly. (Engine End) .................... 54-55
Caster Assembly. .............................................56-57
Frame Section Assemblies ............................... 58-59
Tarp Assemblies ............................................... 60-61
WRS1400LP Assembly. .................................... 62-63
WRS1600LP Assembly. .................................... 64-65
WRS1800LP Assembly. .................................... 66-67
WRS2200LP Assembly. .................................... 68-69
WRS2600LP Assembly. .................................... 70-71
WRS2800LP Assembly. .................................... 72-73
WRS3200LP Assembly. .................................... 74-75
WRS3600LP Assembly. .................................... 76-77
WRS4000LP Assembly. .................................... 78-79
WRS4400LP Assembly. .................................... 80-81
WRS4800LP Assembly. .................................... 82-83
WRS5200LP Assembly. .................................... 84-85
Shaft Puller Assembly ......................................86-87
Terms And Conditions Of Sale — Parts ................ 88
NOTICE
Part numbers are subject to change without notice.
PAGE 2 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
PARTS ORDERING PROCEDURES
Ordering parts has never been easier!
If you have an MQ Account, to obtain a Username
Effective:
Choose from three easy options:
January 1st, 2006
Best Deal!
Order via Internet (Dealers Only):
Order parts on-line using Multiquip’s SmartEquip website!
■ View Parts Diagrams
■ Order Parts
■ Print Specifi cation Information
Goto www.multiquip.com and click on
Order Parts
to log in and save!
Order via Fax (Dealers Only):
All customers are welcome to order parts via Fax.
Domestic (US) Customers dial:
1-800-6-PARTS-7 (800-672-7877)
Order via Phone:
Non-Dealer Customers:
Contact your local Multiquip Dealer for
parts or call 800-427-1244 for help in
locating a dealer near you.
and Password, E-mail us at: parts@multiquip.
com.
To ob ta in an MQ Ac co unt , c on tac t yo ur
District Sales Manager for more information.
Use the internet and qualify for a 5% Discount
on Standard orders for all orders which include
complete part numbers.*
Fax your order in and qualify for a 2% Discount
on Standard orders for all orders which include
complete part numbers.*
Domestic (US) Dealers Call:
1-800-427-1244
International Customers should contact
their local Multiquip Representatives for
Parts Ordering information.
Note: Discounts Are Subject To Change
Note: Discounts Are Subject To Change
When ordering parts, please supply:
❒ Dealer Account Number
❒ Dealer Name and Address
❒ Shipping Address (if different than billing address)
❒ Return Fax Number
❒ Applicable Model Number
❒ Quantity, Part Number and Description of Each Part
NOTICE
All orders are treated as Standard Orders and will
ship the same day if received prior to 3PM PST.
❒ Specify Preferred Method of Shipment:
✓ UPS/Fed Ex ✓ DHL
■ Priority One ✓ Truck
■ Ground
■ Next Day
■ Second/Third Day
www.multiquip.com
WE ACCEPT ALL MAJOR CREDIT CARDS!
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 3
EXPLANATION OF CODE IN REMARKS COLUMN
The following section explains the different symbols and
PART NO. Column
QTY. Column
— Item quantity can be indicated by a
A/R (As Required) is generally used for hoses or other
A blank entry generally indicates that the item is not sold
separately. Other entries will be clarifi ed in the “Remarks”
Some of the most common notes found in the “Remarks”
Column are listed below. Other additional notes needed
same unique symbol will be included when this item is
— Used to list an effective serial
— Indicates that the part
part is NOT used on a specifi c model or model number
available items. Examples include battery cables, shims,
— Indicates that an item cannot
be purchased as a separate item and is either part of an
assembly/kit that can be purchased, or is not available
remarks used in the Parts section of this manual. Use the
help numbers found on the back page of the manual if there
are any questions.
Numbers Used
number, a blank entry, or A/R.
NOTICE
The contents and part numbers listed in the parts
section are subject to change without notice. Multiquip
does not guarantee the availability of the parts listed.
SAMPLE PARTS LIST
NO. PART NO. PART NAME QTY. REMARKS
1 12345 BOLT ......................1 .....INCLUDES ITEMS W/%
2% WASHER, 1/4 IN. ...........NOT SOLD SEPARATELY
2% 12347 WASHER, 3/8 IN. ...1 .....MQ-45T ONLY
3 12348 HOSE ..................A/R ...MAKE LOCALLY
4 12349 BEARING ..............1 .....S/N 2345B AND ABOVE
NO. Column
Unique Symbols — All items with same unique
symbol
(@, #, +, %, or >) in the number column belong to the
same assembly or kit, which is indicated by a note in the
“Remarks” column.
Duplicate Item Numbers — Duplicate numbers indicate
multiple part numbers, which are in effect for the same
general item, such as different size saw blade guards in
use or a part that has been updated on newer versions
of the same machine.
NOTICE
When ordering a part that has more than one item
number listed, check the remarks column for help in
determining the proper part to order.
parts that are sold in bulk and cut to length.
Column.
REMARKS Column
to describe the item can also be shown.
Assembly/Kit — All items on the parts list with the
purchased.
Indicated by:
“INCLUDES ITEMS W/(unique symbol)”
Serial Number Break
number range where a particular part is used.
Indicated by:
“S/N XXXXX AND BELOW”
“S/N XXXX AND ABOVE”
“S/N XXXX TO S/N XXX”
Specifi c Model Number Use
is used only with the specifi c model number or model
number variant listed. It can also be used to show a
variant.
Indicated by:
Numbers Used — Part numbers can be indicated by a
number, a blank entry, or TBD.
TBD (To Be Determined) is generally used to show a
part that has not been assigned a formal part number
at the time of publication.
A blank entry generally indicates that the item is not sold
separately or is not sold by Multiquip. Other entries will
be clarifi ed in the “Remarks” Column.
“XXXXX ONLY”
“NOT USED ON XXXX”
“Make/Obtain Locally” — Indicates that the part can
be purchased at any hardware shop or made out of
and certain washers and nuts.
“Not Sold Separately”
for sale through Multiquip.
PAGE 4 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
SUGGESTED SPARE PARTS
WRS5200 RIDE-ON ROLLER SCREED WITH VANGUARD DM950 DIESEL ENGINE
1 to 3 units
Qty. P/N Description
3................11402................FILTER, HYDRAULIC OIL
1................16219................MOTOR, DRIVE TUBE
3................16222................SHAFT, SPLINED
2................16223................BEARING, 1-3/8" -DRIVE AND STRIKE TUBE
2................16224................BEARING, 1-1/4" -INNER STRIKE TUBE
5................16298................COUPLING, STRIKE TUBE
5................16396................PIN, LEVER-DETACHABLE
1................16409................MOTOR, STRIKE TUBE
2................16564................FITTING,1/2 FEMALE QC
2................16565................FITTING,1/2 MALE QC
2................16566................FITTING,3/4 FEMALE QC
2................16567................FITTING,3/4 MALE QC
1...............820311...............FUEL FILTER
1 ..............820314...............OIL FILTER
1...............820263...............AIR FILTER ELEMENT
1...............821075...............V-BELT
1...............821135...............SWITCH, OIL PRESSURE
1...............825064...............THERMOSTAT
1...............820208...............SWITCH, WATER TEMPERATURE
1...............825700...............STARTER
1...............825084...............ALTERNATOR
1...............825134...............HOSE, RADIATOR, UPPER, OUTLET
1...............825133...............HOSE, RADIATOR, LOWER, INLET
NOTICE
Part numbers on this Suggested Spare Parts list may
supersede/replace the part numbers shown in the
following parts lists.
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 5
NAMEPLATE AND DECALS (ENGINE & OPERATOR ENDS)
5 FOOT FRAME ASSY.
(ENGINE END)
3
6
4
1
CAUTION
10
CAUTION
9
2 3
CAUTION
6
LIFTING
POINT
P/N 36093
11
P/N 36096
P/N 36093
5
LUBE
11
4
Keep hands and feet
clear of drive tube
while in operation.
7
5 FOOT FRAME ASSY.
(OPERATOR END)
5
4
7
Keep hands and feet
clear of drive tube
while in operation.
13
5
12
8
CAUTION
1
P/N 36096
2
4
5
8
PAGE 6 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
NAMEPLATE AND DECALS (ENGINE & OPERATOR ENDS)
NO. PART NO. PART NAME QTY. REMARKS
1 36096 DECAL, NO CENTER LIFT-SHORT 2
2 36097 DECAL, TARP INSTRUCTIONS 2
3 36093 DECAL, REMOVE POWER UNIT 2
4 26401 DECAL, SUPER SCREED 4
5 36103 DECAL, PINCH POINTS 8
6 16563 DECAL, MQ WHITEMAN 2
7 36094 DECAL, CRUSH POINT 2
8 36100 DECAL, MOVING PARTS 2
9 36482 DECAL, REMOVE STRIKE TUBE MOTOR 1
10 36483 DECAL, GUARD WARNING 1
11 16925 DECAL, LUBE AND LIFT 1
12 13118 DECAL, POWDER COATED 1
13 DECAL, SERIAL PLATE ....................................1................CONTACT UNIT SALES
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 7
NAMEPLATE AND DECALS (RIDER GUARD & FRAMES)
2
3
1
5
4
12
11
P/N 36481
6
7
8
9
10
PAGE 8 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
NAMEPLATE AND DECALS (RIDER GUARD & FRAMES)
NO. PART NO. PART NAME QTY. REMARKS
1 36104 DECAL, SUPER SCREED 1
2 36826 DECAL, OPERATOR PRESENCE 1
3 36484 DECAL, DRIVE TUBE DIRECTION 1
4 36481 DECAL, HORN 1
5 35137 DECAL, READ MANUAL, ASK FOR TRAINING 1
6 16926 DECAL, WRS SETUP 1
7 16563 DECAL, MQ WHITEMAN 2
8 16562 DECAL, WRS-5200 2
9 36483 DECAL, GUARD WARNING 2
10 36095 DECAL, LIFTING-LONG ......................................... 1 .......... EACH FRAME SECTION
............................................................................................. REQUIRES QTY 1
11 36099 DECAL, SAFETY 1
12 36485 DECAL, STRIKE TUBE 1
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 9
NAMEPLATE AND DECALS (POWER UNIT)
CAUTION
2 3
P/N 36093
4
1
5
WARNING
DIESEL FUEL can cause
fire or explosion.
Stop engine before fueling
Keep cigarettes, sparks
and flame away.
P/N 36092
6
7
PAGE 10 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
NAMEPLATE AND DECALS (POWER UNIT)
NO. PART NO. PART NAME QTY. REMARKS
1 36098 DECAL, EMERGENCY OFF 1
2 36090 DECAL, VENTILATION 2X4 1
3 36093 DECAL, POWER UNIT REMOVAL 1
4 11811 DECAL, DIESEL FUEL 5.13, BLACK 1
5 36092 DECAL, DIESEL FUEL 3.5 X 1.75 1
6 16908 DECAL, PRESSURE WASHER 1
7 DECAL, SERIAL PLATE ....................................1................CONTACT UNIT SALES
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 11
OPERATOR SEAT ASSY.
4
3
2
6
5
1
4
3
8
19
18
17
21
16
14
13
14
12
7
15
10
14
11
23
9
19
13
22
18
20
22
PAGE 12 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
OPERATOR SEAT ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 21852 SEAT,MICHIGAN ADJUSTABLE W/ARMS ........1................INCLUDES ITEMS W/%
2% 21860 SEAT, BASIC-MICHIGAN V-2805 SERIES 1
3% 21868 ARMREST KIT, SEAT ........................................1................INCLUDES ITEMS W/#
4%# 21869 SCREW, 5/16-18 SELF TAPPING 6
5% 21865 ADJUSTKER KIT, SEAT 1
6% 21870 KILL SWITCH, SEAT-DELTA SYS 1
7 16748 GUARD,RIDER 1
8 16506 MOUNT, RIDER GUARD 1
9 36824 MOUNT, RIDER GUARD CABLE END 1
10 29057 DOCUMENT BOX, CP9000-07 1
11 0730 SCREW, HHC 1/4-20 X 1 4
12 36804 PLATE,SEAT 1
13 5283 NUT, NYLOC 5/16-18 8
14 0300 B WASHER, FLAT SAE 5/16 12
15 19468 GROMMET, MINOR Z-4004 1
16 0655 SCREW, HHC 5/16-18 X 3/4 4
17 16402 GRID,NON SKID 2
18 9154 SCREW, HHC 3/8-16 X 1 3/4 8
19 10133 NUT, NYLOC 3/8-16 8
20 5277 SCREW, HHC 1/4-20 X 1 1/2 8
21 16504 STABILIZER, RIDER 4
22 10024 NUT, NYLOC 1/4-20 12
23 0948 WASHER, FLAT SAE 1/4 4
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 13
THROTTLE ASSY.
FRAME
2
1
4
3
HYDRAULIC
PUMP
11
6
6
7
10
8
6
9
POWER UNIT
5
PAGE 14 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
THROTTLE ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 11379 HAND THROTTLE CONTROL 1
2 4514 SCREW, HHC 1/4-20 X 5/8 GR5 2
3 3513 SCREW, HHF 10-32 X 1 1
4 10019 NUT, NYLOC 10-32 1
5 2153 ROD END, 10-32 FEMALE RH 1
6 0937 NUT, FULL HEX 10-32 ZINC PLATED 3
7 26884 CABLE, TUBE SPEED 16 FT 1
7 16394 CABLE, TUBE SPEED 50 FT 1
8 16500 NUT, WING 1/2-13 1
9 5054 A WASHER, LOCK 1/2 MED 1
10 16501 MOUNT, CABLE 1
11 16396 BALL JOINT, QUICK CONNECT 10-32, P1000 1
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 15
HYDRAULIC
TANK
27
11
26
STACK VALVE ASSY.
13
22
23
24
25
9
8
5
9
4
6
3
4
5
7
17
16
18
19
20
SPEED
13
9
CONTROL
VALVE
4
7
1
DRIVE
TUBE
MOTORS
2
11
15
PAGE 16 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
STACK VALVE ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 16221 VALVE, STACK 1
2 1023 SCREW, HHC 3/8-16 X 1-1/4 GR 5 3
3 16588 FITTING, 90 10FJ - 1/2MP 1
4 16564 FITTING, QD PARKER H4-62 FEM 1/2FP 4
5 16579 HOSE, 60" OAL 1/2HOSE-8FJX8NP 2
6 16590 FITTING, 45 1/2MP-1/2MP 2
7 16568 PLUG, DUST PARKER H4-65M 2
8 16569 CAP, DUST PARKER H4-66M 2
9 16565 FITTING, QD PARKER H4-63 MALE 1/2FP 4
11 26883 HOSE, 192" OAL 8MPX8FJ 2
11 16578 HOSE, 594" OAL 1/2HOSE - 8MPX8FJ 2
13 16589 FITTING, 90 1/2MP-1/2MP 2
15 10133 NUT, NYLOC 3/8-16 3
16 16582 FITTING, STR 12MO-1/2MP 1
17 11718 FITTING, 90 1/2FP-1/2FP 1
18 16583 FITTING, TEE 8MP - 1/2FP - 1/2FP RUN 1
19 36687 FITTING, STR 1/2MP X 10MJ LONG 1
20 36688 HOSE ASSY 1/2" 1
22 16585 FITTING, BUSH 1/2FP-3/4MP 1
23 16566 FITTING, QD PARKER H6-62 FEM 3/4FP 1
24 16570 COVER, FEMALE 3/4 H6-65M 1
25 16567 FITTING, QD PARKER H6-63 MALE 3/4FP 1
26 16577 HOSE, 606" OAL 1/2HOSE-12MPX12MP 1
26 26882 HOSE, 192" OAL 12MPX12MP 1
27 36629 GUARD, OPERATOR 1
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 17
STACK
VALVE
HYDRAULIC
TANK
14
13
11
SPEED CONTROL VALVE ASSY.
5
4
3
2
1
13
SOLENOID
VALVE
9
10
7
8
12
6
PAGE 18 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
SPEED CONTROL VALVE ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 16220 VALVE, SPEED CONTROL 1
2 16596 FITTING, STR 3/4MP-1/2MP 1
3 16592 FITTING, 90 3/4FP - 12MO 1
4 16730 HANDLE, SPEED CONTROL 1
5 16788 HANDLE, TAPERED 1
6 16589 FITTING, 90 1/2MP-1/2MP 1
7 36084 FITTING, TEE 1/2FP - 10MJ - 1/2MP RUN 1
8 16585 FITTING, BUSH 1/2FP-3/4MP 1
9 16567 FITTING, QD PARKER H6-63 MALE 3/4FP 1
10 16571 COVER, MALE 3/4 H6-66M 1
11 16566 FITTING, QD PARKER H6-62 FEM 3/4FP 1
12 36085 FITTING, TEE 10MJ - 1/2MP - 10MJ BRANCH 1
13 36112 HOSE ASM, 1/2ID X 15-1/4 90 END 1
14 26882 HOSE, 192" OAL 12MPX12MP 1
14 16577 HOSE, 606" OAL 1/2HOSE - 12MPX12MP 1
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 19
SPEED
CONTROL
VALVE
SOLENOID VALVE ASSY.
6
5
7
4
3
1
2
3
PAGE 20 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
SOLENOID VALVE ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 36107 VALVE, SOLENOID 1
2 11396 FITTING, 90 8MJ-8M0 1
3 36113 FITTING, 45 8MJ-8FJ 2
4 11749 FITTING, STR 8MJ-8M0 1
5 26250 SCREW, HHC 1/4-20 X 1-3/4 2
6 0948 WASHER, FLAT SAE 1/4 2
7 10024 NUT, NYLOC 1/4-20 2
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 21
DRIVE TUBE MOTOR ASSY.
STACK
VALVE
2
1
1
4
3
4
1
1
PAGE 22 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
DRIVE TUBE MOTOR ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 16219 MOTOR, HYD CHAR-LYNN 4
2 16580 FITTING, 45 8MJ-10MO 4
3 26010 FITTING, 90 8MJ-10MO 4
4 26011 HOSE ASM, 1/2ID X 21-8FJ-8FJ 2
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 23
CONTROL BOX ASSY.
15
10
11
4
16
21
11
8
2
11
19
23
20
11
24
12
1
POWER
CABLE
PLATE
(POWER
UNIT)
17
5
1
7
1
18
6
22
9
3
14
PAGE 24 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
CONTROL BOX ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 11152 NUT, NYLOC 6-32 8
2 16389 SWITCH, TOGGLE 2
3 16392 GRIP, CORD CGB296 1
4 16510 BUTTON, EMERGENCY STOP 1
5 16511 BLOCK, CONTACT 1
6 26560 NUT, LOCKING 3/4 NPT CONDUIT 1
7 2673 CIRCUIT BREAKER, 30A 12V 1
8 26996 DECAL, CONTROL WRSDPU 1
9 36004 BOX, ELEC-BASE 1
10 36005 BOX, ELECTRIC LID 1
11 36010 SCREW, BHSC 6-32 X 1/2 8
12 36019 CORD, ASM, 55' DIESEL 1
14 36134 BYPASS WIRE ASM, CONTROL BOX 1
15 36159 HARDWARE, HOFFMAN A-843DSC 1
16 8381 BOOT, TOGGLE SWITCH 2
17 36007 SWITCH, FLANGED RELAY 2
18 36008 GLOW PLUG TIMER 1
19 36009 HOUR METER 1
20 36015 FUSE MOUNT, PANEL CHASSIS 1
21 36049 LED MOUNT 5
22 36051 LED PANEL LIGHT 5
23 36052 FUSE, 15A 1
24 10958 IGNITION SWITCH 1
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 25
POWER UNIT FRAME ASSY.
9
10
11
12
10
9
1
2
8
2
2
2
4
3
12
11
7
6
5
3
PAGE 26 — WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10)
POWER UNIT FRAME ASSY.
NO. PART NO. PART NAME QTY. REMARKS
1 26971 FRAME, WRSDPU 1
2 16233 WHEEL 4
3 3615 COLLAR, SET 3/4 ID 4
4 26995 GRILL, RADIATOR 1
5 0730 SCREW, HHC 1/4-20 X 1 8
6 0181 B WASHER, LOCK 1/4 MED 8
7 0948 WASHER, FLAT, 1/4 SAE 8
8 10176 NUT, NYLOC 1/2-13 8
9 4370 SCREW, HHC 3/8-16 X 2-1/4 2
10 16195 HANDLE, SCREED 2
11 1724 GRIP, HANDLE 2
12 10133 NUT, NYLOC 3/8-16 2
WRS5200 RIDE-ON ROLLER SCREED • PARTS MANUAL — REV. #1 (11/12/10) — PAGE 27
Loading...