Model SC1000
MODEL SC1000 BASE PARTS LIST-1
MODEL SC1000 BASE PARTS LIST-1
Model_SC1000_2.pdf
Model SC1000
MODEL SC1000 BASE PARTS LIST-1
# PART # DESCRIPTION QTY Note
1 000000979 Tube - 0.75" ID x 0.125" W x 72.0" L - Rubber
2 000001755 Switch Cover
3 3002773 Coil Water 0.5" Copper
4 2002743 Low Water Pressure Switch - 4 PSI
5 000001430 Air Filter
6 3001723 Stand Pipe - 24.25"
Detail B (Agitator Motor)
7 00213237 TS Motor Assembly Kit Domestic/International - 230 VAC,
50/60 Hz
7a 00215727 Agitator Motor Bracket
7b 00377102 Washer - Water Slinger
7c 00751208 Propeller [2]
7d 00856302 Washer
7e 00859119 Tab Clamp - SS
7f 00859503 Roll Pin - 0.09" x 0.6" SS
7g RM156120 Electrical Sleeve Tubing
7h 00213018 Agitator Motor - 230V/50-60 Hz
8 7601431 Heat Sink Tube Assembly and Clamp
Detail C (Manifold)
9 5001983 Adaptor - 0.5" Barb x 0.5"
10 5001963 Adapter - 0.25" Barb x 0.375" MPT
11 000001973 Manifold Water 3 Outlet
12 000002232 Manifold Water 3 Outlet
13 5001023 Valve Ball - 0.375" FPT x 0.375" FPT Brass
14 5001343 Shut-off Valve - 0.375" OD x 0.25"
15 6052031 Bracket - Drain Hose
16 5001673 Screw - #10-32 x 0.5"
17 5001063 Drain Fitting - 0.75" - Brass
18 00206387 Drain Nut - 0.75"
19 5001793 Washer Tapered Flare - 0.5" - Nylon
20 5002033 Nut - 0.5" Flare - Brass
21 5001613 O-ring, Rubber - .750 OD X .625 ID
PART NOTES:
[1] - Agitator w/Heat Sink Tube Domestic/International - 230 VAC, 50/60 Hz
[2] - International
[1]
MODEL SC1000 BASE PARTS LIST-1
Model_SC1000_2.pdf
Model SC1000
MODEL SC1000 BASE PARTS LIST-2
MODEL SC1000 BASE PARTS LIST-2
Model_SC1000_3.pdf
Model SC1000
MODEL SC1000 BASE PARTS LIST-2
# PART # DESCRIPTION QTY Note
1 Thermal Expansion Valve
1a 8251483 Expansion Valve - Non-ERC Units
1b 000003206 Expansion Valve - ERC Units
Detail E [1]
2 4010243 Boot- Pump Motor
3 4010253 Boot - Pump Motor
4 2002753 Pump - 100 GPH - SS
5 5001803 Adaptor - 0.375" MF x 0.375" MPT - SS
6 2002543 Carbonator Motor - 230V 1-3 HP
7 5001943 Elbow - 0.375" x 0.375" Barb
8 5009036 CLAMP PUMP CARB
Detail F [2]
9 2002893 Toggle Switch - 16A - 0.75 HP
10 2002523 Red Light - 250V
Detail G [3]
11 Liquid Level Control
11a 00219104 Liquid Level Control 120V
11b 00219105 Liquid Level Control 220V
12 2002483 Time Delay Relay
13 2002733 Electronic Sensor - Ice Bank Control
14 020001414 Electronic Sensor - Ice Bank Control - 230V
15 Contactor - 3 Pole
15a 2007879 Contactor - 120-230V/60 Hz/3 Ph
15b 2003173 Contactor - 220-400V/50 Hz/3 Ph
Detail G [4]
16 020002329 HPCO Wiring Harnesss
17 020001985 Control Board
18 020002142 Water/Glycol Water Bath Temperature Sensor
19 020002143 Water Level Sensor
20 020001987 Ribbon Cable
21 000001452 Ground Terminal
22 020002091 Ice Bank Control
23 020001986 Key Pad Display
24 020002070 Wiring Harness - Pressure Switch
25 020001992 Pressure Switch
26 000001986 Barbed Fitting
27 020001991 Temperature Thermistor
28 5003143 Tee - 0.375" x 0.375" Barb x 0.25" MF SS
29 000003157 Bracket - Key Pad
30 5002003 Nut - 0.25" Flare
PART NOTES:
[1] - Water Motor & Pump
[2] - Switches Non-ERC Models only
[3] - Non-ERC Models only before S/N 110757274
[4] - ERC Models
MODEL SC1000 BASE PARTS LIST-2
Model_SC1000_3.pdf
Model SC1000
MODEL SC1000 PANELS
MODEL SC1000 PANELS
Model_SC1000_4.pdf
Model SC1000
MODEL SC1000 PANELS
# PART # DESCRIPTION QTY Note
1 6051791 Top Cover
2 000002649 Back Panel
3 000002652 Motor Mounting
4 000002657 Back Corner Panel
5 000002647 Bulkhead Panel
6 000002653 Control Box
7 000002650 Left Side Panel
8 000002648 Front Panel - Left
9 000002953 Front Panel - Right
10 000002654 Right Side Panel
11 000002651 Right Corner Panel
12 000002658 Water/Remote Coupling Panel [1]
PART NOTES:
[1] - not shown
MODEL SC1000 PANELS
Model_SC1000_4.pdf
Model SC1000
SC1000A & SC1000AX (AIR COOLED PARTS)
SC1000A & SC1000AX (AIR COOLED PARTS)
Model_SC1000_5.pdf
Model SC1000
SC1000A & SC1000AX (AIR COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 000002656 Condenser Housing
2 2416203 Fan Blade
3 2412939 Fan Motor 208-230V/50-60 Hz
4 000002689 Condenser Coil
5 Compressor
5a 8251453 Compressor - 230V/60 HZ/1 Ph [1]
2002563 Start Relay - 230V/60 Hz/1 Ph
8503143 Start Capacitor - 115V/60 Hz/1 Ph
000001396 Run Capacitor 115V/60 Hz/1 Ph
5b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [2]
5c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [1]
2004333 Start Relay
2004343 Start Capacitor - 88-106MFD - 220V
00215798 Run Capacitor
00217389 Protector
5d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [2]
6 000008894 Receiver
7 6072461 Fan Motor Bracket
8 8930279 Drier
9 Liquid Line Solenoid Assemlbly Kit
9a 7630031 Solenoid Valve Including 115V Coil [3]
9b 7630091 Solenoid Valve Including 208-230V Coil [3]
10 2001243 High pressure cut-out
11 Solenoid Valve Coils
11a 000005156 Solenoid Valve Coil Only - 115V/60 Hz [4]
11b 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [5]
12 Refrigerant Solenoid Valve
12a 8251373 Solenoid Valve Only - EVU4 [3]
12b 000006495 Solenoid Valve Only - EVU3 [6]
13 000000805 Valve Bracket [3]
14 5202063 Screw - #10-24 x 0.5" HEX SS
15 000001329 Receiver Bracket
16 000001426 Manifold - 3 Port [7]
PART NOTES:
[1] - For SS Units
[2] - For TS & ERC Units
[3] - For Units Prior to Serial 110952651
[4] - \pages from 000005156_02.jpg" width=280 height=256>
[5] - \pages from 000005156_02.jpg" width=266 height=183>
[6] - For Serial 110952651 and Up 3/8in x 3/8in
[7] - not shown
SC1000A & SC1000AX (AIR COOLED PARTS)
Model_SC1000_5.pdf
Model SC1000
SC1000W & SC1000WX (WATER COOLED PARTS)
SC1000W & SC1000WX (WATER COOLED PARTS)
Model_SC1000_6.pdf
Model SC1000
SC1000W & SC1000WX (WATER COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 000008894 Receiver
2 8372069 Water Regulating Valve
3 6020541 Receiver Strap
4 000002658 Water/Remote Coupling Panel
5 8706083 Female Wing Adapter - 0.50"
6 Compressor
6a 8251453 Compressor - 230V/60 HZ/1 Ph [1]
2002563 Start Relay - 230V/60 Hz/1 Ph
8503143 Start Capacitor - 115V/60 Hz/1 Ph
000001396 Run Capacitor 115V/60 Hz/1 Ph
6b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [2]
6c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [1]
2004333 Start Relay
2004343 Start Capacitor - 88-106MFD - 220V
00215798 Run Capacitor
00217389 Protector
5d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [2]
7 000000046 Water-cooled Condenser
8 2001243 High pressure cut-out
9 Liquid Line Solenoid Assemlbly Kit
9a 7630031 Solenoid Valve Including 115V Coil [3]
9b 7630091 Solenoid Valve Including 208-230V Coil [3]
10 Solenoid
10a 000005156 Solenoid Valve Coil Only - 115V/60 Hz [4]
10b 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [5]
11 Refrigerant Solenoid Valve
11a 8251373 Solenoid Valve Only - EVU4 [6]
11b 000006495 Solenoid Valve Only - EVU3 [7]
12 000000805 Valve Bracket
13 5202063 Screw - #10-24 x 0.5" HEX SS
14 000001329 Receiver Bracket
15 5573413 Washer
PART NOTES:
[1] - For SS Units
[2] - For TS & ERC Units
[3] - For Units Prior to Serial 110952651
[4] - \pages from 000005156_02.jpg" width=280 height=256>
[5] - \pages from 000005156_02.jpg" width=266 height=183>
[6] - For Units Prior to Serial 110952651 .500 in - .375 out
[7] - For Serial 110952651 and Up 3/8in x 3/8in
SC1000W & SC1000WX (WATER COOLED PARTS)
Model_SC1000_6.pdf
Model SC1000
SC1000R & SC1000RX (REMOTE COOLED PARTS)
SC1000R & SC1000RX (REMOTE COOLED PARTS)
Model_SC1000_7.pdf
Model SC1000
SC1000R & SC1000RX (REMOTE COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 7629573 Receiver
2 8360063 Coupling Mounting Flange for 1.17"-12
3 8360053 Coupling Mounting Flange for 0.625"-18
4 000002658 Water/Remote Coupling Panel
5 8373169 Receiver Service Valve
6 6020541 Receiver Strap
7 8373149 Magni-Check Valve - 0.375"
8 Compressor
8a 8251453 Compressor - 230V/60 HZ/1 Ph [1]
2002563 Start Relay - 230V/60 Hz/1 Ph
8503143 Start Capacitor - 115V/60 Hz/1 Ph
000001396 Run Capacitor 115V/60 Hz/1 Ph
8b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [2]
8c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [1]
2004333 Start Relay
2004343 Start Capacitor - 88-106MFD - 220V
00215798 Run Capacitor
00217389 Protector
8d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [2]
9 00209235 Head Pressure Valve
10 2001243 High pressure cut-out
11 Liquid Line Solenoid Assemlbly Kit
11a 7630031 Solenoid Valve Including 115V Coil [3]
11b 7630091 Solenoid Valve Including 208-230V Coil [3]
12 Solenoid Valve Coils
12a 000005156 Solenoid Valve Coil Only - 115V/60 Hz [4]
12b 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [5]
13 Refrigerant Solenoid Valve
13a 8251373 Solenoid Valve Only - EVU4 [6]
13b 000006495 Solenoid Valve Only - EVU3 [7]
14 000001460 Liquid Line Solenoid Wiring Harness [8]
15 000000805 Valve Bracket [3]
16 000001460 Liquid Line Solenoid Wiring Harness [8]
17 000000412 Receiver Bracket
18 6000561 Receiver Mounting Bracket
19 5202063 Screw - #10-24 x 0.5" HEX SS
PART NOTES:
[1] - For SS Units
[2] - For TS & ERC Units
[3] - For Units Prior to Serial 110952651
[4] - \pages from 000005156_02.jpg" width=280 height=256>
[5] - \pages from 000005156_02.jpg" width=266 height=183>
[6] - For Units Prior to Serial 110952651 .500 in - .375 out
[7] - For Serial 110952651 and Up 3/8in x 3/8in
[8] - NOT SHOWN
SC1000R & SC1000RX (REMOTE COOLED PARTS)
Model_SC1000_7.pdf
Model SC1000
SC1000R & SC1000RX (REMOTE CONDENSER TS0895-271)
SC1000R & SC1000RX (REMOTE CONDENSER TS0895-271)
Model_SC1000_8.pdf
Model SC1000
SC1000R & SC1000RX (REMOTE CONDENSER TS0895-271)
# PART # DESCRIPTION QTY Note
1 8850629 Air Condenser
2 7629413 Fan Motor - 208-230V/50-60 Hz/1 Ph
3 8504583 Fan Motor Run Capacitor
4 2416113 Fan Blade
5 3400643 Fan Guard
6 2415053 Rain Slinger
7 8360343 Coupling - Male - 0.625"-18
8 8360353 Coupling - Male - 1.17"-12
9 K00129 Female Line Set Coupling Kit [1]
10 8360053 Coupling Mounting Flange for 0.625"-18 [2]
11 8360063 Coupling Mounting Flange for 1.17"-12 [3]
12 6017751 Top Cover
13 6017741 Panel - Side
14 6017731 Panel - Rear
15 6017721 Panel - Front
16 6017681 Fan Motor Mounting Bracket
17 6017761 Electrical Box Cover
18 5035659 Fan Motor Mounting Screw [4]
18a 5573099 Mounting - Flatwasher
18b 5573139 Mounting - Lockwasher
18c 5429759 Mounting - Hexnut
19 5033459 Screw - 0.25"-20 x 0.625" [5]
19a 5573049 Flatwasher
19b 5545119 Mounting - Lockwasher
19c 5429529 Mounting - Hexnut
20 5121539 Panel/Condenser Mounting Screw - #8 x 0.50" [6]
20a 5544599 Panel/Condenser Mounting Lockwasher
21 5202069 Screw - #10-24 x 0.50" HEX [7]
22 7626843 Valve Cores [8]
23 6017691 Legs [9]
PART NOTES:
[1] - Sold as Finished Goods Sales Kit
[2] - for 5/8-18
[3] - for 1-1/16-12
[4] - 5/16-18 x 5/8
[5] - 1/4-20 x 5/8
[6] - #8 x 1/2
[7] - #10-24 x 1/2
[8] - used in linesets
[9] - Not shown
SC1000R & SC1000RX (REMOTE CONDENSER TS0895-271)
Model_SC1000_8.pdf
Loading...