Multiplex 450AX04 Parts List

Model 450

MODEL 450 BASE PARTS LIST-1

MODEL 450 BASE PARTS LIST-1
Model_450_2.pdf
Model 450
MODEL 450 BASE PARTS LIST-1
# PART # DESCRIPTION QTY Note
1 000001430 Air Filter 2 000002429 Top Insulated Panel - Beer 3 2002543 Carbonator Motor - 230V 1-3 HP 4 2005613 Pump - 70 GPH 5 4005653 Stopper - Glycol Tank 6 4010243 Boot- Pump Motor 7 4010253 Boot - Pump Motor 8 5002813 Start capacitor TECUMSEH 115 Volt 60 Hz 9 5003243 Adapter - 0.375" MPT x 0.5" OD Tube 10 6052071 Top Cover 11 5009036 CLAMP PUMP CARB 12 020001833 Motor Assembly Kit [1] a 00377102 Washer - Water Slinger b 00751208 Propeller [2] c 00856302 Washer d 00859119 Tab Clamp - SS e 00859503 Roll Pin - 0.09" x 0.6" SS f RM156120 Electrical Sleeve Tubing g 00213018 Agitator Motor - 230V/50-60 Hz 13 6052331 Heat Sink Tube Assy 14 020001718 Panel Front 15 020001715 Right Side Panel 16 000002431 Left - Insulated Panel 17 000001755 Switch Cover 18 000002433 Back - Insulated Panel 19 000002432 Front - Insulated 20 000002430 Right - Insulated Panel 21 000001696 Cover - 3.25" x 8.0" 22 000002013 Tube .500 OD (22.740") 23 000002014 Tube .500 OD Circ (39.478") 24 000002020 Tube .500 OD Circ (16.479") 25 000002021 Tube .500 OD Circ (15.408") 26 000002022 Tube .500 OD Circ (15.862")
PART NOTES:
[1] - Agitator w/Heat Sink Tube Domestic/International - 230 VAC, 50/60 Hz [2] - International
MODEL 450 BASE PARTS LIST-1
Model_450_2.pdf
Model 450

MODEL 450 BASE PARTS LIST-2

MODEL 450 BASE PARTS LIST-2
Model_450_3.pdf
Model 450
MODEL 450 BASE PARTS LIST-2
# PART # DESCRIPTION QTY Note
1 2002893 Toggle Switch - 16A - 0.75 HP 2 Contactor - 3 Pole 2a 2007879 Contactor - 120-230V/60 Hz/3 Ph 2b 2003173 Contactor - 220-400V/50 Hz/3 Ph 3 2002483 Time Delay Relay 4 2002523 Red Light - 250V 5 Thermal Expansion Valve 5a 000003932 TXV - Dual to Single Valve Conversion Kit 5b 000002976 TXV - Single Valve Replacement 6 000001462 Wire Harness - Pump Motor 7 020001985 Control Board 8 020002142 Water/Glycol Water Bath Temperature Sensor 9 020002143 Water Level Sensor 10 020001987 Ribbon Cable 11 000001452 Ground Terminal 12 020002091 Ice Bank Control 13 000003157 Bracket - Key Pad 14 020001986 Key Pad Display 15 2006619 Contactor - 230V/60 Hz/3 Ph 16 020002070 Wiring Harness - Pressure Switch 17 020001992 Pressure Switch 18 000001986 Barbed Fitting 19 020001991 Temperature Thermistor 20 5003143 Tee - 0.375" x 0.375" Barb x 0.25" MF SS 21 5002003 Nut - 0.25" Flare 22 Thermal Expansion Valve 22a 000003932 TXV - Dual to Single Valve Conversion Kit 22b 000002976 TXV - Single Valve Replacement 23 2004913 Temperature Control 24 2006619 Contactor - 230V/60 Hz/3 Ph 25 2004603 Terminal Block - 230V/50 Hz/1 Ph
MODEL 450 BASE PARTS LIST-2
Model_450_3.pdf
Model 450

450A & 450AX (AIR COOLED PARTS)

450A & 450AX (AIR COOLED PARTS)
Model_450_4.pdf
Model 450
450A & 450AX (AIR COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 000001193 Air Condenser [1] 2 000001324 Condenser Fan Shroud 3 000001425 Fan Blade 4 Fan Motor 4a 8251883 Fan Motor - 230V/60 Hz 4b 00753724 Fan Motor - 220V/50 Hz
Detail A 5 5650619 Screw Mounting Base 6 8930279 Drier 7 5650359 Drier Plastic Tie [2]
Detail B 8 2001243 High pressure cut-out 9 000008894 Receiver [3] 10 Compressor Kit 10a 020001765 Compressor - 230V/60 Hz/3 Ph 10b 00215922 Compressor - 380V / 2.2 HP - International 11 Thermal Expansion Valve 11a 000003932 TXV - Dual to Single Valve Conversion Kit 11b 000002976 TXV - Single Valve Replacement 12 3001793 Evaporator Coil [4] 13 6000541 Receiver Strap 14 8503063 Rubber Grommet 15 000001327 Fan Motor Bracket 16 8503943 Compressor Mounting - Sleeve [5]
PART NOTES:
[1] - 11x 22 [2] - Pkg of 2 [3] - 2-1/8 OD x 15, 3/8 [4] - 50MA-R 404A [5] - 3/8 ID x 1.031" Long
450A & 450AX (AIR COOLED PARTS)
Model_450_4.pdf
Model 450

450W & 450WX (WATER COOLED PARTS)

450W & 450WX (WATER COOLED PARTS)
Model_450_5.pdf
Model 450
450W & 450WX (WATER COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 000001363 Water/Remote Coupling Panel 2 2001243 High pressure cut-out 3 5650619 Screw Mounting Base 4 8372069 Water Regulating Valve 5 8253039 Water-cooled Condenser 6 8930279 Drier 7 8332033 Water Coupling [1] 8 000008894 Receiver [2] 9 3001793 Evaporator Coil [3] 10 Compressor Kit 10a 020001765 Compressor - 230V/60 Hz/3 Ph 10b 00215922 Compressor - 380V / 2.2 HP - International 11 Thermal Expansion Valve 11a 000003932 TXV - Dual to Single Valve Conversion Kit 11b 000002976 TXV - Single Valve Replacement 12 000001329 Receiver Bracket 13 5003883 Flare Nut - 0.50" 14 5650359 Drier Plastic Tie 15 6000541 Receiver Strap 16 8503069 Mounting - Rubber Grommet 17 8503949 Mounting - Sleeve [4]
PART NOTES:
[1] - 1/2 Flare x 3/8 MPT [2] - 2-1/8 OD x 15, 3/8 [3] - 50MA-R 404A [4] - 3/8 ID x 1.031" Long
450W & 450WX (WATER COOLED PARTS)
Model_450_5.pdf
Model 450

450R & 450RX (REMOTE COOLED PARTS)

450R & 450RX (REMOTE COOLED PARTS)
Model_450_6.pdf
Model 450
450R & 450RX (REMOTE COOLED PARTS)
# PART # DESCRIPTION QTY Note
1 7629573 Receiver [1] 2 6307214 Receiver Mounting Strap 3 3001793 Evaporator Coil [2] 4 5650619 Screw Mounting Base 5 8930279 Drier 6 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [3] 7 2001243 High pressure cut-out 8 00209235 Head Pressure Valve [4] 9 8373149 Magni-Check Valve - 0.375" 10 Compressor Kit 10a 020001765 Compressor - 230V/60 Hz/3 Ph 10b 00215922 Compressor - 380V / 2.2 HP - International 11 Thermal Expansion Valve 11a 000003932 TXV - Dual to Single Valve Conversion Kit 11b 000002976 TXV - Single Valve Replacement 12 8373169 Receiver Service Valve 13 Refrigerant Solenoid Valve 13a 8251373 Solenoid Valve Only - EVU4 [5] 13b 000006495 Solenoid Valve Only - EVU3 [6] 14 000000805 Valve Bracket [7] 15 Liquid Line Solenoid Assemlbly Kit [7] 15a 7630031 Solenoid Valve Including 115V Coil [7] 15b 7630091 Solenoid Valve Including 208-230V Coil 16 6000561 Receiver Mounting Bracket 17 5650359 Drier Plastic Tie [8] 18 8503949 Mounting - Sleeve [9] 19 8503069 Mounting - Rubber Grommet 20 000001460 Liquid Line Solenoid Wiring Harness [10]
PART NOTES:
[1] - 6.00" Dia x 16.00" Long [2] - 50MA-R 404A [3] - \pages from 000005156_02.jpg" width=266 height=183>
[4] - 180Psi 3/8 ODF [5] - .500 in - .375 out For Units Prior to Serial 110952651 [6] - 3/8in x 3/8in For Serial 110952651 and Up [7] - For Units Prior to Serial 110952651 [8] - Pkg Of 2 [9] - 3/8 ID x 1.031" Long [10] - NOT SHOWN
208-230V 50/60Hz
450R & 450RX (REMOTE COOLED PARTS)
Model_450_6.pdf
Model 450

450R & 450RX (REMOTE CONDENSER TS0895-271)

450R & 450RX (REMOTE CONDENSER TS0895-271)
Model_450_7.pdf
Model 450
450R & 450RX (REMOTE CONDENSER TS0895-271)
# PART # DESCRIPTION QTY Note
1 8850629 Air Condenser 2 7629413 Fan Motor - 208-230V/50-60 Hz/1 Ph [1] 3 Fan Motor Run Capacitor 3a 8504583 Fan Motor Run Capacitor 4 2416113 Fan Blade 5 3400643 Fan Guard 6 2415053 Rain Slinger 7 8360343 Coupling - Male - 0.625"-18 8 8360353 Coupling - Male - 1.17"-12 9 K00129 Female Line Set Coupling Kit [2] 10 8360053 Coupling Mounting Flange for 0.625"-18 [3] 11 8360063 Coupling Mounting Flange for 1.17"-12 [4] 12 6017751 Top Cover 13 6017741 Panel - Side 14 6017731 Panel - Rear 15 6017721 Panel - Front 16 6017681 Fan Motor Mounting Bracket 17 6017761 Electrical Box Cover 18 5035659 Fan Motor Mounting Screw [5] a 5573099 Mounting - Flatwasher b 5573139 Mounting - Lockwasher c 5429759 Mounting - Hexnut 19 5033459 Screw - 0.25"-20 x 0.625" [6] a 5573049 Flatwasher b 5545119 Mounting - Lockwasher c 5429529 Mounting - Hexnut 20 5121539 Panel/Condenser Mounting Screw - #8 x 0.50" [7] a 5544599 Panel/Condenser Mounting Lockwasher 21 5202069 Screw - #10-24 x 0.50" HEX [8] 22 7626843 Valve Cores [9] 23 6017691 Legs [10]
PART NOTES:
[1] - 208-230V 50/60 Hz/1 Ph [2] - Sold as Finished Goods Sales Kit [3] - for 5/8-18 [4] - for 1-1/16-12 [5] - 5/16-18 x 5/8 [6] - 1/4-20 x 5/8 [7] - #8 x 1/2 [8] - #10-24 x 1/2 [9] - used in linesets [10] - Not shown
450R & 450RX (REMOTE CONDENSER TS0895-271)
Model_450_7.pdf
Loading...