Multiplex 42M Parts List

Model 42M & Model 44M

Tubes, Filter & Carbonator

Tubes, Filter & Carbonator

Model_42-44_2.pdf

Model 42M & Model 44M

Tubes, Filter & Carbonator

# PART # DESCRIPTION QTY Note

1 000000979 Tube - 0.75" ID x 0.125" W x 72.0" L - Rubber [1]
2 000001755 Switch Cover
3 3002113 Coil Assy Plain Water 44M
4 3002063 Coil Assy Circ. Inlet/outlet [1]
5 3002153 Coil Syrup 3/8OD X 11.5ft SS 44
6 3002093 Coil Syrup 3/8 ODX15ft S/SMOD
7 3002123 Coil Assy Pre-cool Primary
8 3002103 Coil Assy Circulating Outlet
9 3002053 Coil Assy Pre-cool Second
10 2002743 Low Water Pressure Switch - 4 PSI
11 4040163 Air Filter
12 3001723 Stand Pipe - 24.25"
13 00216384 Adaptor - 0.25" MF x 0.125" MPT SS
14 6052031 Bracket - Drain Hose
15 5001673 Screw - #10-32 x 0.5"
16 5001063 Drain Fitting - 0.75" - Brass
17 00206387 Drain Nut - 0.75"
18 5001613 O-ring, Rubber - .750 OD X .625 ID

Detail A [2]
19 Y0212104 Electrode Assembly, 11.6" (29.4 cm) Carbonator, White [1]
20 Y0212105 Electrode Assembly, 8.9 Carbonator, Black
21 Y0212106 Electrode Assembly, 6.2 Carbonator, Red
22 8251513 Shut-off Valve - 0.25" x 0.25"
23 00701312 Single Check Valve
24 5001823 Tapered Washer - 0.25" Flare
25 5001903 Barb-stem Ell - 1/4x1/4 Swv S/S
26 5001873 Barb-stem Adpt 1/4barbx1/4sw [1]
27 3001743 Carbonator Tank - Assembly
28 00701334 Toggle Relief Valve - 150 psi

PART NOTES:

[1] - Model 44 only
[2] - Carbonator Tank

Tubes, Filter & Carbonator

Model_42-44_2.pdf

5

6

See Detail B

Detail C

See Detail C

See Detail D

Detail D

8

7

10

9

3

4

11

16

12

15

14

13

Detail B

1

2

Applies To:
SS904480-261
SS904481-261
SS904482-261
SS904496-251
SS904483-251
SS904497-251
SS904484-251
SS904498-251
SS904485-251
SS904450-251
SS904451-251
SS904452-251
TS904480E-261
TS904481E-261
TS904482E-261
TS904496E-251
TS904497E-251
TS904498E-251
TS904247E-261
TS904248E-261
TS904249E-261
TS904250E-251
TS904251E-251
TS904252E-251
TS904480G-261
TS904496G-251
HC904496G-251
TS904482G-261
TS904498G-251
HC904498G-251
TS904481G-261
TS904497G-251
HC904497G-251

Model 42M & Model 44M

Agitator, Manifold, Carb Pump & Motor

Agitator, Manifold, Carb Pump & Motor

Model_42-44_3.pdf

Model 42M & Model 44M

Agitator, Manifold, Carb Pump & Motor

# PART # DESCRIPTION QTY Note

Detail B [1]
1 00213237 TS Motor Assembly Kit Domestic/International - 230 VAC,

50/60 Hz
1a 00215727 Agitator Motor Bracket
1b 00377102 Washer - Water Slinger
1c 00751208 Propeller [3]
1d 00856302 Washer
1e 00859119 Tab Clamp - SS
1f 00859503 Roll Pin - 0.09" x 0.6" SS
1g RM156120 Electrical Sleeve Tubing
1h 00213018 Agitator Motor - 230V/50-60 Hz
12 6052321 Heat Sink Tube Assembly & Clamp

Detail C [4]
3 5001983 Adaptor - 0.5" Barb x 0.5"
4 5001963 Adapter - 0.25" Barb x 0.375" MPT
5 000001973 Manifold Water 3 Outlet
6 000002232 Manifold Water 3 Outlet [5]
7 5001023 Valve Ball - 0.375" FPT x 0.375" FPT Brass
8 5001343 Shut-off Valve - 0.375" OD x 0.25"
9 5001793 Washer Tapered Flare - 0.5" - Nylon
10 5002033 Nut - 0.5" Flare - Brass

Detail D [6]
11 Motor
11a 2002543 Carbonator Motor - 230V 1-3 HP
11b 020003095 Carbonator Motor with Pump - 115-230V/50-60 Hz
12 5001943 Elbow - 0.375" x 0.375" Barb
13 2002763 Pump - 100 GPH / 250 PSI - Brass
14 8332023 Coupling - 0.375" MF x 0.375" NPT Brass
15 5001833 Washer Tapered Flare - 0.375" - Nylon
16 2002753 Pump - 100 GPH - SS

PART NOTES:

[1] - Agitator Motor
[2] - Agitator w/Heat Sink Tube
[3] - International
[4] - Manifold
[5] - Model 44 only
[6] - Carbonator Motor & Pump

[2]

Agitator, Manifold, Carb Pump & Motor

Model_42-44_3.pdf

Model 42M & Model 44M

Base Parts List

Base Parts List

Model_42-44_4.pdf

Model 42M & Model 44M

Base Parts List

# PART # DESCRIPTION QTY Note

1 Thermal Expansion Valve
1a 8251483 Expansion Valve - Non-ERC Units
1b 000003206 Expansion Valve - ERC Units

Detail E [1]
2 Boot Front, Motor Pump
2a 4010243 Boot- Pump Motor
2b 020003214 Boot - Pump
3 Boot Rear, Motor Pump
3a 4010253 Boot - Pump Motor
3b 020003212 Boot - Pump
4 Pump
4a 2002753 Pump - 100 GPH - SS
4b 020003449 Pump w/Bypass - 100 GPH - SS [2]
5 5001803 Adaptor - 0.375" MF x 0.375" MPT - SS
6 Motor
6a 2002543 Carbonator Motor - 230V 1-3 HP
6b 020003095 Carbonator Motor with Pump - 115-230V/50-60 Hz [2]
6c 020003769 Carbonator Motor - 115-230V/50-60 Hz [2]
7 5001943 Elbow - 0.375" x 0.375" Barb
8 000008884 Screw - 0.25"-20 x 0.5" PHIL
9 000008883 Nut - 0.25"-20 ID ALUM
10 000006753 Clamp Pump Carb
11 Motor Shelf [3]
11a 000002652 Motor Mounting
11b 000008466 For Model 44G only
12 Harness Motor/Pump
12a 000001462 Wire Harness - Pump Motor
12b 020003207 Wire Harness - Pump Motor - 230V

Detail F [4]
13 2002893 Toggle Switch - 16A - 0.75 HP
14 2002523 Red Light - 250V

Detail G [5]
15 Liquid Level Control
15a 00219104 Liquid Level Control 120V
15b 00219105 Liquid Level Control 220V
16 2002483 Time Delay Relay
17 2002733 Electronic Sensor - Ice Bank Control
18 020001414 Electronic Sensor - Ice Bank Control - 230V

Detail G - ERC Controls Model 42 & Model 44 [6]
19 020002329 HPCO Wiring Harnesss
20 020001985 Control Board
21 020002142 Water/Glycol Water Bath Temperature Sensor
22 020002143 Water Level Sensor
23 020001987 Ribbon Cable
24 000001452 Ground Terminal
25 020002091 Ice Bank Control

Base Parts List

Model_42-44_4.pdf

Model 42M & Model 44M

Base Parts List

# PART # DESCRIPTION QTY Note

26 020001986 Key Pad Display
27 020002070 Wiring Harness - Pressure Switch
28 020001992 Pressure Switch
29 000001986 Barbed Fitting
30 020001991 Temperature Thermistor [7]
31 5003143 Tee - 0.375" x 0.375" Barb x 0.25" MF SS
32 000003157 Bracket - Key Pad
33 5002003 Nut - 0.25" Flare [7]

PART NOTES:

[1] - Circulator Motor & Pump
[2] - Model 44G only
[3] - Not Shown
[4] - Switches Non-ERC Model 44 only
[5] - Liquid Level & Ice Bank Controls Non-ERC Model 44 only
[6] - ERC Controls Model 42 & 44
[7] - Model 44 only

Base Parts List

Model_42-44_4.pdf

Model 42M & Model 44M

Panels

Panels

Model_42-44_5.pdf

Model 42M & Model 44M

Panels

# PART # DESCRIPTION QTY Note

1 6051791 Top Cover
2 000002649 Back Panel
3 000002652 Motor Mounting
4 000002657 Back Corner Panel
5 000002647 Bulkhead Panel
6 000002653 Control Box
7 000002650 Left Side Panel
8 000002648 Front Panel - Left
9 000002953 Front Panel - Right
10 000002654 Right Side Panel
11 000002651 Right Corner Panel
12 000002658 Water/Remote Coupling Panel [1]

PART NOTES:

[1] - not shown

Panels

Model_42-44_5.pdf

Model 42M & Model 44M

Air Cooled Parts

Air Cooled Parts

Model_42-44_6.pdf

Model 42M & Model 44M

Air Cooled Parts

# PART # DESCRIPTION QTY Note

1 000002656 Condenser Housing
2 2416203 Fan Blade
3 2412939 Fan Motor 208-230V/50-60 Hz
4 000002689 Condenser Coil
5 000008894 Receiver
6 6072461 Fan Motor Bracket
7 8930279 Drier
8 2001243 High pressure cut-out [1]
9 Liquid Line Solenoid
9a 7630091 Solenoid Valve Including 208-230V Coil [2]
10 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [3]
11 Refrigerant Solenoid Valve
11a 8251373 Solenoid Valve Only - EVU4 [4]
11b 000006495 Solenoid Valve Only - EVU3 [5]
12 000000805 Valve Bracket [2]
13 5202063 Screw - #10-24 x 0.5" HEX SS
14 000001329 Receiver Bracket
15 000001426 Manifold - 3 Port [6]
16 020001991 Temperature Thermistor 4
17 Compressors
17a 8251453 Compressor - 230V/60 HZ/1 Ph [7]

2002563 Start Relay - 230V/60 Hz/1 Ph
8503143 Start Capacitor - 115V/60 Hz/1 Ph
000001396 Run Capacitor 115V/60 Hz/1 Ph

17b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [8]

2007539 Start Potential Relay - 230V/50-60 Hz/1 Ph
8503853 Start Capacitor - 50-60 Hz/1 Ph
8503933 Run Capacitor - 115-230V/50-60 Hz/1 Ph

17c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [7]

2004333 Start Relay
2004343 Start Capacitor - 88-106MFD - 220V
00215798 Run Capacitor
00217389 Protector

17d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [8]

PART NOTES:

[1] - Model 44 Only
[2] - For Units Prior to Serial 110952651
[3] - \pages from 000005156_02.jpg" width=266 height=183>
[4] - 0.500 in / 0.375 out For Units Prior to Serial 110952651
[5] - 0.375 in x 0.375 in For Serial 110952651 and Up
[6] - not shown
[7] - For SS Units
[8] - For TS & ERC Units

Air Cooled Parts

Model_42-44_6.pdf

Model 42M & Model 44M

Water-cooled Components

Water-cooled Components

Model_42-44_7.pdf

Model 42M & Model 44M

Water-cooled Components

# PART # DESCRIPTION QTY Note

1 000008894 Receiver
2 8372069 Water Regulating Valve
3 6020541 Receiver Strap
4 000002658 Water/Remote Coupling Panel
5 8706083 Female Wing Adapter - 0.50"
6 000000046 Water-cooled Condenser
7 2001243 High pressure cut-out [1]
8 Liquid Line Solenoid
8a 7630091 Solenoid Valve Including 208-230V Coil [2]
9 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [3]
10 Refrigerant Solenoid Valve
10a 8251373 Solenoid Valve Only - EVU4 [4]
10b 000006495 Solenoid Valve Only - EVU3 [5]
11 000000805 Valve Bracket [2]
12 5202063 Screw - #10-24 x 0.5" HEX SS
13 000001329 Receiver Bracket
14 5573413 Washer
15 020001991 Temperature Thermistor
16 Compressor
16a 8251453 Compressor - 230V/60 HZ/1 Ph [6]

2002563 Start Relay - 230V/60 Hz/1 Ph
8503143 Start Capacitor - 115V/60 Hz/1 Ph

000001396 Run Capacitor 115V/60 Hz/1 Ph
16b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [7]
16c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [6]

2004333 Start Relay

2004343 Start Capacitor - 88-106MFD - 220V

00215798 Run Capacitor

00217389 Protector
16d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [7]

PART NOTES:

[1] - Model 44 Only
[2] - For Units Prior to Serial 110952651
[3] - \pages from 000005156_02.jpg" width=266 height=183>
[4] - .500 in - .375 outFor Units Prior to Serial 110952651
[5] - 3/8in x 3/8inFor Serial 110952651 and Up
[6] - For SS Units
[7] - For TS & ERC Units

Water-cooled Components

Model_42-44_7.pdf

Model 42M & Model 44M

Remote Cooled Parts

Remote Cooled Parts

Model_42-44_8.pdf

Model 42M & Model 44M

Remote Cooled Parts

# PART # DESCRIPTION QTY Note

1 7629573 Receiver
2 8360063 Coupling Mounting Flange for 1.17"-12
3 8360053 Coupling Mounting Flange for 0.625"-18
4 000002658 Water/Remote Coupling Panel
5 8373169 Receiver Service Valve
6 6020541 Receiver Strap
7 8373149 Magni-Check Valve - 0.375"
8 00209235 Head Pressure Valve
9 2001243 High pressure cut-out [1]
10 Liquid Line Solenoid
10a 7630091 Solenoid Valve Including 208-230V Coil [2]
11 000005157 Danfoss Solenoid Valve Coil Only - 230V/50-60 Hz [3]
12 Refrigerant Solenoid Valve
12a 8251373 Solenoid Valve Only - EVU4 [4]
12b 000006495 Solenoid Valve Only - EVU3 [5]
13 000001460 Liquid Line Solenoid Wiring Harness [6]
14 000000805 Valve Bracket [7]
15 000000412 Receiver Bracket
16 6000561 Receiver Mounting Bracket
17 5202063 Screw - #10-24 x 0.5" HEX SS
18 020001991 Temperature Thermistor
19 Compressor
19a 8251453 Compressor - 230V/60 HZ/1 Ph [8]

2002563 Start Relay - 230V/60 Hz/1 Ph

8503143 Start Capacitor - 115V/60 Hz/1 Ph

000001396 Run Capacitor 115V/60 Hz/1 Ph
19b 000008723 Compressor - Copeland - 208-230V/60 Hz/1 Ph [9]

2007539 Start Potential Relay - 230V/50-60 Hz/1 Ph

8503853 Start Capacitor - 50-60 Hz/1 Ph

8503933 Run Capacitor - 115-230V/50-60 Hz/1 Ph
19c 00219080 Compressor - Copeland - 208-230V/50 Hz/1 HP [8]

2004333 Start Relay

2004343 Start Capacitor - 88-106MFD - 220V

00215798 Run Capacitor

00217389 Protector
19d 000008725 Compressor - Copeland - 208-230V/50 Hz/1 Ph [9]

2007549 Start Potential Relay - 50 Hz/1 Ph

8505513 Start Capacitor - 50-60 Hz/1 Ph

8503933 Run Capacitor - 115-230V/50-60 Hz/1 Ph

PART NOTES:

[1] - Model 44 Only
[2] - For Units Prior to Serial 110952651
[3] - \pages from 000005156_02.jpg" width=266 height=183>
[4] - .500 in - .375 outFor Units Prior to Serial 110952651
[5] - 3/8in x 3/8inFor Serial 110952651 and Up
[6] - NOT SHOWN

Remote Cooled Parts

Model_42-44_8.pdf

Model 42M & Model 44M

Remote Cooled Parts

# PART # DESCRIPTION QTY Note

[7] - For Serial 110952651 and Previous
[8] - For SS Units
[9] - For TS & ERC Units

Remote Cooled Parts

Model_42-44_8.pdf

Model 42M & Model 44M

Remote Condenser TS0895

Remote Condenser TS0895

Model_42-44_9.pdf

Model 42M & Model 44M

Remote Condenser TS0895

# PART # DESCRIPTION QTY Note

1 8850629 Air Condenser
2 7629413 Fan Motor - 208-230V/50-60 Hz/1 Ph
3 8504583 Fan Motor Run Capacitor
4 2416113 Fan Blade
5 3400643 Fan Guard
6 2415053 Rain Slinger
7 8360343 Coupling - Male - 0.625"-18
8 8360353 Coupling - Male - 1.17"-12
9 K00129 Female Line Set Coupling Kit
10 8360053 Coupling Mounting Flange for 0.625"-18
11 8360063 Coupling Mounting Flange for 1.17"-12
12 6017751 Top Cover
13 6017741 Panel - Side
14 6017731 Panel - Rear
15 6017721 Panel - Front
16 6017681 Fan Motor Mounting Bracket
17 6017761 Electrical Box Cover
18 5035659 Fan Motor Mounting Screw [1]
18a 5573099 Mounting - Flatwasher
18b 5573139 Mounting - Lockwasher
18c 5429759 Mounting - Hexnut
19 5033459 Screw - 0.25"-20 x 0.625"
19a 5573049 Flatwasher
19b 5545119 Mounting - Lockwasher
19c 5429529 Mounting - Hexnut
20 5121539 Panel/Condenser Mounting Screw - #8 x 0.50"
20a 5544599 Panel/Condenser Mounting Lockwasher
21 5202069 Screw - #10-24 x 0.50" HEX
22 7626843 Valve Cores
23 6017691 Legs

PART NOTES:

[1] - 5/16-18 x 5/8

Remote Condenser TS0895

Model_42-44_9.pdf