Mr. Steam SAH3000B1, SAH3000C1, SAH4500B1, SAH4500C1, SAH6000B1 Installation Manual

Installation, Operation & Maintenance Manual

®

Steam@Home

RESIDENTIAL STEAM GENERATOR SYSTEMS

Models: SAH3000, SAH4500, SAH6000

mr.steam

®

Feel Good Inc.

READ ME FIRST!

IMPORTANT NOTE:

ill notice warning and caution symbols. This blocked infor-

w
mation is important for the safe and efficient installation,
operation and maintenance of this generator. These are
types of potential hazards that may occur during this instal­lation and operation:

As you follow these instructions, you

!

or death if precautions are not followed.

!

product damage may occur if you do not follow instructions.

IMPORTANT NOTE:

especially relevant to a problem-free installation.

IMPORTANT SAFETY INSTRUCTIONS

When installing and using this electrical equipment, basic safety
precautions should always be followed, including the following:

WARN I N G

CA U T I ON

states a hazard may cause serious injury

ignals a situation where minor injury or

s

This highlights information that is

1.

REA D AND FO L LOW ALL INSTRUCT IONS

2. To reduce the risk of injury, children

3. To reduce the risk of injury:

WAR N I N G

!

under the age of 16 should not use the steam bath.

WAR N I N G

!

A. The wet surfaces of steam enclosures may be

slippery. Use care when entering or leaving.

B. The steam head is hot. Do not touch the steam

head and avoid the steam near the steam head.

C. Prolonged use of the steam system can raise

excessively the internal human body temperature
and impair the body’s ability to regulate its internal
temperature (hyperthermia). Limit your use of
steam to 10-15 minutes until you are certain of

body’s reaction.

your

HYPE R THERMIA

The causes, symptoms, and effects of
hyperthermia may be described as follows:
Hyperthermia occurs when the internal
temperature of the body reaches a level
several degrees above the normal body
temperature of 98.6° F. The symptoms of
hyperthermia include an increase in the
internal temperature of the body, dizziness,
lethargy, drowsiness, and fainting.

The effects of hyperthermia include:

a) Failure to perceive heat
b) Failure to recognize the need to exit the

steambath
c) Unawareness of impending risk
d) Fetal damage in pregnant women
e) Physical inability to exit the steambath
f) Unconsciousness.

WA R N ING

!

or medication can greatly increase the risk
of hyperthermia.

The use of alcohol, drugs,

A peel-off warning label has been provided in
the Information envelope. This label is to be
applied to the wall of the installed shower or
steam enclosure in a conspicuous location.

REDUCE THE RISK OF OVERHEATING AND SCALDING

1.

EXIT IMMEDIATELY IF UNCOMFORTABLE, DIZZY OR SLEEPY.

STAYING TOO LONG IN A HEATED AREA IS CAPABLE OF CAUSING OVERHEATING.

2. CHILDREN UNDER THE AGE OF 16 SHOULD NOT USE THE STEAM BATH.

3. CHECK WITH A DOCTOR BEFORE USE IF PREGNANT, DIABETIC, IN POOR
HEALTH OR UNDER MEDICAL CARE.

4. BREATHING HEATED AIR IN CONJUNCTION WITH CONSUMPTION OF ALCOHOL,
DRUGS, OR MEDICATION IS CAPABLE OF CAUSING UNCONSCIOUSNESS.

5. DO NOT CONTACT STEAM HEAD OR STEAM AT THE STEAM HEAD.

REDUCE THE RISK OF SLIPPING AND FALL INJURY

1.

USE CARE WHEN ENTERING OR EXITING THE STEAM ROOM. FLOOR MAY BE SLIPPERY.

NOTE: FOR ADDITIONAL SAFETY CONSIDERATIONS SEE OWNER’S MANUAL

mr.steam

D. Excessive temperatures have a high potential for

causing fetal damage during the early months of
pregnancy. Pregnancy or possibly pregnant
women should consult a physician regarding
correct exposure.

E. Obese persons and persons with a history of

heart disease, low or high blood pressure, circu­latory system problems, or diabetes should con­sult a physician before using a steambath.

F. Persons using medication should consult a

physician before using a steambath since some
medication may induce drowsiness while other
medications may affect heart rate, blood pres­sure and circulation.

4.

SAVE THE SE INSTR U C TIONS

WARNING

!

®

43-20 34th Street , Long Island City NY 11101 1 800 76 STEAM www.mrsteam.com PUR100378 6.4/08

Steam@home®Residential Steambath Generator Systems

INSTALLATION, OPERATION & MAINTENANCE MANUAL

MODELS: SAH3000, SAH4500, SAH6000

MODEL ____________________ SERIAL NO.____________________

TABLE OF CONTENTS

_______________________________________________________________

Information for Installers & Homeowners

Read Me First! & Warning Sticker . . . . . . . . . . . . . . . . 1

Select Your Mr.Steam Model . . . . . . . . . . . . . . . . . . . . 2

Generator Specification Chart . . . . . . . . . . . . . . . . . . . 2

________________________________________________________________________________

INSTALLER’S SECTION

Before Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Steam Room Guidelines . . . . . . . . . . . . . . . . . . . . . . . 3

Water Quality Information . . . . . . . . . . . . . . . . . . . . . . 4

Locating the Steam Generator Unit . . . . . . . . . . . . . . . 4

Typical Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Generator Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Installation: Plumbing, Water Supply,

Steam Outlet, Safety Valve, Drip Pan . . . . . . . . . . . . 6

Steam Head Installation . . . . . . . . . . . . . . . . . . . . . . . 7

Electrical Specifications & Field Power Wiring . . . . . . . 8

Initial Start-Up & Checkout. . . . . . . . . . . . . . . . . . . . . 9

Troubleshooting / System Status Codes . . . . . . . . . . . . 9

Wiring Diagrams / Liquid Level Control Board . . . . . . . 10

Replacement Parts Diagram & Parts List . . . . . . . . . . 11

SteamStart

Dimensions & Installation Instructions. . . . . . . . . . . . . 12

™

________________________________________________________________________________

HOMEOWNER’S SECTION

SteamStart

Care Tips, Safety & Operating Information . . . . . . . . . . . 13

AromaSteam™Essential Oils . . . . . . . . . . . . . . . . . . . 13

mr.steam

43-20 34th Street, Long Island City, NY 11101
9410 S. La Cienega Blvd. Inglewood CA 90301

™

®

Sussman-Automatic Corporation

®

• [e-mail] • www.mrsteam.com

• TEL: 1 800 76 STEAM • FAX: [phone]

• TEL: 1 800 72 STEAM • FAX: [phone]

M A D E I N U S A

PUR 100467 Rev 5.14

mr.steam

®

Steam@Home

®

nstallation, Operation & Maintenance Manual

I

__________________________________________________________________________

CORRECT SIZING IS IMPORTANT

WARNING

!

important to effectively match the heating requirements of
the steam room to the steam bath generator. Do not use a
particular SAH model steam generator with a room whose
“total room volume” is less than the range shown in the
SAH model steam generator sizing chart below. Selection of
a model with a “total room volume” rating greater than the
“total room volume” may cause excessive temperature.
Do not use SAH model steam generators in a room with
a “total room volume” of less than 60 cubic feet.

Selection of the appropriate model is

WARNING

!

teambath system, please note that if you are pregnant,

s
have a coronary condition, are in poor health, are being
treated for any other medical condition, or are using
medication or drugs, Mr.Steam recommends that you
obtain the approval of a physician before use. For infor­mation about this product and safety issues, please call
us at 1.800.76.STEAM or log onto www.mrsteam.com
for a copy of the Installation, Operation & Maintenance
Manual.

In considering a purchase of this

SELECT YOUR STEAM@HOME

Materials of construction and room size affect the steam
generator model selection.

To determine the “total room volume” multiply
length x width x height of the steam room.

STEAM@HOME GENERATOR SIZING CHART

Total Room Volume* Acrylic/Fiberglass Ceramic Tile**
60 – 75 cu. ft. SAH3000 SAH3000
76 – 110 cu. ft. SAH3000 SAH4500
111 – 150 cu. ft. SAH3000 SAH6000

* For rooms with “total room volumes” greater than 150 cu. ft.

refer to Mr.Steam MS series of residential steam bath generators

** For all other room materials refer to Mr. Steam MS series

of residential steam bath generators

Steam@home Generator Specification Chart

†

Model No. KW

SAH3000 3.0 13 12

SAH4500 4.5 19 10

SAH6000 6.0 25 8

Amps

(for 240v/1PH)

IMPORTANT NOTE:

should not be used for rooms constructed of natural
stone, glass block and/or glass tile and/or for rooms hav­ing a ceiling height in excess of 8 feet.

IMPORTANT NOTE:

allows for a maximum of 60 feet of insulated steam line
from the SAH generator to the steam room. If the 60
foot line is exceeded refer to Mr.Steam MS series of
residential steam bah generators. When locating the
steam generator consideration of control location must
be taken into account. The maximum length for a
control cable is 60 feet. A 30 foot cable is standard.
Contact Mr.Steam to purchase the optional 60 ft. cable
(PN 103978-60)

CAUT ION

!

fiberglass enclosures for recommended steamhead
location. Use supplied Acrylic Shield PN MS-103938.
See instructions on page 7.

Wire Water Usage Shipping
Size‡Gallons

3

⁄

8

1

⁄

2

3

⁄

4

Consult with supplier of acrylic and

††

Dimensions* Weight

143⁄8"L x 147⁄8"H x 53⁄16"D 25

143⁄8"L x 147⁄8"H x 53⁄16"D 25

143⁄8"L x 147⁄8"H x 53⁄16"D 25

SAH Model steam generators

The “total room volume”

(lbs)

IMPORTANT NOTES:

• Add C1 suffix to Model No. for 240V/1Ph;

• Add B1 suffix to Model No. for 208V/1Ph

• All Mr.Steam SAH Models are cULus Listed and CE approved.

NOTES:

† Amps are for 240v/1PH rated units.
‡ Wire size (AWG) based on minimum 90˚C rated THHN copper conductors.
Refer to the National Electrical Code for other types of conductors.
See page 5 for complete dimensional information.

All SAH Generators available in 240v/1PH and 208v/1PH. SAH units are not available in 3 phase. Specify voltage with order.

*Dimensions are for generator only, without plumbing features.
†† Approximate water usage based on 20 minutes of operation.

2

mr.steam

®

Steam@Home

®

nstallation, Operation & Maintenance Manual

I

________________________________________________________________________

BEFORE INSTALLING

Carefully inspect the Steam Generator and packaging
for shipping damage. Please contact the carrier in
the event of shipping damage, please contact the
carrier for claim information. Our customer service
department can assist you with any missing or dam­aged parts.

WARN I N G

!

doing so may result in an inoperative or hazardous
installation.

IMPORTANT NOTES:

• This document contains important safety, opera­tion and maintenance information. Leave this
document with the homeowner. Do not discard
this document.

IMPORTANT NOTE:

The following general information should be used in
conjunction with consultations with an architect,
designer and contractor in determining factors nec­essary in providing a suitable and safe steam room.

Never use damaged equipment,

Read these instructions before installation or service.

Although this SAH steambath generator has been fully qualified
for shipment by Mr.Steam
proper, safe and enjoyable steam bathing:

• Verify that the model and accessories are correct, including
incoming line voltage.

• Insure steambath generator has been correctly sized for the
steambath room. Pay particular attention to room volume and
construction. If any questions, please refer to Mr. Steam sizing
and selection guide on page 2.

• The physical size of the unit, clearance for plumbing servicing,
and its distance from the steam room must all be considered
before installation.

IMPORTANT NOTE:

ated with a Mr.Steam SteamStart™ control only, and are to be
installed strictly in accordance with the specific instructions con­tained in this manual.

WARN I N G

!

generators are intended to be connected to 208V or 240V line
voltage and contain live electrical components. All installation
and service to be performed by qualified and licensed electricians
and plumbers only. Installation or service by unqualified persons
or failure to use Mr. Steam parts may void the warranty.

ELECTRICAL SHOCK HAZARD. Mr.Steam steam

®

, the following must be reviewed for

Mr.Steam SAH units are intended to be oper-

INSTALLER

STEAM ROOM GUIDELINES

IMPORTANT NOTES:

1. Steam room must be completely enclosed, with full
walls, door, floor and ceiling.

2. It is recommended that a gasketed door is used for heat
sealing and steam containment.

3. If smooth surfaced flooring is used, provide suitable
anti-skid strips or equivalent to prevent user slipping
and injury.

4. Walls and ceilings must be constructed of water-resist­ant, non-corrosive surface, such as tile, molded acrylic,
or fiberglass. The ceiling should be sloped to prevent
dripping of condensate.

CA U T I ON

!

of the steam room enclosure. Consult with the material
manufacture and see pg. 7 for additional details.

5. Provide a floor drain.

6. No heating, venting or air conditioning devices should

be installed inside the steam room.

7. Steam room tile construction information is available

from the Tile Council of America, Inc. by purchasing the
TCA Handbook for Ceramic Tile Installation. Tel: (864)
646-8453 or www.tileusa.com.

If acrylic or fiberglass are used as part

8. Windows that are part of the steam room should be
double paned and tempered safety glass.

9. Limit steam room ceiling height to 8 feet.

10. A peel-off warning label has been provided in the
Information envelope (see Warning facsimile below).
This label is to be applied to the wall of the installed
shower or steam enclosure.

WARN I N G

!

for residential use only. Commercial or other nonresidential
applications void the warranty and may adversely affect
product performance.

The SAH series of steam generators are

WARNING

!

REDUCE THE RISK OF OVERHEATING AND SCALDING

1.

EXIT IMMEDIATELY IF UNCOMFORTABLE, DIZZY OR SLEEPY.

STAYING TOO LONG IN A HEATED AREA IS CAPABLE OF CAUSING OVERHEATING.

2. CHILDREN UNDER THE AGE OF 16 SHOULD NOT USE THE STEAM BATH.

3. CHECK WITH A DOCTOR BEFORE USE IF PREGNANT, DIABETIC, IN POOR
HEALTH OR UNDER MEDICAL CARE.

4. BREATHING HEATED AIR IN CONJUNCTION WITH CONSUMPTION OF ALCOHOL,
DRUGS, OR MEDICATION IS CAPABLE OF CAUSING UNCONSCIOUSNESS.

5. DO NOT CONTACT STEAM HEAD OR STEAM AT THE STEAM HEAD.

REDUCE THE RISK OF SLIPPING AND FALL INJURY

1.

USE CARE WHEN ENTERING OR EXITING THE STEAM ROOM. FLOOR MAY BE SLIPPERY.

NOTE: FOR ADDITIONAL SAFETY CONSIDERATIONS SEE OWNER’S MANUAL

mr.steam

®

43-20 34th Street , Long Island City NY11101 1 800 76 STEAM www.mrsteam.com PUR100378 6.4/08

Not Actual Size

3