Monogram ZSAB1 Installation

Installation Instructions

Sabbath Mode Product Kit ZSAB1

For Use With Monogram Built-In Refrigerators:

36", 42" & 48"

Side-by-Side “R” Models (Manufactured On or After February 2004) and “X” Models

36" Bottom-Freezer “R” Models

(Manufactured On or After April 2004) and “X” Models

36"

All-Refrigerator/ All-Freezer “X” Models

Safety Instructions

• Completion Time – 30 Minutes to 1 Hour.

New installations require more time than replacement installations.

READ CAREFULLY. KEEP THESE INSTRUCTIONS.

FOR YOUR SAFETY

Read and observe all CAUTION and WARNINGS shown throughout these instructions.

While performing installations described in this booklet, gloves, safety glasses or goggles should be worn.

For Monogram local service in your area,

1.800.444.1845. For Monogram service in Canada, 1.800.561.3344. For Monogram Parts and Accessories, call

1.800.626.2002.

WARNING –

FOR PERSONAL SAFETY: Remove

house fuse or open circuit breaker before beginning installation.

ATTENTION –

SÉCURITÉ : Enlever le fusible du

circuit ou déclencher le disjoncteur avant de commencer l’installation.

Read these instructions completely and carefully.

•

IMPORTANT – Save these instructions

for local inspector’s use. Observe all governing codes and ordinances.

• Note to GE Factory Service Technician or GE

Customer Care Service Technician – Be sure

to leave these instructions with the Consumer.

• Note to Consumer – Keep these instructions

with your Owner’s Manual for future reference.

• Skill Level – The Sabbath Mode Product Kit must

only be installed by a qualified GE Factory Service Technician or GE Customer Care Appliance Service Technician. Product failure due to installation by anyone else is not covered under the GE Appliance Warranty.

CONTENTS

Introduction

About the Sabbath Mode ....................................................3

Using the Sabbath Switch ..................................................4

Parts Included ..........................................................................4

Tools and Materials Needed ..............................................4

Installation Instructions Side-by-Side Refrigerators – R Models

Mount Switchbox ....................................................................5

Making Electrical Connections ....................................6, 7

Operation Checklist ................................................................7

Installation Instructions Side-by-Side Refrigerators – X Models

Mount Switchbox ....................................................................8

Making Electrical Connections ..................................9, 10

Operation Checklist ............................................................10

Installation Instructions Bottom-Freezer Refrigerators – R Models

Mount Switchbox..................................................................11

Making Electrical Connections ..............................11–13

Operation Checklist ............................................................13

Installation Instructions Bottom-Freezer Refrigerators – X Models

Mount Switchbox..................................................................14

Making Electrical Connections................................15, 16

Operation Checklist ............................................................16

Installation Instructions All-Refrigerator and All-Freezer – X Models

Remove Grilles........................................................................17

Install Switchbox to Bracket............................................18

Making Electrical Connections................................18, 19

Install Switchbox and Bracket........................................20

Operation Checklist ............................................................20

Consumer Information

Frequently Asked Questions............................................21

Warranty ..................................................................................24

This feature was designed for use on the Jewish Sabbath and Holidays. The Sabbath Mode feature makes it possible for observant Jews to refrigerate and freeze food during the duration of the holiday. When set, the Sabbath Mode feature will override typical reactions to actions in your refrigerator.

While in Sabbath Mode your refrigerator will still operate normally, but the refrigerator will not respond to your actions. The fan may or may not be running when the door is opened; however, this is not a result of your actions. The fan will operate at random times.

Introduction

Icemaker

Feeler Arm

Power Switch

Green Power Light

Icemaker

Feeler Arm

Power Switch

ABOUT THE SABBATH MODE

Defrost Heater

• The defrost heater will continue to defrost the refrigerator and freezer.

• The defrost heater will be activated on a fixed timer during Sabbath Mode. Defrost heater will not defrost as a result of door openings or any action by the consumer.

Displays and Alarms

• The main temperature control and Quick Chill or Express Chill displays will not be lit. The touch pad sensors will not sound a tone or operate to change the set temperature when in Sabbath Mode.

• The temperature and Quick Chill settings will remain at the previously set temperatures during and after Sabbath Mode.

• Door alarms will not operate while in Sabbath Mode.

Ice and Water Dispenser

• The proximity sensor and dispenser touch sensor icons on the ice and water dispenser will not operate.

• Ice and water cannot be retrieved from the dispenser while the refrigerator is in Sabbath Mode.

Lights

• Interior lights and dispenser light will not operate.

Icemaker

• The icemaker is automatically disabled in Bottom-Freezer models.

• The icemaker will continue to operate in Side-by-Side and All-Freezer models, but should be disabled by opening the ice bin door and by setting the icemaker power switch to O (off) or OFF.

• To obtain ice, open the freezer door and remove the cubed ice from the ice bin.

TOOLS AND MATERIALS NEEDED

PARTS INCLUDED

Introduction

USING THE SABBATH SWITCH

• To activate the Sabbath Mode feature, raise the top grille panel and set the Sabbath Mode switch to the ON position.

• When the refrigerator is in Sabbath mode, a green LED light will be visible.

On Side-by-Side Refrigerators, the green light will be visible between the top grille panel and the refrigerator door.

On Bottom-Freezer Refrigerators, the green light may not be visible with the top grille panel closed. If you are not sure if the unit is in Sabbath Mode, raise the grille panel to see if the green light is on.

Sabbath

Switchbox

4 Wire Ties

On/Off LED

2 Self-Piercing

Screws

Stepladder

or Stool

Phillips Head

Screwdriver

Sabbath Mode Product Kit Technical Data Sheet (Place with refrigerator’s Technical Data Sheet for future use)

TECHNICAL

DATA

MOUNT SWITCHBOX

• FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation.

• Open the grille panel.

• Place a sheet or towel over the top of the fresh food and freezer doors to prevent accidentally scratching the door panels.

• Place the switchbox against the evaporator housing to the left of the main control board cover (on 36" and 42" models) or to the right of the main control board cover (on 48" models). Make sure the green LED light on the side of the switchbox is pointing DOWN.

• Mount the switchbox to the evaporator housing using the two self-tapping screws included with the kit.

IMPORTANT: DO NOT DRILL HOLES IN THE EVAPORATOR HOUSING. USE THE SELF-TAPPING SCREWS SUPPLIED WITH THE KIT.

If desired, the top of the switchbox can be mounted using a screw from one of the plastic wire straps at the top of the evaporator housing.

Installation Instructions

36" & 42" Models

48" Model Shown

48" Models

INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “R” Models Only

If your Side-by-Side refrigerator is an “X” model, go to page 8.

Sabbath Switchbox Mounting Location

Screws

AC Connector Wire

DC Connector Wire

Green LED Light

MAKING ELECTRICAL CONNECTIONS

• Locate the Refrigerator’s AC Input and Output connectors to the upper right of the evaporator housing.

• Disconnect the refrigerator’s AC Input and Output connectors from each other.

NOTE: If possible, try to avoid exposing the wires attached to the refrigerator’s AC connectors.

• Connect the switchbox AC Input connector to the refrigerator’s AC Input connector.

• Connect the switchbox AC Output connector to the refrigerator’s AC Output connector.

• Locate the refrigerator’s DC Input and Output connectors to the lower right of the evaporator housing.

• Disconnect the refrigerator’s DC Input and Output connectors from each other.

Installation Instructions

48" Model Shown

INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “R” Models Only (cont.)

Kit AC Connectors

Connector

Refrigerator AC Connectors

Kit AC Output Connector (3 prongs)

Kit AC Input Connector (3 holes)

OPERATION CHECKLIST With the Sabbath Switch set to OFF:

With the Sabbath Switch set to ON:

MAKING ELECTRICAL CONNECTIONS (cont.)

• Connect the switchbox DC Input connector to the refrigerator’s DC Input connector.

• Connect the switchbox DC Output connector to the refrigerator’s DC Output connector.

• Route the switchbox wires through the wire straps already attached to the evaporator housing. Arrange the connectors as far back in the refrigerator as possible. If necessary, use the wire ties included with the kit to dress the wires.

• Cover any exposed wiring on the refrigerator connectors with UL approved electrical tape.

WARNING: No wires are to be exposed.

• Write the installation date on the ZSAB1 switchbox.

• Place the Sabbath Mode Product Kit Technical Data Sheet with the refrigerator’s Technical Data Sheet for future use.

• Close grille panel.

• Replace house fuses or reset circuit breaker.

Installation Instructions

48" Models

36" & 42" Models

48" Model Shown

Wire Strap

 Make sure the green LED light is on.  Open the fresh food and freezer doors to make sure

the lights do not come on and the temperature and Climate Control Drawer displays do not come on.

 Press the temperature and Climate Control Drawer

controls to make sure they do not light up or beep.

 Try to dispense water or ice from the dispenser.

Ice or water should not dispense.

 Press the dispenser controls to make sure they

do not light up.

 Listen to make sure the compressor is running.  Confirm that the kit wires are properly routed

and that no AC wires are exposed at the unit connector side. Use UL approved electrical tape to cover wires completely.

 Confirm that the Sabbath Mode Product Kit Technical

Data Sheet has been placed with the refrigerator’s Technical Data Sheet for future use.

 Confirm that the installation date has been written

on the ZSAB1 switchbox.

 Leave the Installation Instructions with the consumer

for future use.

 Make sure the green LED light is off.  Make sure the dispenser is operating normally.  Listen to make sure the compressor is running.

 Open the fresh food and freezer doors and confirm

that the interior lights, the temperature display and the Climate Control Drawer all operate normally. If the interior lights do not come on, the Master Light Switch may have been accidentally set to the OFF position. Make sure the Master Light Switch is in the ON position.

Refrigerator DC Connectors

Kit DC Connectors

Kit DC Output Connector (2 prongs)

Kit DC Input Connector (2 holes)

MOUNT SWITCHBOX

• FOR PERSONAL SAFETY: Unplug the refrigerator,

remove house fuse or open circuit breaker before beginning installation.

• Open the grille panel.

• Place a sheet or towel over the top of the fresh food and freezer doors to prevent accidentally scratching the door panels.

• Remove the water filter.

• Remove the 2 screws that secure the water filter bracket. Remove the bracket to expose the wiring harnesses.

Installation Instructions

INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “X” Models Only

If your Side-by-Side refrigerator is an “R” model, go to page 5.

Sabbath Switchbox Mounting Location

+ 16 hidden pages