Modern Flames AL1500CLX, AL1000CLX, AL2000CLX, AL2500CLX, AL3600CLX Service Manual
...
Ambiance CLX Electric Series
AL1000CLX • AL1500CLX • AL2000CLX
AL2500CLX • AL3600CLX
INSTALLATION/SERVICE INSTRUCTIONS
FOR USE IN UNITED STATES AND CANDA
2
USER INSTRUCTIONS
Read these instructions completely before beginning installation. Failure to follow them
could cause a heater malfunction resulting in serious injury and/or property damage.
WARNING: All electric heaters have hot and arcing or sparking parts inside. Do not use it
in areas where gasoline, paint or flammable liquids are or are stored.
This fireplace meets the construction and safety standards of H.U.D. for application in
manufactured homes when installed according to these instructions.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
3
TABLE OF CONTENTS
Important Instructions .................................. 3
Product Dimensions .................................... 5
Box Contents ............................................... 5
Listing Approvals ......................................... 6
Unpacking and Testing ................................ 6
Locating Fireplace ....................................... 7
Installation .................................................... 7
When using electrical heaters, basic precautions should always be followed to reduce the
risk of fire, electric shock and injury to
persons, including the following:
1. Read all instructions before using this
heater.
2. Keep combustible materials, such as
furniture, pillows, bedding, papers, clothes
and curtains away from front of heater. 1.5
meters minimum clearance required.
3. This heater is hot when in use. To avoid
burns, do not let bare skin touch hot
surfaces. The grill directly in front of heater
outlet becomes hot during heater
operation.
4. Extreme caution is necessary when any
heater is used and whenever heater is left
operating and unattended.
5. Always unplug heater when not in use.
6. Do not operate any heater with a damaged
cord or plug or if heater malfunctions or
has been dropped or damaged in any way.
Return heater to authorized service facility
for examination, electrical or mechanical
adjustment or repair.
7. Do not use outdoors.
8. This heater is not intended for use in
bathrooms, laundry areas and similar
indoor locations. Never locate heater
where it may fall into a bathtub or other
water container.
9. Do not run cord under carpeting. Do not
cover cord with throw rugs, runners or the
like. Arrange cord away from traffic area
and where it will not be tripped over.
10.To disconnect heater, turn controls to the
OFF before removing plug from outlet.
11.Do not insert or allow foreign objects to
enter any ventilation or exhaust opening as
this may cause an electric shock or fire or
damage the heater.
WARNING: Improper installation, adjustment, alteration, service or maintenance
can cause injury or property damage. Refer
to this manual. For assistance or additional
information, consult a qualified installer.
CAUTION: Do not expose the heater to the
elements (such as rain, etc).
Do not place clothing or other flammable
material on or near firebox. Never place
any objects on the fireplace.
Carefully supervise young children when
they are in the room with fireplace.
Fireplace becomes very hot when running.
Keep children and adults away from hot
surfaces to avoid burns or clothing ignition. Fireplace will remain hot for a time after shutdown. Allow surfaces to cool before touching.
Do not install fireplace directly on carpet or
similar surface which may restrict air circulation beneath unit.
Operation ................................................... 10
Service Parts .............................................. 11
Frequently Asked Questions ...................... 12
Troubleshooting ......................................... 13
Cleaning and Maintenance Instructions ..... 14
Wiring Diagram .......................................... 15
IMPORTANT INSTRUCTIONS
CAUTION: In order to avoid overheating, do not cover the heater.
USER INSTRUCTIONS
WARNING: This heater is not equipped
with a device to control the room temperature. Do not use this heater in small rooms
when they are occupied by persons not capable of leaving the room on their own,
unless constant supervision is provided.
CAUTION: Some parts of this product can
become very hot and cause burns. Particular attention has to be given where children
and vulnerable people are present.
4
USER INSTRUCTIONS USER INSTRUCTIONS
12.To prevent possible fire, do not block air
inlets or outlets in any manner. Do not use
on soft surfaces, like a bed, where
openings may become blocked.
13.Always use properly grounded fused and
polarized outlets.
14.A heater has hot and arcing or sparking
parts inside. Do not use it in areas where
gasoline, paint or flammable liquids or
vapors are used or stored.
15.Use this heater only as described in this
manual. Any other use not recommended
by the manufacturer may cause fire, electric shock or injury to persons.
16.Avoid the use of an extension cord because the extension cord may overheat
and cause a risk of fire. However, if you
have to use an extension cord, the cord
should be No. 14 AWG minimum size and
rated not less than 1875 WATTS.
17.Always use ground fault protection where
required by electrical codes.
18.Always disconnect power before performing any cleaning, maintenance or relocation of heater.
19.To prevent a possible fire, do not burn
wood or other materials in this heater.
20.To prevent electric shock or fire, always
use a certified electrician should new
circuits or outlets be required.
21.When transporting or storing heater, keep
in a dry place.
22.Control panel door gets hot during heater
operation. Open door by pressing on right
corner. A spring magnet will disengage.
Pull door down to open.
23.Do not let children play with the appliance
unsupervised.
24.Heater must not be located immediately
below a socket outlet.
25.The appliance is not to be used by children
or persons with reduced physical, sensory
or mental capabilities, or lack of experience
and knowledge, unless they have been
given supervision and instruction.
26.If the supply cord is damaged, it must be
replaced by the manufacturer, its service
agent or similarly qualified persons in order
to avoid a hazard.
27.The heater must not be located
immediately below a socket outlet.
28.Children of less than 3 years should be
kept away unless continuously supervised.
Children aged from 3 years and less than 8
years shall only switch on/off the appliance
provided that it has been placed or
installed in its intended normal operating
position and they have been given
supervision or instruction concerning use
of the appliance in a safe way and
understand the hazards involved. Children
aged from 3 years and less than 8 years
shall not plug in, regulate and clean the
appliance or perform user maintenance.
29.This appliance can be used by children
aged from 8 years and above and persons
with reduced physical, sensory or mental
capabilities or lack of experience and
knowledge if they have been given
supervision or instruction concerning use
of the appliance in a safe way and
understand the hazards involved. Children
shall not play with the appliance. Cleaning
and user maintenance shall not be made
by children without supervision.
30.SAVE THESE INSTRUCTIONS
IMPORTANT INSTRUCTIONS
5
BOX CONTENTS
1 Fire Unit
1 Glass Face
3 L-metal Brackets
4 Wall Anchors
4 Small Washer Head
Screws
4 Large Washer Head
Screws
1 Remote
1 Mounting Bracket
USER INSTRUCTIONS
PRODUCT DIMENSIONS
Model Viewing Area Face Dimensions Firebox Dimensions
AL1000CLX 559mm W x 254mm H 1016mm W x 648mm H 616mm W x 489mm H x 140mm D
AL1500CLX 1067mm W x 254mm H 1524mm W x 648mm H 1124mm W x 489mm H x 140mm D
AL2000CLX 1575mm W x 254mm H 2032mm W x 648mm H 1632mm W x 489mm H x 140mm D
AL2500CLX 2083mm W x 254mm H 2540mm W x 648mm H 2140mm W x 489mm H x 140mm D
AL3600CLX 3200mm W x 254mm H 3658mm W x 648mm H 3258mm W x 489mm H x 140mm D
Width varies (see chart below)
489mm
(all models)
140mm
(all models)
Loading...