Page 1
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
Material name
:
A00734 MST BRK&PARTS CLNR II 20net14
Material number
:
000000000001003210
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
Aerosol containing a compressed gas
Colour
clear
Odour
aliphatic, solvent-like
Flammable aerosols
:
Category 1
Gases under pressure
:
Compressed gas
Skin irritation
:
Category 2
Specific target organ toxicity single exposure
:
Category 3 (Central nervous system)
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H222 Extremely flammable aerosol.
H280 Contains gas under pressure; may explode if heated.
H315 Causes skin irritation.
H336 May cause drowsiness or dizziness.
Precautionary statements
:
Prevention:
P210 Keep away from heat/sparks/open flames/hot surfaces.
No smoking.
P211 Do not spray on an open flame or other ignition source.
P251 Pressurized container: Do not pierce or burn, even after
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 11
Page 2
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
use.
P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.
P264 Wash skin thoroughly after handling.
P271 Use only outdoors or in a well-ventilated area.
P280 Wear protective gloves.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water.
P304 + P340 + P312 IF INHALED: Remove victim to fresh air
and keep at rest in a position comfortable for breathing. Call a
POISON CENTER or doctor/ physician if you feel unwell.
P332 + P313 If skin irritation occurs: Get medical advice/
attention.
P362 Take off contaminated clothing and wash before reuse.
Storage:
P403 + P233 Store in a well-ventilated place. Keep container
tightly closed.
P405 Store locked up.
P410 + P412 Protect from sunlight. Do not expose to
temperatures exceeding 50 °C/ 122 °F.
Disposal:
Dispose of contents/container in accordance with local
regulation.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Substance / Mixture
:
Mixture
Chemical Name
CAS-No.
Concentration [%]
Naphtha (petroleum), hydrotreated light
64742-49-0
>= 70 - < 90
ethanol
64-17-5
>= 5 - < 10
carbon dioxide
124-38-9
>= 5 - < 10
heptane
142-82-5
>= 1 - < 5
General advice
:
Show this safety data sheet to the doctor in attendance.
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
SECTION 4. FIRST AID MEASURES
2 / 11
Page 3
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
If inhaled
:
Remove to fresh air.
Call a physician or poison control centre immediately.
In case of skin contact
:
If skin irritation persists, call a physician.
Wash off immediately with plenty of water for at least 15
minutes.
In case of eye contact
:
Flush eyes with water at least 15 minutes. Get medical
attention if eye irritation develops or persists.
If swallowed
:
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Drink 1 or 2 glasses of water.
Obtain medical attention.
Suitable extinguishing media
:
Foam
Carbon dioxide (CO2)
Dry chemical
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
For safety reasons in case of fire, cans should be stored
separately in closed containments.
Use a water spray to cool fully closed containers.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Remove all sources of ignition.
Evacuate personnel to safe areas.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Wipe up with absorbent material (e.g. cloth, fleece).
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
3 / 11
Page 4
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
Advice on safe handling
:
Do not breathe vapours/dust.
Do not puncture.
Avoid contact with skin and eyes.
Smoking, eating and drinking should be prohibited in the
application area.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
No smoking.
Keep container tightly closed in a dry and well-ventilated
place.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Do not store together with oxidizing and self-igniting products.
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
ethanol
64-17-5
TWA
1,000 ppm
ACGIH
TWA
1,000 ppm
1,900 mg/m3
NIOSH REL
TWA
1,000 ppm
1,900 mg/m3
OSHA Z-1
TWA
1,000 ppm
1,900 mg/m3
OSHA P0
carbon dioxide
124-38-9
TWA
5,000 ppm
ACGIH
STEL
30,000 ppm
ACGIH
TWA
5,000 ppm
9,000 mg/m3
NIOSH REL
ST
30,000 ppm
54,000 mg/m3
NIOSH REL
TWA
5,000 ppm
9,000 mg/m3
OSHA Z-1
TWA
10,000 ppm
18,000 mg/m3
OSHA P0
STEL
30,000 ppm
54,000 mg/m3
OSHA P0
heptane
142-82-5
TWA
85 ppm
350 mg/m3
NIOSH REL
C
440 ppm
NIOSH REL
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 11
Page 5
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
1,800 mg/m3
TWA
500 ppm
2,000 mg/m3
OSHA Z-1
TWA
400 ppm
1,600 mg/m3
OSHA P0
STEL
500 ppm
2,000 mg/m3
OSHA P0
Respiratory protection
:
In the case of vapour formation use a respirator with an
approved filter.
In the case of dust or aerosol formation use respirator with an
approved filter.
Material
:
Neoprene
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Eye wash bottle with pure water
Tightly fitting safety goggles
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
Aerosol containing a compressed gas
Colour
:
clear
Odour
:
aliphatic, solvent-like
Odour Threshold
:
No data available
pH : No data available
Melting point/freezing point
:
No data available
Boiling point
:
Not applicable
Flash point
:
Not applicable
Evaporation rate
:
not determined
Upper explosion limit
:
not determined
Lower explosion limit
:
not determined
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
5 / 11
Page 6
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
Density
:
No data available
Water solubility
:
Not applicable
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
Vapours may form explosive mixture with air.
No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks.
Incompatible materials
:
Strong oxidizing agents
Hazardous decomposition
products
:
Carbon dioxide (CO2)
Carbon monoxide
Acute oral toxicity
:
LD50 Oral Rat: 7,060 mg/kg
Acute inhalation toxicity
:
LC50 Rat: 124.7 mg/l
Exposure time: 4 h
Acute inhalation toxicity
:
LC50 Rat: 103,000 mg/l
Exposure time: 4 h
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Components:
ethanol:
heptane:
Skin corrosion/irritation
Product:
6 / 11
Page 7
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
Remarks: slight irritation
Remarks: slight irritation
Remarks: Symptoms of overexposure may be headache, dizziness, tiredness, nausea
and vomiting., Concentrations substantially above the TLV value may cause narcotic
effects., Solvents may degrease the skin.
Partition coefficient: n-
:
Remarks: No data available
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
Naphtha (petroleum), hydrotreated light:
ethanol:
carbon dioxide:
heptane:
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
7 / 11
Page 8
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
octanol/water
Partition coefficient: noctanol/water
:
log Pow: > 3.0
log Pow: 5
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Very toxic
to aquatic life., May cause long lasting harmful effects to
aquatic life.
Waste from residues
:
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, 2.1, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, Aerosols, flammable, 2.1, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, Aerosols, flammable, 2.1, - Limited quantity
Components:
heptane :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
8 / 11
Page 9
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, 2.1, - Limited quantity
SARA 311/312 Hazards
:
Fire Hazard
Sudden Release of Pressure Hazard
Acute Health Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
California Prop 65
WARNING! This product contains a chemical known to the
State of California to cause cancer.
benzene
71-43-2
WARNING: This product contains a chemical known to the
State of California to cause birth defects or other reproductive
harm.
toluene
108-88-3
benzene
71-43-2
TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL
AICS
On the inventory, or in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
On the inventory, or in compliance with the inventory
IECSC
On the inventory, or in compliance with the inventory
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TCSI (Taiwan), TSCA (USA)
SECTION 16. OTHER INFORMATION
9 / 11
Page 10
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Extremely flammable aerosol. Contains gas under pressure; may explode if heated.
Causes skin irritation. May cause drow siness or dizziness.
Precautionary statements
:
Prevention: Keep away from heat/sparks/open flames/hot surfaces. No smoking. Do
not spray on an open flame or other ignition source. Pressurized container: Do not
pierce or burn, even after use. Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.
Wash skin thoroughly after handling. Use only outdoors or in a well-ventilated area.
Wear protective gloves.
Response: IF ON SKIN: Wash with plenty of soap and w ater. IF INHALED: Remove
victim to fresh air and keep at rest in a position comfortable for breathing. Call a
POISON CENTER or doctor/ physician if you feel unwell. If skin irritation occurs: Get
medical advice/ attention. Take off contaminated clothing and w ash before reuse.
Storage: Store in a well-ventilated place. Keep container tightly closed. Store locked
up. Protect from sunlight. Do not expose to temperatures exceeding 50 °C/ 122 °F.
Disposal: Dispose of contents/container in accordance with local regulation.
Version:
2.0
Revision Date:
08/31/2015
Print Date:
10/22/2015
Flammability
Health
Instability
2
4
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
4
2
2
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
Further information
OSHA GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Mis ty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 11
Page 11
SAFETY DATA SHEET
A00734 MST BRK&PARTS CLNR II 20net14
Version 2.0
Revision Date 08/31/2015
Print Date 10/22/2015
11 / 11
Loading...