Page 1
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Material name
:
A00390 MST PENETRATING LUBE 20net19
Material number
:
000000000001002456
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
Aerosol containing a compressed gas
Colour
opaque, brown
Odour
solvent-like
Gases under pressure
:
Compressed gas
Skin irritation
:
Category 2
Eye irritation
:
Category 2A
Carcinogenicity
:
Category 1A
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H280 Contains gas under pressure; may explode if heated.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H350 May cause cancer.
Precautionary statements
:
Prevention:
P201 Obtain special instructions before use.
P202 Do not handle until all safety precautions have been read
and understood.
P264 Wash skin thoroughly after handling.
P280 Wear eye protection/ face protection.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 13
Page 2
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
P280 Wear protective gloves.
P281 Use personal protective equipment as required.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water
for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing.
P308 + P313 IF exposed or concerned: Get medical advice/
attention.
P332 + P313 If skin irritation occurs: Get medical advice/
attention.
P337 + P313 If eye irritation persists: Get medical advice/
attention.
P362 Take off contaminated clothing and wash before reuse.
Storage:
P405 Store locked up.
P410 + P403 Protect from sunlight. Store in a well-ventilated
place.
Disposal:
Dispose of contents/container in accordance with local
regulation.
IARC
Group 1: Carcinogenic to humans
trichloroethylene
79-01-6
Group 2A: Probably carcinogenic to humans
tetrachloroethylene
127-18-4
ACGIH
Suspected human carcinogen
trichloroethylene
79-01-6
Confirmed animal carcinogen with unknown relevance to
humans
tetrachloroethylene
127-18-4
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
Reasonably anticipated to be a human carcinogen
tetrachloroethylene
127-18-4
trichloroethylene
79-01-6
Chemical Name
CAS-No.
Concentration [%]
tetrachloroethylene
127-18-4
>= 50 - < 70
Naphtha (petroleum), hydrotreated light
64742-49-0
>= 10 - < 20
trichloroethylene
79-01-6
>= 5 - < 10
Distillates (petroleum), hydrotreated heavy
naphthenic
64742-52-5
>= 5 - < 10
carbon dioxide
124-38-9
>= 1 - < 5
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
2 / 13
Page 3
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
1,2,4-trimethylbenzene
95-63-6
>= 1 - < 5
General advice
:
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
Do not leave the victim unattended.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15
minutes.
If on skin, rinse well with water.
If on clothes, remove clothes.
In case of eye contact
:
Rinse immediately with plenty of water for at least 15 minutes.
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Take victim immediately to hospital.
Suitable extinguishing media
:
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
Water spray jet
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Chlorine compounds
Sulphur oxides
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
3 / 13
Page 4
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Evacuate personnel to safe areas.
Ensure adequate ventilation.
Remove all sources of ignition.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Advice on safe handling
:
Do not breathe vapours/dust.
Avoid exposure - obtain special instructions before use.
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
Keep in a dry, cool and well-ventilated place.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
Strong oxidizing agents
Keep away from metals.
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 13
Page 5
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
tetrachloroethylene
127-18-4
TWA
25 ppm
ACGIH
STEL
100 ppm
ACGIH
TWA
100 ppm
OSHA Z-2
CEIL
200 ppm
OSHA Z-2
Peak
300 ppm
OSHA Z-2
TWA
25 ppm
170 mg/m3
OSHA P0
trichloroethylene
79-01-6
TWA
10 ppm
ACGIH
STEL
25 ppm
ACGIH
TWA
100 ppm
OSHA Z-2
CEIL
200 ppm
OSHA Z-2
Peak
300 ppm
OSHA Z-2
TWA
50 ppm
270 mg/m3
OSHA P0
STEL
200 ppm
1,080 mg/m3
OSHA P0
Distillates (petroleum),
hydrotreated heavy naphthenic
64742-52-5
TWA (Mist)
5 mg/m3
OSHA Z-1
TWA
(Inhalable
fraction)
5 mg/m3
ACGIH
carbon dioxide
124-38-9
TWA
5,000 ppm
ACGIH
STEL
30,000 ppm
ACGIH
TWA
5,000 ppm
9,000 mg/m3
NIOSH REL
ST
30,000 ppm
54,000 mg/m3
NIOSH REL
TWA
5,000 ppm
9,000 mg/m3
OSHA Z-1
TWA
10,000 ppm
18,000 mg/m3
OSHA P0
STEL
30,000 ppm
54,000 mg/m3
OSHA P0
1,2,4-trimethylbenzene
95-63-6
TWA
25 ppm
125 mg/m3
NIOSH REL
Component
CAS-No.
Control
parameters
Biological
specimen
Sampling
time
Permissible
concentration
Basis
TETRACHLOROETHEN
E
127-18-4
Tetrachloroe
thylene
In blood
Prior to
shift (16
hours
after
exposure
ceases)
0.5 mg/l
ACGIH BEI
TETRACHLOROETHEN
E
Tetrachloroe
thylene
In end-
exhaled air
Prior to
shift (16
hours
after
exposure
ceases)
3 .parts per
million
ACGIH BEI
TRICHLOROETHENE
79-01-6
Trichloroace
tic acid
Urine
End of
shift at
15 mg/l
ACGIH BEI
Biological occupational exposure limits
5 / 13
Page 6
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
end of
workwee
k
TRICHLOROETHENE
Trichloroeth
anol
In blood
End of
shift at
end of
workwee
k
0.5 mg/l
ACGIH BEI
TRICHLOROETHENE
Trichloroeth
ylene
In blood
End of
shift at
end of
workwee
k
ACGIH BEI
TRICHLOROETHENE
Trichloroeth
ylene
In end-
exhaled air
End of
shift at
end of
workwee
k
ACGIH BEI
Respiratory protection
:
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Safety glasses
Skin and body protection
:
Impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
Aerosol containing a compressed gas
Colour
:
opaque, brown
Odour
:
solvent-like
Odour Threshold
:
No data available
pH : Not applicable
Melting point/freezing point
:
No data available
Boiling point
:
No data available
Personal protective equipment
Hand protection
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
6 / 13
Page 7
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Flash point
:
No data available
Evaporation rate
:
No data available
Flammability (solid, gas)
:
The product is not flammable.
Upper explosion limit
:
No data available
Lower explosion limit
:
No data available
Vapour pressure
:
No data available
Relative vapour density
:
No data available
Density
:
1.210 g/cm3
Water solubility
:
insoluble
Solubility in other solvents
:
not determined
Partition coefficient: noctanol/water
:
No data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
No data available
Viscosity, kinematic
:
No data available
Heat of combustion
:
18.53 kJ/g
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks.
Extremes of temperature and direct sunlight.
Incompatible materials
:
Strong oxidizing agents
Aluminium
Metals
Hazardous decomposition
products
:
Carbon oxides
Sulphur oxides
Chlorine
Phosgene
Hydrogen fluoride
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
7 / 13
Page 8
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Acute oral toxicity
:
Acute toxicity estimate : 4,421 mg/kg
Method: Calculation method
Acute inhalation toxicity
:
Acute toxicity estimate : > 10 mg/l
Exposure time: 4 h
Test atmosphere: dust/mist
Method: Calculation method
Acute dermal toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Acute oral toxicity
:
LD50 Oral Rat: 2,629 mg/kg
Acute inhalation toxicity
:
LC50 Rat: 34,200 mg/l
Exposure time: 8 h
Acute dermal toxicity
:
LD50 Dermal Rabbit: 5,000 mg/kg
Acute oral toxicity
:
LD50 Oral Rat: 4,920 mg/kg
Acute inhalation toxicity
:
LC50 Mouse: 8450 ppm
Exposure time: 4 h
Acute dermal toxicity
:
LD50 Dermal Rabbit: > 20,000 mg/kg
Acute oral toxicity
:
LD50 Rat: > 5,000 mg/kg
Acute inhalation toxicity
:
LC50 Rat: > 5 mg/l
Exposure time: 4 h
Acute dermal toxicity
:
LD50 Rabbit: > 5,000 mg/kg
Remarks: May cause skin irritation and/or dermatitis.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Product:
Components:
tetrachloroethylene:
trichloroethylene:
Distillates (petroleum), hydrotreated heavy naphthenic:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
8 / 13
Page 9
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Remarks: May cause irreversible eye damage.
Remarks: No data available
Partition coefficient: noctanol/water
:
Remarks: No data available
Partition coefficient: noctanol/water
:
log Pow: 3.40
Respiratory or skin sensitisation
No data available
Germ cell mutagenicity
No data available
Carcinogenicity
No data available
Reproductive toxicity
No data available
tetrachloroethylene:
Naphtha (petroleum), hydrotreated light:
trichloroethylene:
Distillates (petroleum), hydrotreated heavy naphthenic:
carbon dioxide:
1,2,4-trimethylbenzene:
STOT - single exposure
No data available
STOT - repeated exposure
No data available
Aspiration toxicity
No data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
Product:
Components:
tetrachloroethylene :
9 / 13
Page 10
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Partition coefficient: noctanol/water
:
log Pow: 2.29
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Toxic to
aquatic life.
Waste from residues
:
The product should not be allowed to enter drains, water
courses or the soil.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Do not dispose of waste into sewer.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
trichloroethylene :
Mobility in soil
No data available
Other adverse effects
No data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
10 / 13
Page 11
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
tetrachloroethylene
127-18-4
100
182
SARA 311/312 Hazards
:
Sudden Release of Pressure Hazard
Acute Health Hazard
Chronic Health Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
The following components are subject to reporting levels
established by SARA Title III, Section 313:
tetrachloroethylene
127-18-4
54.99 %
trichloroethylene
79-01-6
8.385 %
1,2,4-trimethylbenzene
95-63-6
1.0023 %
California Prop 65
WARNING! This product contains a chemical known to the
State of California to cause cancer.
tetrachloroethylene
127-18-4
trichloroethylene
79-01-6
ethylbenzene
100-41-4
benzene
71-43-2
naphthalene
91-20-3
WARNING: This product contains a chemical known to the
State of California to cause birth defects or other reproductive
harm.
toluene
108-88-3
benzene
71-43-2
TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL
AICS
On the inventory, or in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
On the inventory, or in compliance with the inventory
IECSC
On the inventory, or in compliance with the inventory
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
11 / 13
Page 12
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Contains gas under pressure; may explode if heated. Causes skin irritation. Causes
serious eye irritation. May cause cancer.
Precautionary statements
:
Prevention: Obtain special instructions before use. Do not handle until all safety
precautions have been read and understood. Wash skin thoroughly after handling.
Wear eye protection/ face protection. Wear protective gloves. Use personal protective
equipment as required.
Response: IF ON SKIN: Wash with plenty of soap and w ater. IF IN EYES: Rinse
cautiously w ith water for several minutes. Remove contact lenses, if present and easy
to do. Continue rinsing. IF exposed or concerned: Get medical advice/ attention. If skin
irritation occurs: Get medical advice/ attention. If eye irritation persists: Get medical
advice/ attention. Take off contaminated clothing and w ash before reuse.
Storage: Store locked up. Protect from sunlight. Store in a well-ventilated place.
Disposal: Dispose of contents/container in accordance with local regulation.
Version:
2.0
Revision Date:
10/05/2015
Print Date:
10/22/2015
Flammability
Health
Instability
2
2
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
2
0
2*
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TCSI (Taiwan), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
12 / 13
Page 13
SAFETY DATA SHEET
A00390 MST PENETRATING LUBE 20net19
Version 2.0
Revision Date 10/05/2015
Print Date 10/22/2015
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Mis ty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, F C
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
13 / 13
Loading...