Misty 1038799 User Manual

SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
Material name
:
BL0925 MST BOLEX 12QT CS Material number
:
000000000001038799
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW Atlanta, GA 30318 Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded. In the District of Columbia 202-483-7616
Appearance
liquid
Colour
opaque, white
Odour
pungent
Skin corrosion
:
Category 1A
Serious eye damage
:
Category 1
Specific target organ toxicity ­single exposure
:
Category 3 (Respiratory system)
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H314 Causes severe skin burns and eye damage. H335 May cause respiratory irritation.
Precautionary statements
:
Prevention: P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. P264 Wash skin thoroughly after handling. P271 Use only outdoors or in a well-ventilated area. P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.
Response:
P301 + P330 + P331 IF SWALLOWED: Rinse mouth. Do NOT
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
induce vomiting. P303 + P361 + P353 IF ON SKIN (or hair): Remove/ Take off immediately all contaminated clothing. Rinse skin with water/ shower. P304 + P340 + P310 IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately call a POISON CENTER or doctor/ physician. P305 + P351 + P338 + P310 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or doctor/ physician. P363 Wash contaminated clothing before reuse. Storage: P403 + P233 Store in a well-ventilated place. Keep container tightly closed. P405 Store locked up. Disposal: P501 Dispose of contents/container in accordance with local regulation.
IARC
No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA.
NTP
No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP.
Substance / Mixture
:
Mixture
Chemical Name
CAS-No.
Concentration [%]
HYDROCHLORIC ACID
7647-01-0
>= 20 - < 25
General advice
:
Move out of dangerous area. Consult a physician. Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended.
If inhaled
:
If unconscious place in recovery position and seek medical advice.
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
SECTION 4. FIRST AID MEASURES
2 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
If breathed in, move person into fresh air. If breathing is irregular or stopped, administer artificial respiration.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15 minutes. If on clothes, remove clothes. Get medical attention if irritation develops and persists.
In case of eye contact
:
If in eyes, rinse with water for 15 minutes. Remove contact lenses. Protect unharmed eye. If eye irritation persists, consult a specialist.
If swallowed
:
Keep respiratory tract clear. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician.
Suitable extinguishing media
:
Alcohol-resistant foam Carbon dioxide (CO2) Dry chemical
Unsuitable extinguishing media
:
High volume water jet
Specific hazards during firefighting
:
Do not allow run-off from fire fighting to enter drains or water courses. Hazardous combustion products
:
Chlorine compounds
Specific extinguishing methods
:
Use extinguishing measures that are appropriate to local circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations.
Special protective equipment for firefighters
:
Wear self-contained breathing apparatus for firefighting if necessary.
Personal precautions, protective equipment and emergency procedures
:
Use personal protective equipment. Environmental precautions
:
Prevent product from entering drains. Prevent further leakage or spillage if safe to do so.
SECTION 5. FIREFIGHTING MEASURES
SECTION 6. ACCIDENTAL RELEASE MEASURES
3 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
If the product contaminates rivers and lakes or drains inform respective authorities.
Methods and materials for containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Keep in suitable, closed containers for disposal.
Advice on safe handling
:
Avoid exposure - obtain special instructions before use. Avoid contact with skin and eyes. For personal protection see section 8. Smoking, eating and drinking should be prohibited in the application area. Provide sufficient air exchange and/or exhaust in work rooms. To avoid spills during handling keep bottle on a metal tray. Dispose of rinse water in accordance with local and national regulations.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated place. Observe label precautions. Electrical installations / working materials must comply with the technological safety standards.
Materials to avoid
:
Store and keep away from, reducing agents, bases and alkalies.
Components
CAS-No.
Value type (Form of exposure)
Control parameters / Permissible concentration
Basis
HYDROCHLORIC ACID
7647-01-0
C
2 ppm
ACGIH
C
5 ppm 7 mg/m3
NIOSH REL
C
5 ppm 7 mg/m3
OSHA Z-1
C
5 ppm 7 mg/m3
OSHA P0
Respiratory protection
:
Use respiratory protection unless adequate local exhaust ventilation is provided or exposure assessment demonstrates that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed with the producers of the protective gloves.
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Personal protective equipment
Hand protection
4 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
Eye protection
:
Ensure that eyewash stations and safety showers are close to the workstation location. Tightly fitting safety goggles Wear face-shield and protective suit for abnormal processing problems.
Skin and body protection
:
impervious clothing Choose body protection according to the amount and concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday.
Appearance
:
liquid
Colour
:
opaque, white
Odour
:
pungent
Odour Threshold
:
no data available
pH : < 1
Melting point/freezing point
:
no data available
Boiling point
:
no data available
Flash point
:
not applicable
Evaporation rate
:
no data available
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Relative vapour density
:
1.112
Density
:
no data available
Water solubility
:
soluble
Partition coefficient: n­octanol/water
:
no data available
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
5 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
no data available
Incompatible materials
:
Alkali metals
Hazardous decomposition products
:
No decomposition if stored normally.
Remarks: Extremely corrosive and destructive to tissue.
Remarks: May cause irreversible eye damage.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
no data available
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
HYDROCHLORIC ACID:
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
no data available
Further information
Product:
6 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
Remarks: no data available
Partition coefficient: n­octanol/water
:
Remarks: no data available
Regulation
40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances
Remarks
This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B).
Additional ecological information
:
no data available
Waste from residues
:
Do not dispose of waste into sewer. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents. Dispose of as unused product. Do not re-use empty containers.
SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Mobility in soil
no data available
Other adverse effects
no data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
7 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
Transportation Regulation: 49 CFR (USA): ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel): UN1760, CORROSIVE LIQUID, N.O.S., (HYDROCHLORIC ACID), 8, II - Limited quantity
Transportation Regulation: IATA (Cargo Air): UN1760, Corrosive liquid, n.o.s., (HYDROCHLORIC ACID), 8, II - Limited quantity
Transportation Regulation: IATA (Passenger Air): UN1760, Corrosive liquid, n.o.s., (HYDROCHLORIC ACID), 8, II - Limited quantity
Transportation Regulation: TDG (Canada): UN1760, CORROSIVE LIQUID, N.O.S., (HYDROCHLORIC ACID), 8, II - Limited quantity
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
HYDROCHLORIC ACID
7647-01-0
5000
*
SARA 311/312 Hazards
:
Acute Health Hazard
SARA 302
:
SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302.
SARA 313
:
SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm.
TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL.
AICS
On the inventory, or in compliance with the inventory
NZIoC
On the inventory, or in compliance with the inventory
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
The components of this product are reported in the following inventories:
8 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
PICCS
On the inventory, or in compliance with the inventory
IECSC
On the inventory, or in compliance with the inventory
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Causes severe skin burns and eye damage. May cause respiratory irritation.
Precautionary statements
: Prevention: Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. Wash skin thoroughly after handling. Use only outdoors or in a w ell-ventilated area. Wear protective gloves/ protective clothing/ eye protection/ face protection. Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN (or hair): Remove/ Take off immediately all contaminated clothing. Rinse skin with w ater/ shower. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately call a POISON CENTER or doctor/ physician. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or doctor/ physician. Wash contaminated clothing before reuse. Storage: Store in a well-ventilated place. Keep container tightly closed. Store locked up. Disposal: Dispose of contents/container in accordance with local regulation.
Version:
1.0
Revision Date:
06/16/2015
Print Date:
05/09/2017
Flammability
Health
Instability
3
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
0
3
0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL (Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this
9 / 10
SAFETY DATA SHEET
BL0925 MST BOLEX 12QT CS
Version 1.0
Print Date 05/09/2017
document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig ™, Mis ty®, Next Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®, Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 10
Loading...