Page 1
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Material name
:
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Material number
:
000000000001038773
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
liquid
Colour
white
Odour
mild, characteristic
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
Not a dangerous substance or mixture according to the Globally Harmonised System (GHS).
GHS Label element
Not a dangerous substance or mixture according to the Globally Harmonised System (GHS).
Potential Health Effects
Carcinogenicity:
1 / 8
Page 2
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Substance / Mixture
:
Mixture
General advice
:
Show this safety data sheet to the doctor in attendance.
Move out of dangerous area.
Do not leave the victim unattended.
If inhaled
:
Consult a physician after significant exposure.
If unconscious place in recovery position and seek medical
advice.
In case of skin contact
:
Wash off immediately with plenty of water for at least 15
minutes.
If skin irritation persists, call a physician.
In case of eye contact
:
If in eyes, rinse with water for 15 minutes.
If eye irritation persists, consult a specialist.
If swallowed
:
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
If symptoms persist, call a physician.
Suitable extinguishing media
:
Water spray jet
Carbon dioxide (CO2)
Alcohol-resistant foam
Dry chemical
Unsuitable extinguishing
media
:
None known.
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
No hazardous combustion products are known
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
Contains no hazardous ingredients according to GHS
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 8
Page 3
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Personal precautions,
protective equipment and
emergency procedures
:
Evacuate personnel to safe areas.
Use personal protective equipment.
Keep people away from and upwind of spill/leak.
Environmental precautions
:
Prevent further leakage or spillage if safe to do so.
Prevent further leakage or spillage.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Advice on safe handling
:
Wear personal protective equipment.
Smoking, eating and drinking should be prohibited in the
application area.
Conditions for safe storage
:
Keep container closed when not in use.
Keep in a dry, cool and well-ventilated place.
Store in original container.
Containers which are opened must be carefully resealed and
kept upright to prevent leakage.
Materials to avoid
:
No materials to be especially mentioned.
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
Eye protection
:
Safety goggles
Ensure that eyewash stations and safety showers are close to
the workstation location.
Skin and body protection
:
impervious clothing
Choose body protection according to the amount and
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Personal protective equipment
Hand protection
3 / 8
Page 4
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not smoke.
When using do not eat or drink.
Wash hands before breaks and at the end of workday.
Appearance
:
liquid
Colour
:
white
Odour
:
mild, characteristic
Odour Threshold
:
no data available
pH : 7 - 8
Melting point/freezing point
:
no data available
Boiling point
:
no data available
Flash point
:
not applicable
Evaporation rate
:
no data available
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Density
:
1 g/cm3
Water solubility
:
soluble
Partition coefficient: noctanol/water
:
no data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
No decomposition if stored and applied as directed.
Conditions to avoid
:
no data available
Incompatible materials
:
no data available
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
4 / 8
Page 5
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Hazardous decomposition
products
:
No hazardous decomposition products are known.
Partition coefficient: noctanol/water
:
Remarks: no data available
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
no data available
Skin corrosion/irritation
no data available
Serious eye damage/eye irritation
no data available
Respiratory or skin sensitisation
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
no data available
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Mobility in soil
5 / 8
Page 6
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Waste from residues
:
Dispose of in accordance with local regulations.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
The product should not be allowed to enter drains, water
courses or the soil.
Contaminated packaging
:
Dispose of as unused product.
Empty remaining contents.
Do not re-use empty containers.
Transportation Regulation: 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IMDG (Vessel):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Cargo Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: IATA (Passenger Air):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
Transportation Regulation: TDG (Canada):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
no data available
Other adverse effects
no data available
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
This material does not contain any components with a CERCLA RQ.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
6 / 8
Page 7
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
SARA 311/312 Hazards
:
No SARA Hazards
SARA 302
:
SARA 302: No chemicals in this material are subject to the
reporting requirements of SARA Title III, Section 302.
SARA 313
:
SARA 313: This material does not contain any chemical
components with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by SARA
Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
Not in compliance with the inventory
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
Not in compliance with the inventory
NFPA:
HMIS III:
Version:
1.0
Flammability
Health
Instability
0
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
0
0
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
Not a dangerous substance or mixture according to the Globally Harmonised System (GHS).
7 / 8
Page 8
SAFETY DATA SHEET
BL0827 MST EDF-3 DEFOAMER 4/1GLL
Version 1.0
Revision Date 06/12/2015
Print Date 10/14/2015
Revision Date:
06/12/2015
Print Date:
10/14/2015
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
8 / 8
Loading...