SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Material name
:
A00170 MST AP CLNR 20net19
Material number
:
000000000001001592
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW
Atlanta, GA 30318
Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation
Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded.
In the District of Columbia 202-483-7616
Appearance
Aerosol containing a liquefied gas
Colour
white
Odour
ammoniacal, mint-like
Gases under pressure
:
Liquefied gas
Hazard pictograms
:
Signal word
:
Warning
Hazard statements
:
H280 Contains gas under pressure; may explode if heated.
Precautionary statements
:
Storage:
P410 + P403 Protect from sunlight. Store in a well-ventilated
place.
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
Potential Health Effects
Carcinogenicity:
1 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
ACGIH
Confirmed animal carcinogen with unknown relevance to
humans
2-butoxyethanol
111-76-2
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
Chemical Name
CAS-No.
Concentration [%]
butane
106-97-8
>= 1 - < 5
2-butoxyethanol
111-76-2
>= 1 - < 5
4-Nonylphenol branched, ethoxylated
127087-87-0
>= 1 - < 5
General advice
:
Do not leave the victim unattended.
Move out of dangerous area.
Show this safety data sheet to the doctor in attendance.
If inhaled
:
If unconscious place in recovery position and seek medical
advice.
If symptoms persist, call a physician.
In case of skin contact
:
If skin irritation persists, call a physician.
Wash off immediately with plenty of water for at least 15
minutes.
If on clothes, remove clothes.
In case of eye contact
:
Remove contact lenses.
Protect unharmed eye.
Keep eye wide open while rinsing.
If eye irritation persists, consult a specialist.
If in eyes, rinse with water for 15 minutes.
If swallowed
:
Keep respiratory tract clear.
Never give anything by mouth to an unconscious person.
If symptoms persist, call a physician.
DO NOT induce vomiting unless directed to do so by a
physician or poison control center.
Suitable extinguishing media
:
Water spray jet
Alcohol-resistant foam
Carbon dioxide (CO2)
Dry chemical
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
2 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Unsuitable extinguishing
media
:
High volume water jet
Specific hazards during
firefighting
:
Do not allow run-off from fire fighting to enter drains or water
courses.
Hazardous combustion
products
:
Carbon dioxide (CO2)
Carbon monoxide
Smoke
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Further information
:
Collect contaminated fire extinguishing water separately. This
must not be discharged into drains.
Fire residues and contaminated fire extinguishing water must
be disposed of in accordance with local regulations.
Special protective equipment
for firefighters
:
Wear self-contained breathing apparatus for firefighting if
necessary.
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Evacuate personnel to safe areas.
Remove all sources of ignition.
Beware of vapours accumulating to form explosive
concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent product from entering drains.
Prevent further leakage or spillage if safe to do so.
If the product contaminates rivers and lakes or drains inform
respective authorities.
Methods and materials for
containment and cleaning up
:
Sweep up or vacuum up spillage and collect in suitable
container for disposal.
Soak up with inert absorbent material (e.g. sand, silica gel,
acid binder, universal binder, sawdust).
Advice on safe handling
:
Avoid contact with skin and eyes.
For personal protection see section 8.
Smoking, eating and drinking should be prohibited in the
application area.
Dispose of rinse water in accordance with local and national
regulations.
Do not breathe vapours or spray mist.
Always replace cap after use.
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
3 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun
exposure and temperatures over 50 °C. Do not open by force
or throw into fire even after use. Do not spray on flames or
red-hot objects.
Keep in a dry, cool and well-ventilated place.
Observe label precautions.
Electrical installations / working materials must comply with
the technological safety standards.
Materials to avoid
:
No materials to be especially mentioned.
Components
CAS-No.
Value type
(Form of
exposure)
Control
parameters /
Permissible
concentration
Basis
butane
106-97-8
TWA
800 ppm
1,900 mg/m3
NIOSH REL
TWA
800 ppm
1,900 mg/m3
OSHA P0
2-butoxyethanol
111-76-2
TWA
20 ppm
ACGIH
TWA
5 ppm
24 mg/m3
NIOSH REL
TWA
50 ppm
240 mg/m3
OSHA Z-1
TWA
25 ppm
120 mg/m3
OSHA P0
Component
CAS-No.
Control
parameters
Biological
specimen
Sampling
time
Permissible
concentration
Basis
2-BUTOXYETHANOL
111-76-2
Butoxyacetic
acid (BAA)
Urine
End of
shift (As
soon as
possible
after
exposure
ceases)
200 mg/g
ACGIH BEI
Remarks:
Creatinine
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory
equipment.
Use respiratory protection unless adequate local exhaust
ventilation is provided or exposure assessment demonstrates
that exposures are within recommended exposure guidelines.
Remarks
:
The suitability for a specific workplace should be discussed
with the producers of the protective gloves.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Biological occupational exposure limits
Personal protective equipment
Hand protection
4 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Eye protection
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Safety glasses
Skin and body protection
:
impervious clothing
Choose body protection according to the amount and
concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink.
When using do not smoke.
Wash hands before breaks and at the end of workday.
Appearance
:
Aerosol containing a liquefied gas
Colour
:
white
Odour
:
ammoniacal, mint-like
pH : no data available
Melting point/freezing point
:
no data available
Boiling point
:
no data available
Flash point
:
not applicable
Evaporation rate
:
no data available
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Density
:
1 g/cm3
Water solubility
:
soluble
Partition coefficient: noctanol/water
:
no data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
Heat of combustion
:
3.13 kJ/g
Reactivity
:
Stable
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
5 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous
reactions
:
Vapours may form explosive mixture with air.
No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks.
Extremes of temperature and direct sunlight.
Incompatible materials
:
Copper
Alkali metals
Hazardous decomposition
products
:
Carbon oxides
Nitrogen oxides (NOx)
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Acute inhalation toxicity
:
Acute toxicity estimate : > 10 mg/l
Exposure time: 4 h
Test atmosphere: dust/mist
Method: Calculation method
Acute dermal toxicity
:
Acute toxicity estimate : > 5,000 mg/kg
Method: Calculation method
Remarks: May cause skin irritation and/or dermatitis.
Remarks: Vapours may cause irritation to the eyes, respiratory system and the skin.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Product:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
no data available
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
6 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Remarks: no data available
Partition coefficient: noctanol/water
:
Remarks: no data available
Partition coefficient: noctanol/water
:
Pow: 2.89
Regulation
40 CFR Protection of Environment; Part 82 Protection of
Stratospheric Ozone - CAA Section 602 Class I
Substances
Remarks
This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
no data available
butane:
2-butoxyethanol:
4-Nonylphenol branched, ethoxylated:
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
no data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Components:
butane :
Mobility in soil
no data available
Other adverse effects
no data available
Product:
7 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Additional ecological
information
:
An environmental hazard cannot be excluded in the
event of unprofessional handling or disposal., Harmful to
aquatic life.
Waste from residues
:
The product should not be allowed to enter drains, water
courses or the soil.
Do not contaminate ponds, waterways or ditches with
chemical or used container.
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents.
Dispose of as unused product.
Do not re-use empty containers.
Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA):
ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Cargo Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: IATA (Passenger Air):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Transportation Regulation: TDG (Canada):
UN1950, AEROSOLS, NON-FLAMMABLE, 2.2, - Limited quantity
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
ammonia, aqueous solution
1336-21-6
1000
*
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
8 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
SARA 311/312 Hazards
:
Sudden Release of Pressure Hazard
SARA 302
:
The following components are subject to reporting levels
established by SARA Title III, Section 302:
ammonia, aqueous solution
1336-21-6
0.1146 %
SARA 313
:
SARA 313: This material does not contain any chemical
components with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by SARA
Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of
California to cause cancer, birth defects, or any other
reproductive harm.
TSCA
On TSCA Inventory
DSL
This product contains one or several components that are not on the
Canadian DSL nor NDSL.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
Not in compliance with the inventory
NFPA:
HMIS III:
Flammability
Health
Instability
3
0
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
0
2
3
0 = not significant, 1 =Slight,
2 = Moderate, 3 = High
4 = Extreme, * = Chronic
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL
(Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
9 / 10
SAFETY DATA SHEET
A00170 MST AP CLNR 20net19
Version 1.0
Revision Date 02/19/2015
Print Date 06/01/2015
Hazard pictograms
:
Signal word
:
Warning:
Hazard statements
:
Contains gas under pressure; may explode if heated.
Precautionary statements
:
Storage: Protect from sunlight. Store in a well-ventilated place.
OSHA GHS Label Information:
We believe the statements, technical information and recommendations contained herein are
reliable, but they are given without warranty or guarantee of any kind. The information in this
document applies to this specific material as supplied. It may not be valid for this material if it
is used in combination with any other materials. Users should make their own investigations
to determine the suitability and applicability of the information for their particular purposes.
This SDS has been prepared by the Compliance Services organization supporting this
manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®,
Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC
Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
10 / 10
Loading...