Misty 1001403, AMR A238-20-LP User Manual

SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Material name
:
A00238LP MST TRAD LEMON PL HH 20net10
Material number
:
000000000001001842
Company
:
Zep Inc.
Address
:
1310 Seaboard Industrial Blvd., NW Atlanta, GA 30318 Telephone
:
404-352-1680
Emergency telephone numbers
For SDS Information
:
Compliance Services 1-877-428-9937
For a Medical Emergency
:
877-541-2016 Toll Free - All Calls Recorded
For a Transportation Emergency
:
CHEMTREC: 800-424-9300 - All Calls Recorded. In the District of Columbia 202-483-7616
Appearance
Aerosol containing a liquefied gas
Colour
colourless
Odour
characteristic
Flammable aerosols
:
Category 1
Gases under pressure
:
Liquefied gas
Eye irritation
:
Category 2A
Skin sensitisation
:
Category 1
Specific target organ toxicity ­single exposure
:
Category 3 (Central nervous system)
Hazard pictograms
:
Signal word
:
Danger
Hazard statements
:
H222 Extremely flammable aerosol. H280 Contains gas under pressure; may explode if heated. H317 May cause an allergic skin reaction. H319 Causes serious eye irritation. H336 May cause drowsiness or dizziness.
Precautionary statements
:
Prevention: P210 Keep away from heat, hot surfaces, sparks, open flames
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Manufacturer or supplier's details
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
GHS Classification
GHS Label element
1 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
and other ignition sources. No smoking. P211 Do not spray on an open flame or other ignition source. P251 Pressurized container: Do not pierce or burn, even after use. P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. P264 Wash skin thoroughly after handling. P271 Use only outdoors or in a well-ventilated area. P272 Contaminated work clothing should not be allowed out of the workplace. P280 Wear eye protection/ face protection. P280 Wear protective gloves.
Response:
P302 + P352 IF ON SKIN: Wash with plenty of soap and water. P304 + P340 + P312 IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/ physician if you feel unwell. P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P333 + P313 If skin irritation or rash occurs: Get medical advice/ attention. P337 + P313 If eye irritation persists: Get medical advice/ attention. P363 Wash contaminated clothing before reuse. Storage: P403 + P233 Store in a well-ventilated place. Keep container tightly closed. P405 Store locked up. P410 + P412 Protect from sunlight. Do not expose to temperatures exceeding 50 °C/ 122 °F. Disposal: P501 Dispose of contents/container in accordance with local regulation.
IARC
No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
ACGIH
No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH.
OSHA
No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA.
NTP
No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP.
Substance / Mixture
:
Mixture
Potential Health Effects
Carcinogenicity:
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
2 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Chemical Name
CAS-No.
Concentration [%]
acetone
67-64-1
>= 70 - < 90
propane
74-98-6
>= 10 - < 20
butane
106-97-8
>= 5 - < 10
Proprietary Fragrance Component
Not Assigned
>= 1 - < 5
citral
5392-40-5
>= 0.1 - < 1
General advice
:
Show this safety data sheet to the doctor in attendance.
If inhaled
:
Remove to fresh air. Call a physician or poison control centre immediately.
In case of skin contact
:
If skin irritation persists, call a physician. If on clothes, remove clothes. Wash off immediately with plenty of water for at least 15 minutes.
In case of eye contact
:
Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. Rinse immediately with plenty of water for at least 15 minutes.
If swallowed
:
DO NOT induce vomiting unless directed to do so by a physician or poison control center. Take victim immediately to hospital. Never give anything by mouth to an unconscious person. Keep respiratory tract clear.
Suitable extinguishing media
:
Foam Carbon dioxide (CO2) Dry chemical Water
Unsuitable extinguishing media
:
High volume water jet
Specific hazards during firefighting
:
Do not allow run-off from fire fighting to enter drains or water courses.
Hazardous combustion products
:
Carbon dioxide (CO2) Carbon monoxide Smoke
Specific extinguishing methods
:
Use extinguishing measures that are appropriate to local circumstances and the surrounding environment.
Further information
:
For safety reasons in case of fire, cans should be stored separately in closed containments.
Hazardous components
SECTION 4. FIRST AID MEASURES
SECTION 5. FIREFIGHTING MEASURES
3 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Use a water spray to cool fully closed containers.
Special protective equipment for firefighters
:
Wear self-contained breathing apparatus for firefighting if necessary.
Personal precautions, protective equipment and emergency procedures
:
Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Beware of vapours accumulating to form explosive concentrations. Vapours can accumulate in low areas.
Environmental precautions
:
Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities.
Methods and materials for containment and cleaning up
:
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Sweep up and shovel into suitable containers for disposal.
Advice on safe handling
:
Do not breathe vapours or spray mist. Avoid exposure - obtain special instructions before use. Avoid contact with skin and eyes. Take precautionary measures against static discharges. Use only with adequate ventilation. Always replace cap after use.
Conditions for safe storage
:
BEWARE: Aerosol is pressurized. Keep away from direct sun exposure and temperatures over 50 °C. Do not open by force or throw into fire even after use. Do not spray on flames or red-hot objects. No smoking. Observe label precautions. Electrical installations / working materials must comply with the technological safety standards. Keep in a dry, cool and well-ventilated place.
Materials to avoid
:
Store and keep away from bases and alkalies.
Components
CAS-No.
Value type (Form of exposure)
Control parameters / Permissible concentration
Basis
SECTION 6. ACCIDENTAL RELEASE MEASURES
SECTION 7. HANDLING AND STORAGE
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
4 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
acetone
67-64-1
TWA
500 ppm
ACGIH
STEL
750 ppm
ACGIH
TWA
250 ppm 590 mg/m3
NIOSH REL
TWA
1,000 ppm 2,400 mg/m3
OSHA Z-1
TWA
750 ppm 1,800 mg/m3
OSHA P0
STEL
1,000 ppm 2,400 mg/m3
OSHA P0 propane
74-98-6
TWA
1,000 ppm
ACGIH
TWA
1,000 ppm 1,800 mg/m3
NIOSH REL
TWA
1,000 ppm 1,800 mg/m3
OSHA Z-1
TWA
1,000 ppm 1,800 mg/m3
OSHA P0
butane
106-97-8
TWA
800 ppm 1,900 mg/m3
NIOSH REL
TWA
800 ppm 1,900 mg/m3
OSHA P0
Component
CAS-No.
Control
parameters
Biological specimen
Sampling
time
Permissible
concentration
Basis
2-PROPANONE
67-64-1
Acetone
Urine
End of
shift (As
soon as
possible
after
exposure
ceases)
50 mg/l
ACGIH BEI
Respiratory protection
:
In case of insufficient ventilation, wear suitable respiratory equipment.
Remarks
:
The suitability for a specific workplace should be discussed with the producers of the protective gloves.
Eye protection
:
Safety glasses Ensure that eyewash stations and safety showers are close to the workstation location.
Skin and body protection
:
impervious clothing Choose body protection according to the amount and concentration of the dangerous substance at the work place.
Hygiene measures
:
When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday.
Biological occupational exposure limits
Personal protective equipment
Hand protection
5 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Appearance
:
Aerosol containing a liquefied gas
Colour
:
colourless
Odour
:
characteristic
Odour Threshold
:
no data available
pH : not applicable
Melting point/freezing point
:
no data available
Boiling point
:
not applicable
Flash point
:
not applicable
Evaporation rate
:
not determined
Flammability (solid, gas)
:
Extremely flammable aerosol.
Upper explosion limit
:
no data available
Lower explosion limit
:
no data available
Vapour pressure
:
no data available
Relative vapour density
:
no data available
Density
:
< 1 g/cm3
Water solubility
:
soluble
Solubility in other solvents
:
not determined
Partition coefficient: n­octanol/water
:
no data available
Auto-ignition temperature
:
not determined
Thermal decomposition
:
no data available
Viscosity, kinematic
:
no data available
Reactivity
:
Stable
Chemical stability
:
Stable under normal conditions.
Possibility of hazardous reactions
:
Vapours may form explosive mixture with air. No decomposition if stored and applied as directed.
Conditions to avoid
:
Heat, flames and sparks. Extremes of temperature and direct sunlight.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Solubility(ies)
Viscosity
SECTION 10. STABILITY AND REACTIVITY
6 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Incompatible materials
:
Oxidizing agents Bases Amines
Hazardous decomposition products
:
Carbon dioxide (CO2) Carbon monoxide
Acute oral toxicity
:
Acute toxicity estimate : > 5,000 mg/kg Method: Calculation method
Remarks: slight irritation
Remarks: Irritating to eyes.
Remarks: Causes sensitisation.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute toxicity
Product:
Skin corrosion/irritation
Product:
Serious eye damage/eye irritation
Product:
Respiratory or skin sensitisation
Product:
Germ cell mutagenicity
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
acetone: propane: butane: Proprietary Fragrance Component: citral:
STOT - single exposure
no data available
STOT - repeated exposure
no data available
Aspiration toxicity
7 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Remarks: Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting., Concentrations substantially above the TLV value may cause narcotic effects., Solvents may degrease the skin.
Partition coefficient: n­octanol/water
:
Remarks: no data available
Partition coefficient: n­octanol/water
:
Pow: 2.89
Partition coefficient: n­octanol/water
:
Pow: 2.76
Regulation
40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances
Remarks
This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B).
Additional ecological information
:
no data available
no data available
Further information
Product:
SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity
no data available
Persistence and degradability
no data available
Bioaccumulative potential
Product:
Components: butane :
citral :
Mobility in soil
no data available
Other adverse effects
no data available
Product:
SECTION 13. DISPOSAL CONSIDERATIONS
8 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Waste from residues
:
Dispose of in accordance with local regulations.
Contaminated packaging
:
Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. Do not burn, or use a cutting torch on, the empty drum.
Transportation Regulation: 49 CFR (USA): ORM-D, CONSUMER COMMODITY
Transportation Regulation: IMDG (Vessel): UN1950, AEROSOLS, 2.1, - Limited quantity
Transportation Regulation: IATA (Cargo Air): UN1950, Aerosols, flammable, 2.1, - Limited quantity
Transportation Regulation: IATA (Passenger Air): UN1950, Aerosols, flammable, 2.1, - Limited quantity
Transportation Regulation: TDG (Canada): UN1950, AEROSOLS, 2.1, - Limited quantity
Components
CAS-No.
Component RQ
(lbs)
Calculated product RQ
(lbs)
acetone
67-64-1
5000
*
SARA 311/312 Hazards
:
Fire Hazard Sudden Release of Pressure Hazard Acute Health Hazard
SARA 302
:
SARA 302: No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302.
Disposal methods
SECTION 14. TRANSPORT INFORMATION
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA 304 Extremely Hazardous Substances Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
9 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
SARA 313
:
SARA 313: This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313.
California Prop 65
This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm.
TSCA
On TSCA Inventory
DSL
This product contains one or several components that are not on the Canadian DSL nor NDSL.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
Not in compliance with the inventory
NFPA:
HMIS III:
Hazard pictograms
:
Signal word
:
Danger:
Hazard statements
:
Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May cause an allergic skin reaction. Causes serious eye irritation. May cause drowsiness or dizziness.
Precautionary statements
:
Flammability
Health
Instability
3
4
0
Special hazard.
FLAMMABILITY
PHYSICAL HAZARD
HEALTH
4
2
3
0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic
The components of this product are reported in the following inventories:
Inventory Acronym and Validity Area Legend:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), ISHL (Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TSCA (USA)
SECTION 16. OTHER INFORMATION
Further information
OSHA GHS Label Information:
10 / 11
SAFETY DATA SHEET
A00238LP MST TRAD LEMON PL HH 20net10
Version 1.0
Print Date 06/01/2015
Prevention: Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. Do not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even after use. Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray. Wash skin thoroughly after handling. Use only outdoors or in a well-ventilated area. Contaminated work clothing should not be allowed out of the workplace. Wear eye protection/ face protection. Wear protective gloves. Response: IF ON SKIN: Wash with plenty of soap and water. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/ physician if you feel unwell. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If skin irritation or rash occurs: Get medical advice/ attention. If eye irritation persists: Get medical advice/ attention. Wash contaminated clothing before reuse. Storage: Store in a well-ventilated place. Keep container tightly closed. Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50 °C/ 122 °F. Disposal: Dispose of contents/container in accordance with local regulation.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor.
Zep Inc. markets products under well recognized and established brand names such as Zep®,
Zep Commercial®,Zep Professional®, Enforcer®, National Chemical™, Selig™, Misty®, Next
Dimension™, Petro®, i-Chem®, TimeMist®, TimeWick™, MicrobeMax®, Country Vet®, Konk®, Original Bike Spirits®, Blue Coral®, Black Magic®, Rain-X®, Niagara National™, FC Forward Chemicals®,Rexodan®, Mykal™, and a number of private labeled brands.
11 / 11
Loading...