Minuteman C29485-00 User Manual

290 Series
Model:
Polyethylene Tank Vacuum 4 Gallon Unit
SERVICE PARTS
C29485-02 (115V) Dry Only C29485-02 (230V) Dry Only C29485-00 (230V) Dry Only
CARE
Revised 7/02
FOR COMMERCIAL USE ONLY
IMPORTANT SAFETY INSTRUCTIONS
When using an electrical appliance, basic precautions should always be followed, including the following:
READ ALL INSTRUCTIONS BEFORE USING
WARNING
Do not leave appliance when plugged in. Unplug from outlet when not in use and before servicing.
To avoid electric shock, do not expose to rain, store indoors.
- To reduce the risk of fire, electric shock, or injury:
WARNING: C29485-02, C29486-00/02 Dry Only
To reduce the risk of electrical shock: Do not expose to rain. Store indoors.
Never allow children or untrained adults to operate this equipment.
Keep the area of operation clear of all persons, particularly small children, and pets.
Keep bystanders at least 25 feet away from the area of operation.
Use only as described in this manual. Use only manufacturer’s recommended attachments.
Do not use with damaged cord or plug. If appliance is not working as it should, has been dropped,
damaged, left outdoors, or dropped into water, return it to a service center.
Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord around sharp
edges or corners. Do not run appliance over cord. Keep cord away from heated surfaces.
Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.
Do not handle plug or appliance with wet hands.
Do not put any object into openings. Do not use with any opening blocked; keep free of dust, lint,
hair, and anything that may reduce air flow.
Keep hair, loose clothing, fingers, and all parts of body away from openings and moving parts.
Do not pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes.
Do not use without dustbag and/or filters in place.
Turn off all controls before unplugging.
Use extra care when cleaning on stairs.
Do not use to pick up flammable or combustible liquids such as gasoline or use in areas where
they may be present.
Connect to a properly grounded outlet only. See grounding instructions.
SAVE THESE INSTRUCTIONS
1
INSPECTION
Carefully unpack and inspect your machine for shipping damage. Each unit is tested and thoroughly inspected before shipment, and any damage is the responsibility of the delivery carrier who should be notified immediately.
ELECTRICAL
(Model C29485-02 115V) This machine is designed to operate on a standard 15 amp. 115 volt, 60 hz, AC circuit. Voltages below 105 volts AC or above 125 volts AC could cause serious damage to the motor.
ELECTRICAL
(Model C29486-02 230V) This machine is designed to operate on a standard 16 amp type L fused 230 volt, 50 hz, AC circuit. Voltages below 200 volts AC or above 250 volts AC could cause serious damage to the motor. I.E.C. Class 1.
WARNING
Electric motors can cause explosions when operated near explosive materials or vapors. Do not operate this machine near flammable materials such as solvents, thinners, fuels, grain dust, etc.
GROUNDING INSTRUCTIONS
This appliance must be grounded. If it should malfunction or breakdown, grounding provides a path of least resistance for electric current to reduce the risk of electric shock. This appliance is equipped with a cord having an equipment-grounding conductor and grounding plug. The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances.
DANGER - Improper connection of the equipment-grounding conductor can result in a risk of
electric shock. Check with a qualified electrician or service person if you are in doubt as to whether the outlet is properly grounded. Do not modify the plug provided with the appliance — if it will not fit the outlet, have a proper outlet installed by a qualified electrician.
This appliance is for use on a nominal 120 volt circuit and has a grounding plug that looks like the plug illustrated in Sketch A below. Make sure that the appliance is connected to an outlet having the same configuration as the plug. No adapter should be used with this appliance.
2
USER MAINTENANCE INSTRUCTIONS
All service and repair should be performed by qualified vacuum service representative or electrician. No user serviceable components are employed in the electrical vacuum lid head assembly. No lubrication of the motor is required.
CLOTH BAG & HOSE ASSEMBLY
Cloth bag and hose assembly are user maintenance items and can be replaced when worn out. Cloth bags can be maintained by blowing dust off of the bag and then laundering. Cloth bags should be completely dried before re-installing into machine. For optimum performance, empty and clean filter bag regularly. A clogged and dirty bag restricts the flow of air and results in reduced vacuum. The hose assembly can be maintained by wiping off with a dampened cloth of mild liquid soap and water, then allowed to dry.
CORD STORAGE
While not in use storage can be accomplished by winding cord around motor lid assembly. Cord
should be completely unwound from lid assembly during operation.
Do not use with damaged cord or plug. If appliance is not working as it should, has been dropped,
damaged, left outdoors, or dropped into water, return to service center.
Do not pull or carry by cord, use cord as handle, close a door on cord, or pull cord around sharp
edges or corners. Do not run appliance over cord. Keep cord away from heated surfaces.
Do not unplug by pulling cord. To unplug, grasp the plug, not the cord.
Do not handle plug or appliance with wet hands.
Always unplug the machine when removing the motor head off the tank. This equipment should be
stored indoors and not exposed to rain.
A B
C D
E
TOOLS AND ACCESSORIES
829563 Dust Brush Complete
829562 Crevice Tool
1 1/4” (32 mm)
829565 Wand Tube
(2 required)
829849 Hose Assy. 1 1/4 x 8
(32 mm x 2.4 m)
829561 Combination Floor Tool
F
829564 Upholstery Tool
3
Parts List
1 381001 1 Vac Motor 120V
Item Part No. Qty. Description
1A 380044 1 Vac Motor 240V
2 290017 2 Molded Vac Motor Gasket
3 740705 1 Power Cord Grey
3A 740600 1 Cord
4 460001 1 Handle Basic 460
5 832201 1 Motor Lid Cover
6 460101 1 Motor Cap
7 460116 1 Motor Pan Assembly
8 711125 5 SCR-ST-B 10 x .50 NI
9 832637 1 Motor Hold Down
11 460106 1 Bag Guard
10 832219 1 Diffuser Foam
12 711128 4 SCR-ST-B Hi/Lo 8 x .62 PL
13 711161 8 SCR Hi/Lo #10 x 3/4 PL
14 711162 2 SCR Hi/Lo #10 x 1 1/2 PL
15 711553 1 WSR-Internal Lock #10
16 809754 1 Switch Rocker
17 833237 1 Strain Relief
18 290031 1 Lid Gasket
19 380028 2 Carbon Brush Replacement
20 381801 1 Receptacle
21 381801-1 1 Receptacle Clip
22 832197 1 Felt Upper Dome
23 832198 1 Felt Outer Dome
24 711160 1 SCR Hi/Lo #10 x 5/8 PL
25 715015 1 Decal, Warning
4
Parts List
Item Part No. Qty. Description
1 390087 1 Gasket Diecut 2 390110 1 Intake Assy Aluminum 3 460112 1 Tank 4 Gal. High Intake 3A 460111 1 Tank 4 Gal. Low Intake 4 460115 1 Dolly 5 460114 2 Latch Poly Tank 6 711160 4 SCR Hi/Lo #10 x 5/8 PL 7 712320 2 WSR-Nylon .22 x .45 x .04 8 460118 4 Caster 9 828893 4 Pop Rivet
10 900035 1 Deflector, Intake
11 750118 1 Intake Assy. Tube 4/6 Gal. 12 712638 2 Nut-Hex 10-24 SS Nyloc 13 712824 2 SCR-THMS 10-24 x .75 STPL 14 710530 1 SCR-MC 8-32 x .50 BR 15 711372 1 Nut-Hex 8-32 Nyloc 16 715383 1 Decal, Minuteman
5
Parts List
Item Part No. Qty. Description
1 760244 1 Molded Bag Ring 2 805043 1 Cloth Filter 4 Gallon 3 805044 1 Bag Assy. Complete 4 Gallon
6
LIMITED WARRANTY
Minuteman International, Inc. warrants to the original purchaser/user that this product is free from defects in workmanship and materials under normal use and service for a period of three years from date of purchase. In addition, Minuteman International, Inc. will, at its option, honor labor warranty claims for the first 12 months from date of sale, provided such claims are submitted through and approved by factory authorized repair stations. Minuteman International, Inc. will, at its option, repair or replace without charge, except for transportation costs, parts that fail under normal use and service when operated and maintained in accordance with the applicable operation and instruction manuals.
This warranty does not apply to normal wear, or to items whose life is dependent on their use and care, such as belts, cords, switches, hoses, rubber parts, electrical motor components or adjustments. Parts not manufactured by Minuteman International, Inc. such as engines, batteries, battery chargers, hydraulic pumps, and tires are covered by and subject to the warranties and/ or guarantees of their manufacturers. Please contact Minuteman International, Inc. for procedures in warranty claims against these manufacturers.
Special warning to purchaser — Use of replacement filters and/or prefilters not manufactured by Minuteman International, Inc. or its designated licensees, will void all warranties expressed or implied.
A potential health hazard exists without exact original equipment replacement.
All warranteed items become the sole property of Minuteman International, Inc. or its original manufacturer, whichever the case may be.
Minuteman International, Inc. disclaims any implied warranty, including the warranty of merchantability and the warranty of fitness for a particular purpose. Minuteman International, Inc. assumes no responsibility for any special, incidental or consequential damages.
This limited warranty is applicable only in the U.S.A. and Canada, and is extended only to the original user/purchaser of this product. Customers outside the U.S.A. and Canada should contact their local distributor for export warranty policies. Minuteman International, Inc. is not responsible for costs or repairs performed by persons other than those specifically authorized by Minuteman International, Inc. This warranty does not apply to damage from transportation, alterations by unauthorized persons, misuse or abuse of the equipment, use of non-compatible chemicals, or damage to property, or loss of income due to malfunctions of the product.
If a difficulty develops with this machine, you should contact the dealer from whom it was purchased.
This warranty gives you specific legal rights, and you may have other rights which vary from state to state. Some states do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long an implied warranty lasts, so the above exclusions and limitations may not apply to you.
World Headquarters Minuteman Canada, Inc. Minuteman International, Inc. 2210 Drew Road 111 South Rohlwing Road Mississauga, Ontario Addison, Illinois 60101 L5S 1B1
(630) 627-6900 (905) 673-3222 FAX (630) 627-1130 FAX (905) 673-5161
987215
Printed in U.S.A.
Loading...