Middleby Marshall Oven PS555-G Service Manual
PS555 Parts
Gas (Domestic & Std. Export)
PMD-15-002
Rev. B V1 9/00
PS555
USA & Std. Export
PS555 Gas Oven
PARTS MANUAL
for domestic and standard export ovens
© 2000 Middleby Marshall, Inc.
is a registered trademark of Middleby Marshall, Inc. All rights reserved.
Middleby Cooking Systems Group 1400 Toastmaster Drive Elgin, IL 60120 (847)741-3300 FAX (847)741-4406
1
USA & Std. Export
PS555
TABLE OF CONTENTS
Section Page
I. KEY SPARE PARTS KIT ....................................................................................................3
II. INSTALLATION KIT ............................................................................................................. 4
III. BASE PAD KIT ................................................................................................................... 4
IV. OVEN PANELS, WINDOW AND LEGS ..............................................................................6
V. CONTROL PANEL AND MACHINERY COMPARTMENT ...................................................8
VI. SIDE COMPARTMENTS ..................................................................................................10
VII. BLO WER ASSEMBLIES AND BLOWER MOTORS .........................................................12
VIII. GAS BURNER SYSTEM ................................................................................................... 14
IX. CONVEYOR ASSEMBLY, SINGLE-BELT OVENS ...........................................................16
X. CONVEYOR ASSEMBLY, SPLIT-BELT OVENS .............................................................. 18
NOTE: Throughout this Parts Manual, the following abbreviations are used:
A/R = Quantity As Required
N/A = Does Not Apply
WARNING
FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER
FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR
ANY OTHER APPLIANCE
WARNING
Improper installation, adjustment, alteration, service or maintenance
can cause property damage, injury or death. Read the installation,
operating and maintenance instructions thoroughly before install-
ing or servicing this equipment.
WARNING
DISCONNECT THE OVEN FROM ITS ELECTRICAL POWER SUPPLY
BEFORE SERVICING.
NOTICE
Using any parts other than genuine Middleby Marshall factory manufactured parts relieves
the manufacturer of all warranty and liability.
NOTICE
Middleby Marshall (Manufacturer) reserves the right to change specifications at any time.
2
I. KEY SPARE PARTS KIT
ITEM QTY. P/N DESCRIPTION
1 1 36939 KIT, DIGITAL TEMPERATURE CONTROL
2 1 27384-0008 MOTOR, DRIVE
PS555
USA & Std. Export
3 2 22450-0052 BRUSH, DRIVE MOTOR
4 1 37337 KIT, CONVEYOR SPEED CONTROLLER WITH DIGITAL DISPLAY
5 1 27170-0263 ASSEMBLY, PICKUP, DRIVE MOTOR
6 1 33984 KIT, THERMOCOUPLE
7 1 97525 FAN, COOLING
8 1 27381-0069 MOTOR, BLOWER, 1 HP
9 1 42810-0114 KIT, IGNITION MODULE
10 1 38811 BURNER BLOWER/MOTOR ASSEMBLY
11 1 41647 VALVE, MODULATING GAS, 1/2"
12 1 31651 AMPLIFIER, MODULATING VALVE
13 1 39530 AIR SWITCH
3
USA & Std. Export
PS555
INSTALLATION KIT
BASE PAD KIT
4
II. INSTALLATION KIT
ITEM BELT BELT P/N DESCRIPTION
1 1 1 43339 OWNERS OPERATING AND INSTALLATION MANUAL, PS555 OVEN
2 1 1 1002040 AAUTHORIZED SERVICE AGENCY LISTING/DISTRIBUTORS GUIDE
3 1 1 35900-0148 CONVEYOR REAR STOP
4 1 1 35000-1103 CONVEYOR END STOP
5 1 1 33120-0053 GAS PIPE NIPPLE
QTY. - SGL. QTY. - SPLIT
(DOMESTIC AND STANDARD EXPORT VERSIONS - ENGLISH)
III. BASE PAD KIT
ITEM QTY. QTY. - DBL. QTY. - DBL. QTY. QTY. P/N DESCRIPTION
1a 4 -- -- -- - - 37210-0060 LEG, 19 (483mm)
1b -- 4 - - -- - - 37210-0082 LEG, 10 (254mm)
1c -- -- 4 -- -- 37210-0057 LEG, 15 (381mm)
1d -- -- -- 4 (optional) -- 43158 LEG, 4" (102mm)
2 - - -- - - -- 4 37210-0054 OUTRIGGER
3 4 4 4 4 -- 37115-0102 CASTER, SWIVEL WITH 3/4" STUD
4 - - -- - - -- 2 22290-0010 CASTER, SWIVEL WITH PLATE (W/O BRAKE)
5 - - -- - - -- 2 22290-0009 CASTER, SWIVEL WITH PLATE & BRAKE
6 2 2 2 2 2 27271-0004 PIPE CLAMP, 1-1/2
7 2 2 2 2 2 33120-0055 NIPPLE, 1-14 DIA. X 3 L, NPT
8 2 2 2 2 2 23122-0007 ELBOW, 90°, 1-1/4 DIA.
9 1 1 1 1 1 22361-0003 GAS HOSE, 1-1/4 DIA. X 72 L
10 4 4 4 4 - - 22450-0028 LEG, 6" (152mm) ADJUSTABLE WITH 3/4" STUD
11 1 1 1 1 1 33120-0056 GAS PIPE, 1-1/4 DIA. X 54 L
12 1 1 1 1 1 22450-0253 RESTRAINT CABLE, 60 (1524mm)
13 1 1 1 1 1 21392-0005 EYE BOLT/LAG SCREW
14b 2 2 2 2 2 41582 TOP COVER (RIGHT OR LEFT), PS555
SINGLE OVEN W/ OVEN W/ TRIPLE QUAD
OVEN 10" LEGS 15" LEGS OVEN OVEN
PS555
USA & Std. Export
NOT SHOWN:
-- 1 1 1 1 1 41643 BASE PAD, PS555
-- 8 8 8 8 8 21256-0069 SCREW, SLT TRS HD #10-32 X 1-1/4
-- 2 2 2 2 2 21292-0001 SCREW, TEKS HWH #2PT #10-16 X 3/4
-- 16 16 16 -- 8 21216-0018 BOLT, HEX CAP 1/2"-13 X 1-1/4"
-- 16 16 16 -- 8 21416-0003 FLAT WASHER, 1/2
-- 16 16 16 -- 8 21426-0004 LOCK WASHER, 1/2
-- -- - - - - -- 16 220373 SCREW, HEX HD 3/8"-16 X 1"
-- - - -- -- -- 16 21416-0001 FLAT WASHER, 3/8
-- - - -- -- -- 16 21422-0001 LOCK WASHER, 3/8
5
MCSG 12/99
6
USA & Std. Export
PS555
Loading...