Middleby Marshall PS555, PS570S User Manual

PS500 Series Parts
Gas (Europe)

PME-15-001

Rev. B  V1  9/00

EUROPE

PS555 & PS570S

PS500 Series Gas Ovens

Models:

 PS555
 PS570S

PARTS MANUAL

for European export ovens

© 2000 Middleby Marshall, Inc.

is a registered trademark of Middleby Marshall, Inc. All rights reserved.

Middleby Cooking Systems Group  1400 Toastmaster Drive  Elgin, IL 60120  [phone]  FAX [phone]

1

PS555

EUROPE

Section Page

&

PS570S

I. KEY SPARE PARTS KIT ....................................................................................................3

II. INSTALLATION KIT ............................................................................................................. 4

III. BASE PAD KIT ................................................................................................................... 4

IV. OVEN PANELS, WINDOW AND LEGS .............................................................................. 6

V. CONTROL PANEL AND MACHINERY COMPARTMENT ...................................................8

VI. SIDE COMPARTMENTS ..................................................................................................10

VII. BLOWER ASSEMBLIES AND BLOWER MOTORS .........................................................12

VIII. GAS BURNER SYSTEM ...................................................................................................14

IX. CONVEYOR ASSEMBLY, SINGLE-BELT OVENS ...........................................................16

X. CONVEYOR ASSEMBLY, SPLIT-BELT OVENS .............................................................. 18

NOTE: Throughout this Parts Manual, the following abbreviations are used:

TABLE OF CONTENTS

A/R = Quantity As Required
N/A = Does Not Apply

WARNING

FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER

FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR

ANY OTHER APPLIANCE

WARNING

Improper installation, adjustment, alteration, service or maintenance

can cause property damage, injury or death. Read the installation,

operating and maintenance instructions thoroughly before install-

ing or servicing this equipment.

WARNING

DISCONNECT THE OVEN FROM ITS ELECTRICAL POWER SUPPLY

BEFORE SERVICING.

NOTICE

Using any parts other than genuine Middleby Marshall factory manufactured parts relieves

the manufacturer of all warranty and liability.

NOTICE

Middleby Marshall (Manufacturer) reserves the right to change specifications at any time.

2

EUROPE

PS555 & PS570S

I. KEY SPARE PARTS KIT

ITEM QTY. P/N DESCRIPTION

1 1 36939 KIT, DIGITAL TEMPERATURE CONTROL

2 1 27384-0008 MOTOR, DRIVE

3 2 22450-0052 BRUSH, DRIVE MOTOR

4 1 37337 KIT, CONVEYOR SPEED CONTROLLER WITH DIGITAL DISPLAY

5 1 27170-0263 ASSEMBLY, PICKUP, DRIVE MOTOR

6 1 33984 KIT, THERMOCOUPLE

7 1 97525 FAN, COOLING

8 1 27381-0069 MOTOR, BLOWER, 1 HP

9 1 35825 KIT, IGNITION MODULE

10 1 33983 HIGH LIMIT CONTROL MODULE, 240V

11 1 38811 BURNER BLOWER/MOTOR ASSEMBLY

12 1 41647 VALVE, MODULATING GAS, 1/2"

13 1 31651 AMPLIFIER, MODULATING VALVE

14 1 37498 AIR SWITCH

3

PS555

EUROPE

&

PS570S

INSTALLATION KIT

BASE PAD KIT

4

II. INSTALLATION KIT

QTY. - SGL. QTY. - SPLIT

ITEM BELT BELT P/N DESCRIPTION

1 1 1 43015 OWNERS OPERATING AND INSTALLATION MANUAL, PS500 SERIES OVENS

(EUROPEAN EXPORT VERSIONS)

2 1 1 1002040 AUTHORIZED SERVICE AGENCY LISTING/DISTRIBUTORS GUIDE

3 1 1 35900-0148 CONVEYOR REAR STOP

4 1 1 35000-1103 CONVEYOR END STOP

5 1 1 33120-0053 GAS PIPE NIPPLE

III. BASE PAD KIT

EUROPE

PS555 & PS570S

ITEM QTY. QTY. - DBL. QTY. - DBL. QTY. QTY. P/N DESCRIPTION

1a 4 -- -- -- - - 37210-0060 LEG, 483mm

1b -- 4 - - -- -- 37210-0082 LEG, 254mm

1c - - -- 4 - - -- 37210-0057 LEG, 381mm

1d -- -- -- 4 (optional) - - 43158 LEG, 102mm

2 - - -- -- -- 4 37210-0054 OUTRIGGER

3 4 4 4 4 - - 37115-0102 CASTER, SWIVEL WITH 3/4" STUD

4 - - -- -- -- 2 22290-0010 CASTER, SWIVEL WITH PLATE (W/O BRAKE)

5 - - -- -- -- 2 22290-0009 CASTER, SWIVEL WITH PLATE & BRAKE

6 2 2 2 2 2 27271-0004 PIPE CLAMP, 1-1/2

7 2 2 2 2 2 33120-0055 NIPPLE, 1-14 DIA. X 76mm L, NPT

8 2 2 2 2 2 23122-0007 ELBOW, 90°, 1-1/4 DIA.

9 1 1 1 1 1 22361-0003 GAS HOSE, 1-1/4 DIA. X 72 L

10 4 4 4 4 -- 22450-0028 LEG, 152mm, ADJUSTABLE WITH 3/4" STUD

11 1 1 1 1 1 33120-0056 GAS PIPE, 1-1/4 DIA. X 54 1372mm L

12 1 1 1 1 1 22450-0253 RESTRAINT CABLE, 1524mm

13 1 1 1 1 1 21392-0005 EYE BOLT/LAG SCREW

14a 2 2 2 2 2 42431 TOP COVER (RIGHT OR LEFT), PS570S

14b 2 2 2 2 2 41582 TOP COVER (RIGHT OR LEFT), PS555

NOT SHOWN:

-- 1 1 1 1 1 41714 BASE PAD, PS570S

-- 1 1 1 1 1 41643 BASE PAD, PS555

-- 8 8 8 8 8 21256-0069 SCREW, SLT TRS HD #10-32 X 1-1/4

-- 2 2 2 2 2 21292-0001 SCREW, TEKS HWH #2PT #10-16 X 3/4

-- 16 16 16 -- 8 21216-0018 BOLT, HEX CAP 1/2"-13 X 1-1/4"

-- 16 16 16 -- 8 21416-0003 FLAT WASHER, 1/2

-- 16 16 16 -- 8 21426-0004 LOCK WASHER, 1/2

-- -- -- -- -- 16 220373 SCREW, HEX HD 3/8"-16 X 1"

-- - - -- - - -- 16 21416-0001 FLAT WASHER, 3/8

-- - - -- - - -- 16 21422-0001 LOCK WASHER, 3/8

SINGLE OVEN W/ OVEN W/ TRIPLE QUAD

OVEN 10" LEGS 15" LEGS OVEN OVEN

5

MCSG 12/99

6

EUROPE

PS570S

&

PS555

IV. OVEN PANELS, WINDOW AND LEGS

ITEM QTY. P/ N DESCRIPTION ITEM QTY. P/ N DESCRIPTION

1 2 39539 ASSY, UPPER END PLUG (INC. ITEMS 2-7)

2 1 41778 WELDMENT, UPPER END PLUG PS500

3 1 41738 EYEBROW

4 2 220295 SCREW, "AB" HEX WSHR HD #10 X 3/4"

5 2 36452 WING NUT, 1/4"-20 W/PLASTIC GRIP

6 2 41708 PLATE, END PLUG MOUNTING

7 4 21292-0001 SCREW, TEKS HWH #2PT #10-16 X 3/4"

8 2 39569 ASSY, LOWER END PLUG (INC. ITEMS 9-12)

9 1 41779 WELDMENT, LOWER END PLUG PS500

10 2 36452 WING NUT, 1/4"-20 W/PLASTIC GRIP

11 2 41708 PLATE, END PLUG MOUNTING

12 4 21292-0001 STUD, SELF-CLINCHING 1/4"-20 X 1"

13 1 44494 ASSEMBLY, DRIVE MOTOR SHROUD

14 2 A6153 SCREW, HEX HD 1/4"-20 X 1/2"

15 1 44482 ASSEMBLY, LEFT MOTOR SHROUD

7

16 1 44483 ASSEMBLY, RIGHT MOTOR SHROUD

17 2 41679 ASSEMBLY, REAR SHROUD (INC. ITEMS 18-21)

18 1 31765 GRILL, COOLING FAN

19 2 4021D8905 BUMPER

20 1 4111A8813 SCREW, SLT TRS HD #10-32 X 1-1/4"

21 1 F707A8803 HEX NUT, #10-32

22 A/R 4111A8815 SCREW, HEX HD #10-32 X 1/2"

23a 2 42431 TOP COVER, PS570S

23b 2 41582 TOP COVER, PS555

24 8 21256-0069 SCREW, SLT TRS HD #10-32 X 1-1/4"

25a 2 42555 INSULATION, ROOF PRECUT PS570S

25b 2 42554 INSULATION, ROOF PRECUT PS555

26a 1 41768 WINDOW GUARD, PS570S

26b 1 42488 WINDOW GUARD, PS555

27 2 30927 BUMPER, WINDOW

28a 1 41714 BASE PAD, PS570S

28b 1 41643 BASE PAD, PS555

29 1 34121-0003 SCREW, WINDOW PIVOT

30 1 41627 ASSEMBLY, PS570S WINDOW WITH GLASS (IN-

CLUDES ITEMS 31-35)

31 1 41626 FRAME, LOWER DOOR

32 1 22140-0012 GLASS, WINDOW, PRE-CUT

33 1 41630 FRAME, UPPER DOOR

34 1 41790 ASSEMBLY, WINDOW LATCH (INC. ITEM 35)

35 2 19A1S144 SCREW, HEX HD #10-32 X 1-1/4"

36a 1 42542 WELDMENT - PS555 HATCH, HANDLE, & PIVOT PIN

36b 1 44485 WELDMENT - PS555 WINDOW WITH HATCH, HANDLE,

& PIVOT PIN

37 1 41587 GLASS, WINDOW, PRE-CUT

38 1 41790 ASSEMBLY, WINDOW LATCH (INC. ITEM 34)

39 2 19A1S144 SCREW, HEX HD #10-32 X 1-1/4"

40a 4 37210-0060 LEG, 483mm - SINGLE OVEN

40b 4 37210-0057 LEG, 381mm - DOUBLE OVEN

40c 4 37210-0082 LEG, 254mm - DOUBLE OVEN

40d 4 43158 LEG, 102mm - OPTIONAL FOR TRIPLE OVEN

41 16 21216-0018 BOLT, HEX CAP 1/2"-13 X 1-1/4" - SINGLE & DOUBLE

OVENS

42 16 21426-0004 LOCKWASHER, 1/2" - SGL & DBL OVENS

43 16 21416-0003 FLAT WASHER, 1/2" - SGL & DBL OVENS

44 4 37115-0102 CASTER, SWIVEL WITH 3/4" STUD - SINGLE, DOUBLE,

& TRIPLE OVENS

45 4 22450-0028 LEG, 152mm ADJUSTABLE WITH 3/4" STUD - SINGLE,

DOUBLE, & TRIPLE OVENS

46 4 37210-0054 OUTRIGGER - QUAD OVEN

47 8 21216-0018 BOLT, HEX CAP 1/2"-13 X 1-1/4" - QUAD OVENS

48 8 21426-0004 LOCKWASHER, 1/2" - QUAD OVENS

49 8 21416-0003 FLAT WASHER, 1/2" - QUAD OVENS

50a 2 22290-0009 CASTER, SWIVEL WITH FLAT MOUNTING PLATE

AND BRAKE - QUAD OVENS, FRONT

50b 2 22290-0010 CASTER, SWIVEL WITH FLAT MOUNTING PLATE

(WITHOUT BRAKE) - QUAD OVENS, REAR

51 16 220373 SCREW, HEX HD 3/8"-16 X 1" - QUAD OVENS

52 16 21422-0001 LOCKWASHER, 3/8" - QUAD OVENS

53 16 21416-0001 FLAT WASHER, 3/8" - QUAD OVENS

PS555 & PS570S

EUROPE

MCSG 12/99

8

EUROPE

PS570S

&

PS555

V. CONTROL PANEL AND MACHINERY COMPARTMENT

ITEM QTY. P/N DESCRIPTION ITEM QTY. P/N DESCRIPTION

1a 1 39467 MACHINERY COMPARTMENT ACCESS

PANEL, PS570S, WITHOUT COMPONENTS

1b 1 41581 MACHINERY COMPARTMENT ACCESS

PANEL, PS555, WITHOUT COMPONENTS

2 1 42977 LABEL, WIRING DIAGRAM

3 1 39464 LABEL, CONTROL PANEL

4 1 22500-0194 LABEL, IGNITION RESET SWITCH

5 1 22500-0021 NAMEPLATE, "MIDDLEBY MARSHALL"

6 2 A6153 SCREW, HEX HD 1/4"-20 X 1/2"

7 2 97525 COOLING FAN

8 1 44421 TRANSFORMER, 240Vp:24Vs 0.5 KVA

9

9 1 37498 AIR SWITCH

10 1 39052 KIT, IGNITION MODULE

11 1 31651 AMPLIFIER, MODULATING VALVE

12 3 42503 CONTACT BLOCK WITH BASE

13 1 28201-0016 SWITCH, LIGHTED IGNITION RESTART

14 3 37168 SELECTOR SWITCH WITH KNOB

-- 1 37337 KIT, CONVEYOR SPEED CONTROLLER WITH
SELECTOR AND DIGITAL DISPLAY (INC. ITEMS

15-16)

15 1 37504 SPEED CONTROL MODULE ONLY

16 1 37503 DIGITAL DISPLAY

17 1 36939 KIT, DIGITAL TEMPERATURE CONTROLLER

18 1 31504 TRANSFORMER, 230Vp:120Vs 0.2 KVA

19 2 28021-0047 SAFETY SWITCH, MACHINERY COMPART-

MENT ACCESS PANEL

20 1 42501 CIRCUIT BREAKER, 2A

21 2 27470-0004 GRILL, COOLING FAN

NOT SHOWN:

-- 2 37842 FILTER, FOAM, COOLING FAN

-- 2 33984 KIT, THERMOCOUPLE

PS555 & PS570S

EUROPE

MCSG 12/99

10

EUROPE

PS570S

&

PS555

LEFT SIDE

RIGHT SIDE

VI. SIDE COMPARTMENTS

ITEM QTY. P/N DESCRIPTION

1 1 44463 ELECTRICAL JUNCTION BOX

2 1 44392 COVER, ELECTRICAL JUNCTION BOX

3 2 4111A8815S SCREW, HEX HD #10-32 X 1/2"

4 2 44390 TERMINAL BLOCK, 3-POLE

5 1 31589 GROUND LUG

6 1 33412 STRAIN RELIEF

7 1 36430 ASSEMBLY, EQUIPOTENTIAL GROUND (IN-

CLUDES ITEM 8)

8 1 36244 LABEL, EQUIPOTENTIAL GROUND

9 1 33813 RFI FILTER

10 1 43188 MOUNTING BRACKET, RFI FILTER

11

11 1 33983 HIGH LIMIT CONTROL MODULE, 240V

12 1 35145 RESET BUTTON, HIGH LIMIT, 240V

13 2 42501 CIRCUIT BREAKER, 2A

14 4 41835 CIRCUIT BREAKER, 15A

ITEM QTY. P/N DESCRIPTION

15 1 28041-0011 CONTACTOR

16 2 37498 AIR SWITCH

17 A/R 22450-0297 TUBING, SILICONE BULK 1/4"/6.4mm O.D.

18 A/R 15125-0002 TUBING, ALUMINUM BULK 1/4"/6.4mm O.D.

19 2 28021-0047 SAFETY SWITCH, BLOWER MOTOR SHROUD

20a 2 44469 ASSEMBLY, START CAPACITOR (BLACK) -

INCLUDES BRACKET AND END CAP

20b 2 27170-0269 START CAPACITOR (BLACK) - WITHOUT

BRACKET OR END CAP

21 2 27170-0270 CAPACITOR, RUN (SILVER)

22 2 44465 INSULATOR CAP, RUN CAPACITOR

23 4 22450-0259 HOSE CLAMP

24 2 41668 MOUNTING BRACKET, SIDE COMPARTMENT

COMPONENTS

25 2 43102 MOUNTING BRACKET, BLOWER MOTOR

SHROUD, TOP

26 2 43126 MOUNTING BRACKET, BLOWER MOTOR

SHROUD, BOTTOM

PS555 & PS570S

EUROPE

MCSG 12/99

12

EUROPE

PS570S

&

PS555

VII. BLOWER ASSEMBLIES AND BLOWER MOTORS

NOTE: The quantities shown below are for a single blower assembly.

ITEM QTY. P/N DESCRIPTION

1a 1 22521-0005 BLOWER WHEEL - CCW, DRIVE END

1b 1 22521-0006 BLOWER WHEEL - CW, IDLER END

2 1 37210-0124 PLATE, INLET RING

3 4 21211-0001 SCREW, CAP HEX HD 3/8"-16 X 3"

4 4 21416-0001 FLAT WASHER, 3/8"

5 4 21422-0001 LOCKWASHER, SPLIT, 3/8"

6 4 35210-0576 SPACER

7 1 35210-0541 SHAFT SEAL, TEFLON

8 1 37210-0101 PLATE, SHAFT SEAL INNER

9 4 21292-0001 SCREW, HEX WSHR HD #10-16 X 3/4"

13

10 2 35000-1622 HANGER, REAR SHROUD

11 4 21292-0001 SCREW, HEX WSHR HD #10-16 X 3/4"

12 1 41899 SHAFT, BLOWER

13 1 35210-0286 KEY, BLOWER WHEEL

14 2 22072-0017 BEARING

15 4 39411 SPACER, BEARING

16 4 21322-0014 SCREW, CAP HEX HD 1/2"-13 X 3-1/2"

17 4 A6235 FLAT WASHER, 7/16"

18 4 21121-0013 HEX NUT, 1/2"-13

19 1 39587 PULLEY, BK70

ITEM QTY. P/N DESCRIPTION

20 1 22031-0018 BUSHING, SPLIT, 1-7/16" I.D. (INC. KEY AND 2

BOLTS)

21a 1 42498 BELT, B68 (PS570S)

21b 1 42662 BELT, B62 (PS555)

22 12 1513D8805 SCREW, CAP HEX HD 3/8"-16 X 3/4"

23 10 21422-0001 LOCKWASHER, SPLIT 3/8"

24 10 21416-0001 FLAT WASHER, 3/8"

25 1 27381-0069 MOTOR, BLOWER, 1 HP

26 1 41666 BRACKET, MOTOR MOUNTING

27 4 A3896 SCREW, CAP HEX HD 5/16"-18 X 1"

28 8 3023A8807 FLAT WASHER, 5/16"

29 4 21421-0004 LOCKWASHER, SPLIT 5/16"

30 4 B10012 HEX NUT, 5/16"-18

31a 1 39587 PULLEY, BK70

31b 1 39586 PULLEY, BK80

32 1 220026 KEY, PULLEY 3/16" x 3/16" X 3/4" (5x5x19mm)

33 1 43024 EXTENDER, FAN

34a 1 27399-0008 FAN BLADE, CW

34b 1 27399-0009 FAN BLADE, CCW

35 1 41667 BRACKET, MOTOR SUPPORT

PS555 & PS570S

EUROPE

MCSG 12/99

14

EUROPE

PS570S

&

PS555

VIII. GAS BURNER SYSTEM

ITEM QTY. P/N DESCRIPTION ITEM QTY. P/N DESCRIPTION

-- 1 38126 ASSEMBLY, BURNER (INCLUDES ITEMS 1-13)

1 1 38811 ASSEMBLY, BURNER BLOWER AND MOTOR

2 1 -- BLOWER AND MOTOR

3 1 42810-0087 KIT, EXTERNAL AIR SHUTTER

4 1 42400-0640 KIT, PITOT TUBE

5 1 38127 VENTURI

6 1 42810-0117 PILOT WITH IGNITOR

7 1 27170-0204 PILOT SHIELD

8 1 27170-0264 BRACKET, PILOT MOUNTING

9 1 38284 FITTING, PILOT TUBING

10 A/R 15125-0002 TUBING, ALUMINUM, 1/4"/6.4mm O.D.

15

11 1 36920 FITTING, BULKHEAD

12 1 38279 ORIFICE HOLDER/INLET CONNECTOR

13 1 38280 WINDOW PLUG

14a 1 43059 MAIN ORIFICE, PS555 NATURAL GAS, 5.79mm

14b 1 43060 MAIN ORIFICE, PS555 PROPANE, 3.58mm

14a 1 22176-0014 MAIN ORIFICE, PS570S NATURAL GAS, 6.35mm

14b 1 22176-0015 MAIN ORIFICE, PS570S PROPANE, 3.84mm

(INCLUDES ITEMS 2-4)

15a 1 22174-0011 PILOT ORIFICE, NATURAL GAS, 0.635mm

15b 1 22174-0010 PILOT ORIFICE, PROPANE, 0.381mm

16 1 39582 BRACKET, MOTOR MOUNTING

17 2 22450-0259 HOSE CLAMP

18 1 37210-0026 BRACKET, HOSE AND BURNER MOUNTING

19 1 22450-0255 AIR DUCT, FLEXIBLE

20 A/R 38290 TUBING, SILICONE RUBBER, 1/4"/6.4mm DIA.

21 1 27159-0019 IGNITION/SENSOR WIRE

22 1 30185 KIT, PILOT TEE 1/4"/6.4mm

23 A/R 15125-0002 TUBING, ALUMINUM, 1/4"/6.4mm O.D.

24 1 41647 VALVE, MODULATING GAS, M420, 1/2"

25 1 28092-0020 MULTIFUNCTION GAS VALVE

26 1 23115-0009 VALVE, SHUTOFF 1/2"

27 1 41649 BRACKET, PIPE MOUNTING 1-1/4"

28 1 23051-0003 UNION, PIPE 1/2"

29 1 23051-0012 UNION, PIPE 1-1/4"

PS555 & PS570S

EUROPE

MCSG 12/99

16

EUROPE

PS570S

&

PS555

IX. CONVEYOR - SINGLE-BELT OVENS

ITEM QTY. P/N DESCRIPTION ITEM QTY. P/N DESCRIPTION

1a 1 39580 WELDMENT, CONVEYOR DRIVE FRAME, PS570S

1b 1 42518 WELDMENT, CONVEYOR DRIVE FRAME, PS555

2 1 37210-0046 WELDMENT, CONVEYOR CENTER FRAME

3a 1 39581 WELDMENT, CONVEYOR IDLER FRAME, PS570S

3b 1 42518 WELDMENT, CONVEYOR IDLER FRAME, PS555

4 2 27413-0002 PLUG, 3/4" (19mm) DIA. (PS555 ONLY)

5 4 35210-0429 PIVOT PLATE

6 8 35210-0491 BUSHING, CONVEYOR ADJUSTMENT

7 8 F716A8805 WASHER, EXTERNAL TOOTH 1/4"

8 8 21176-0001 LOCKNUT, HEX 1/4"-20

9a 1 22450-0265 CONVEYOR BELT, PS570S COMPLETE, 32"W x 204"L (0.81

17

9b 1 22450-0002 CONVEYOR BELT, PS555 COMPLETE, 32"W x 174"L (0.81 X

9c -- 33900-0032 CONVEYOR BELT, 32"W x 12"L (0.81 X 0.30m)

10 1 42400-0089 MASTER LINKS KIT, 32" (0.81m) BELT (INC. ITEMS 11-13)

11 1 - - MASTER LINK, LEFT

12 4 -- MASTER LINK, CENTER

13 1 -- MASTER LINK, RIGHT

14 1 35000-1011 SHAFT, IDLER

15 6 22229-0003 SPROCKET, CONVEYOR BELT (INC. ITEM 16)

16 6 21276-0039 SET SCREW, CONVEYOR BELT SPROCKET, 1/4"-28 X 3/

17 2 22034-0003 BUSHING, BRONZE 3/4" O.D. X 5/8" I.D.

18 2 37000-0413 BRACKET, IDLER SHAFT ADJUSTMENT

19 2 35000-1008 SCREW, CONVEYOR TENSION ADJUSTMENT

20 2 35900-0020 BRACKET, SHAFT SUPPORT

21 1 35000-1012 SHAFT, DRIVE

X 5.18m)

4.42m)

8" (INC. WITH ITEM 15)

22 6 22229-0003 SPROCKET, CONVEYOR BELT (INC. ITEM 23)

23 6 21276-0039 SET SCREW, CONVEYOR BELT SPROCKET, 1/4"-28 X 3/

8" (INC. WITH ITEM 22)

24 1 22011-0013 COLLAR, SHAFT, WITH SET SCREW

25 2 22034-0003 BUSHING, BRONZE 3/4" O.D. X 5/8" I.D.

26 2 35000-1080 SPACER, NYLON 1-1/4" O.D. X 3/4" I.D.

27 2 35900-0020 BRACKET, SHAFT SUPPORT

28 1 35000-1013 ADAPTER, DRIVE SHAFT

29 1 22152-0017 SPROCKET, DRIVE SHAFT, 5/8" BORE, 9T, WITH SET SCREW

30 1 42400-0164 ASSEMBLY, ROLLER CHAIN COMPLETE (62 LINKS)

31 1 22273-0001 MASTER LINK, ROLLER CHAIN

32 1 22152-0018 SPROCKET, DRIVE MOTOR, 5/8" BORE, 15T, WITH SET

SCREW

33 1 35210-0640 ADAPTER, DRIVE MOTOR, WITH SET SCREW

34 1 42400-0414 ASSEMBLY, DRIVE MOTOR AND PICKUP (INC. ITEMS 35-36)

35 1 27384-0008 DRIVE MOTOR, 1/8 HP, 1400:1

-- 2 22450-0052 BRUSHES, DRIVE MOTOR

36 1 27170-0263 ASSEMBLY, PICKUP, DRIVE MOTOR

37 4 21411-0003 FLAT WASHER, 1/4"

38 4 21426-0002 LOCKWASHER, 1/4"

39 4 21126-0009 HEX NUT, 1/4"-20

40 1 35000-1103 END STOP, CONVEYOR

41 1 35900-0148 REAR STOP, CONVEYOR

42a 2 30003 CRUMB PAN , ALUMINIZED (WITHOUT OPENINGS - FOR

LOWER OVEN CAVITY ONLY)

42b 2 35210-0262 CRUMB PAN, STAINLESS STEEL (WITHOUT OPENINGS -

FOR LOWER OVEN CAVITIES ONLY)

43a 2 30004 CRUMB PAN, ALUMINIZED (WITH OPENINGS - FOR ALL

UPPER OVEN CAVITIES)

43b 2 35210-0179 CRUMB PAN, STAINLESS STEEL (WITH OPENINGS - FOR

ALL UPPER OVEN CAVITIES)

PS555 & PS570S

EUROPE

MCSG 12/99

18

EUROPE

PS570S

&

PS555

X. CONVEYOR - SPLIT-BELT OVENS

ITEM QTY. P/N DESCRIPTION ITEM QTY. P/N DESCRIPTION

1a 1 39580 WELDMENT, CONVEYOR DRIVE FRAME, PS570S

1b 1 42518 WELDMENT, CONVEYOR DRIVE FRAME, PS555

2 1 37210-0046 WELDMENT, CONVEYOR CENTER FRAME

3a 1 39581 WELDMENT, CONVEYOR IDLER FRAME, PS570S

3b 1 42518 WELDMENT, CONVEYOR IDLER FRAME, PS555

4 2 27413-0002 PLUG, 3/4" (19mm) DIA. (PS555 ONLY)

5 4 35210-0429 PIVOT PLATE

6 8 35210-0491 BUSHING, CONVEYOR ADJUSTMENT

7 8 F716A8805 WASHER, EXTERNAL TOOTH 1/4"

8 8 21176-0001 LOCKNUT, HEX 1/4"-20

9a 2 22450-0271 CONVEYOR BELT, PS570S COMPLETE, 15"W x 204"L (0.38

9b 2 22450-0094 CONVEYOR BELT, PS555 COMPLETE, 15"W x 174"L (0.38 X

19

9c -- 33900-0037 CONVEYOR BELT, 15"W x 12"L (0.38 X 0.30m)

10 2 NOT AVAILABLE MASTER LINKS KIT, 15" (0.38m) BELT (INC. ITEMS 11-13)

11 1 - - MASTER LINK, LEFT

12 1 -- MASTER LINK, CENTER

13 1 -- MASTER LINK, RIGHT

14 1 42400-0354 SHAFT, IDLER, REAR

15 1 21415-0001 FLAT WASHER, BRONZE, 1" O.D. X 1/2" I.D.

16 1 35000-1535 SHAFT, IDLER, FRONT

17 8 22229-0003 SPROCKET, CONVEYOR BELT (INC. ITEM 18)

18 8 21276-0039 SET SCREW, CONVEYOR BELT SPROCKET, 1/4"-28 X 3/

19 2 22034-0003 BUSHING, BRONZE 3/4" O.D. X 5/8" I.D.

20 2 37000-0413 BRACKET, IDLER SHAFT ADJUSTMENT

21 2 35000-1008 SCREW, CONVEYOR TENSION ADJUSTMENT

22 2 35900-0020 BRACKET, SHAFT SUPPORT

23 1 42400-0355 SHAFT, DRIVE, REAR

24 1 21415-0001 FLAT WASHER, BRONZE, 1" O.D. X 1/2" I.D.

X 5.18m)

4.42m)

8" (INC. WITH ITEM 17)

25 1 35000-1536 SHAFT, DRIVE, FRONT

26 8 22229-0003 SPROCKET, CONVEYOR BELT (INC. ITEM 27)

27 8 21276-0039 SET SCREW, CONVEYOR BELT SPROCKET, 1/4"-28 X 3/

8" (INC. WITH ITEM 26)

28 1 22011-0014 COLLAR, SPLIT LOCKING

29 2 22034-0003 BUSHING, BRONZE 3/4" O.D. X 5/8" I.D.

30 2 35000-1080 SPACER, NYLON 1-1/4" O.D. X 3/4" I.D.

31 2 35900-0020 BRACKET, SHAFT SUPPORT

32 1 35000-1537 BUSHING, SPLIT BELT DRIVE SPROCKET

33 2 22152-0017 SPROCKET, DRIVE SHAFT, 5/8" BORE, 9T, WITH SET SCREW

34 1 42400-0164 ASSEMBLY, ROLLER CHAIN COMPLETE (62 LINKS)

35 1 42410-0128 ASSEMBLY, ROLLER CHAIN COMPLETE (48 LINKS)

36 2 22273-0001 MASTER LINK, ROLLER CHAIN

37 2 22152-0018 SPROCKET, DRIVE MOTOR, 5/8" BORE, 15T, WITH SET

SCREW

38 1 35210-0640 ADAPTER, DRIVE MOTOR, WITH SET SCREW

39 2 42400-0414 ASSEMBLY, DRIVE MOTOR AND PICKUP (INC. ITEMS 40-41)

40 1 27384-0008 DRIVE MOTOR, 1/8 HP, 1400:1

-- 2 22450-0052 BRUSHES, DRIVE MOTOR

41 1 27170-0263 ASSEMBLY, PICKUP, DRIVE MOTOR

42 8 21411-0003 FLAT WASHER, 1/4"

43 8 21426-0002 LOCKWASHER, 1/4"

44 8 21126-0009 HEX NUT, 1/4"-20

45 1 35000-1103 END STOP, CONVEYOR

46 1 35900-0148 REAR STOP, CONVEYOR

47a 2 30003 CRUMB PAN , ALUMINIZED (WITHOUT OPENINGS - FOR

LOWER OVEN CAVITY ONLY)

47b 2 35210-0262 CRUMB PAN, STAINLESS STEEL (WITHOUT OPENINGS -

FOR LOWER OVEN CAVITIES ONLY)

48a 2 30004 CRUMB PAN, ALUMINIZED (WITH OPENINGS - FOR ALL

UPPER OVEN CAVITIES)

48b 2 35210-0179 CRUMB PAN, STAINLESS STEEL (WITH OPENINGS - FOR

ALL UPPER OVEN CAVITIES)

PS555 & PS570S

EUROPE

PS555

EUROPE

WARNING

&

PS570S

Improper installation, adjustment, alteration, service or maintenance

can cause property damage, injury or death. Read the installation,

operating and maintenance instructions thoroughly before

installing or servicing this equipment.

NOTICE

During the warranty period, ALL parts replacement and servicing should be performed by

your Middleby Marshall Authorized Service Agent. Service that is performed by parties

other than your Middleby Marshall Authorized Service Agent may void your warranty.

NOTICE

Using any parts other than genuine Middleby Marshall factory manufactured parts relieves

the manufacturer of all warranty and liability.

NOTICE

Middleby Marshall reserves the right to change specifications at any time.

Middleby Cooking Systems Group  1400 Toastmaster Drive  Elgin, IL 60120  USA  [phone]  FAX [phone]

24-Hour Service Hotline: [phone]

www .middleby.com

20