Page 1
A MIDDLEBY COMPANY
parts
manual
PS200/220/224VL Gas, Eng (CE)
MODEL PS200/220/
224VL GAS OVEN
(CE version)
P/N 38540
Rev. B V1 9/98
Page 2
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE
OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN
THE VICINITY OF THIS OR ANY OTHER APPLIANCE
WARNING
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or
death. Read the installation, operating and maintenance
instructions thoroughly before installing
or servicing this equipment.
WARNING
DISCONNECT THE OVEN FROM ITS ELECTRICAL POWER
SUPPLY BEFORE SERVICING.
NOTICE
Using any parts other than genuine Middleby Marshall factory
manufactured parts relieves the manufacturer of all warranty and liability.
NOTICE
Middleby Marshall (Manufacturer) reserves the right to change specifications at any time.
2
Page 3
TABLE OF CONTENTS
Section Page
Key Spare Parts Kit .................................................................................................................... 4
Installation Kit .............................................................................................................................. 5
Oven Base/Legs/Casters Kit ....................................................................................................... 5
Standard Air Fingers ................................................................................................................... 6
Oven Panels, Windows, and Legs ............................................................................................... 8
Cool Front ................................................................................................................................. 10
Blower, Shrouds and Vents .......................................................................................................12
Control Panel .................................................................................................................. .......... 14
Machinery Compartment .......................................................................................................... .16
Gas Burner System ................................................................................................................... 18
Conveyor Assembly - Single Conveyor ...................................................................................... 20
Conveyor Assembly - Split Belt Conveyor .................................................................................. 22
NOTE: Throughout this Parts Manual, the following abbreviations are used:
A/R = Quantity As Required
N/A = Does Not Apply
3
Page 4
PARTS LIST FOR KEY SPARE PARTS KIT
ITEM PART NO. QTY. DESCRIPTION
1 27381-0066 1 BLOWER/FAN MOTOR
2 27384-0011 1 CONVEYOR DRIVE MOTOR
3 42810-0133 1 CONVEYOR SPEED CONTROLLER
4 33985 1 THERMOCOUPLE
5 22450-0230 2 BRUSH, CONVEYOR DRIVE MOTOR
6 30876 1 SOLENOID VALVE
7 27170-0287 1 BURNER MOTOR/BLOWER ASSEMBLY
8 35825 1 KIT, IGNITION MODULE
9 27170-0263 1 CONVEYOR CONTROL PICKUP
10 33983 1 HIGH LIMIT CONTROL
KEY SPARE PARTS KIT
FIGURE 1
4
Page 5
PARTS LIST FOR INSTALLATION KIT
ITEM PART NO. QTY. DESCRIPTION
PS200VL PS220VL PS224VL Sgl oven Dbl oven
1 22361-0001 22361-0001 22361-0001 1 2 GAS HOSE, FLEXIBLE
2 23115-0010 23115-0010 23115-0010 1 2 GAS SHUTOFF VALVE, 3/4
3 35000-1103 35900-0370 35900-0442 1 2 CONVEYOR END STOP
4 35900-0148 35900-0376 35900-0148 1 2 CONVEYOR REAR STOP
5 30711 30711 30711 1 2 O-OI MANUAL, PS200 SERIES, ENG/GER (CE)
5 30712 30712 30712 1 2 O-OI MANUAL, PS200 SERIES, SPN/ITL (CE)
5 30713 30713 30713 1 2 O-OI MANUAL, PS200 SERIES, FRN/FLM (CE)
-- 37318 37318 37318 A/R A/R O-OI SUPPLEMENT (ANALOG), ENG/GER (CE)
-- 38333 38333 38333 A/R A/R O-OI SUPPLEMENT (DIGITAL), ENG/GER (CE)
6 1002040 1002040 1002040 1 2 SERVICE AGENCY DIRECTORY
7A 42400-0089 49400-0197 42400-0090 1 2 MASTER LINKS KIT - SINGLE BELT OVENS
7B 42400-0089 36596 42400-0589 2 4 MASTER LINKS KIT - SPLIT BELT OVENS
PARTS LIST FOR OVEN BASE/LEGS/CASTERS KIT
ITEM PART NO. QTY. DESCRIPTION
PS200VL PS220VL PS224VL Sgl oven Dbl oven
1 30427 30806 30807 1 1 BASE PAD, PAINTED
2 30426 30426 30426 4 --
3 22450-0028 22450-0028 22450-0028 4 4 LEG, 6 (152mm), ADJUSTABLE
4 220373 220373 220373 16 -- 3/8-16 x 1 HEX BOLT
5 21416-0001 21416-0001 21416-0001 16 -- 3/8 FLAT WASHER
6 21422-0001 21422-0001 21422-0001 16 -- 3/8 SPLIT WASHER
7 21256-0008 21256-0008 21256-0008 4 4 10-32 x 3/8 RH SCREWS FOR TOP
8 37900-0041 37900-0041 37900-0041 -- 1 FLUE OFFSET - DOUBLE OVENS ONLY
9 37900-0042 37900-0042 37900-0042 -- 1 FLUE EXTENSION - DOUBLE OVENS ONLY
-- 35900-0011 35900-0347 35900-0413 1 1 OVEN TOP
LEG EXTENSION, 15 (381mm), PAINTED -
SINGLE OVENS ONLY
INSTALLATION KIT
FIGURE 2
OVEN BASE/LEGS/CASTERS KIT
FIGURE 3
5
Page 6
M3
Air Finger
A = 49400-0266
B = 37000-0577
C = 37900-0050
M3
Air Finger
A = 49400-0266
B = 37000-0577
C = 37900-0050
Full Blank Plate
35900-0106
Full Blank Plate
35900-0106
Product Direction
6
A = 49400-0266
B = 37000-0577
C = 37900-0051
M6
Air Finger
A = 49400-0266
B = 37000-0577
C = 37900-0051
M6
Air Finger
A = 49400-0266
B = 37000-0577
C = 37900-0051
M6
Air Finger
A = 49400-0266
B = 37000-0577
C = 37900-0051
M6
Air Finger
NOTE: RIGHT-TO-LEFT product direction is a mirror image.
NOTE: The standard finger arrangement is shown. Some ovens are equipped with custom
arrangements. Consult the label inside the machinery compartment.
STANDARD AIR FINGERS
FIGURE 4
Page 7
PARTS LIST FOR AIR FINGERS - STANDARD ARRANGEMENT FOR UPPER AND LOWER OVENS
Upper Air Fingers
7
Lower Air Fingers
Page 8
8
FIGURE 5
OVEN PANELS, WINDOW,
AND LEGS
Page 9
PARTS LIST FOR OVEN PANELS, WINDOW AND LEGS
PART NO.
ITEM QTY. PS200VL PS220VL PS224VL DESCRIPTION
1 2 34991 38394 35377 UPPER END PLUG
2 2 21296-0003 21296-0003 21296-0003 WING SCREW, 1/4-20 x 1/2 SS
3 2 35900-0052 35900-0355 35900-0431 EYEBROW, ADJUSTABLE - OPTIONAL
4 4 2000346 2000346 2000346 SCREW, SLT 1/4-20 x 1/2
5 2 35900-0041 35900-0323 35900-0417 END PLUG, LOWER
6 2 21296-0003 21296-0003 21296-0003 WING SCREW, 1/4-20 x 1/2 SS
7 8 49400-0056 49400-0056 49400-0056 MOUNTING BRACKET - END PLUG
8 A/R 21292-0001 21292-0001 21292-0001 SCREW, 10-16 x 3/4" HEX HD
9 4 35900-0043 35900-0043 35900-0043 SHELF BRACKET - UPPER END PLUG
10 1 30743 30743 30743 CHAIN GUARD
11 1 35900-0011 35900-0347 35900-0413 OVEN TOP
12 4 21256-0025 21256-0025 21256-0025 SCREW, 10-32 x 3/8" SS
13 1 49400-0120 49400-0120 49400-0120 WINDOW ASSEMBLY
9
14 1 37900-0103 37900-0103 37900-0103 WINDOW MOUNTING FRAME
15 1 42400-0087 42400-0087 42400-0087 WINDOW LATCH ASSEMBLY
16 2 34121-0003 34121-0003 34121-0003 SCREW, THUMB PIVOT
17 1 30285 30285 30285 GLASS DOOR ASSEMBLY
18 1 22140-0017 22140-0017 22140-0017 TEMPERED GLASS
19 11 oz. 17130-0006 17130-0006 17130-0006 SEALANT, SILICONE RUBBER
20 1 30287 30287 30287 GLASS DOOR FRAME WELDMENT
21 1 30286 30286 30286 GLASS TOP FRAME
22 1 30427 30806 30807 BASE PAD, PAINTED
23 4 30426 30426 30426 LEG EXTENSION, PAINTED - SINGLE OVENS ONLY
24 4 22450-0028 22450-0028 22450-0028 LEG, 6 (152mm), ADJUSTABLE
25 A/R 21416-0001 21416-0001 21416-0001 WASHER, 3/8 FLAT
26 A/R 21422-0001 21422-0001 21422-0001 WASHER, 3/8 SPLIT
27 A/R 220373 220373 220373 BOLT, 3/8-16 x 1 HEX HD
28 1 22500-0021 22500-0021 22500-0021 PLATE, NAME, MIDDLEBY MARSHALL
29 4 220311 220311 220311 SCREW, 10-32 x 3/8
30 1 -- -- -- LABEL, OPERATING INSTRUCTIONS, PS200VL GAS
31 3 30631 30631 30631 LABEL, CAUTION - HOT SURFACE (CE)
Page 10
10
FIGURE 6A
COOL FRONT-
WITH WINDOW OPENING
FIGURE 6B
COOL FRONT-
WITHOUT WINDOW OPENING
Page 11
PARTS LISTS FOR COOL FRONT
COOL FRONT WITH WINDOW OPENING
ITEM QTY. PART NO. DESCRIPTION
- 1 37329 ASSEMBLY, PS200VL COOL FRONT/WITH WINDOW OPENING
1 4 220311 SCREW, 10-32 x 3/8
2 1 22500-0021 PLATE, NAME, MIDDLEBY MARSHALL
3 1 37336 PANEL, COOL FRONT/WITH WINDOW OPENING
4 4 21442-0005 LOCK WASHER
5 4 F707A8803 HEX NUT, 10-32, NP
COOL FRONT WITHOUT WINDOW OPENING
ITEM QTY. PART NO. DESCRIPTION
11
- 1 35944 ASSEMBLY, PS200VL COOL FRONT/NO WINDOW OPENING
6 8 220311 SCREW, 10-32 x 3/8
7 1 22500-0021 PLATE, NAME, MIDDLEBY MARSHALL
8 1 35926 PANEL, COOL FRONT/NO WINDOW OPENING
9 8 21442-0005 LOCK WASHER
10 8 F707A8803 HEX NUT, 10-32, NP
11 2 35470 BRACKET, CENTER SUPPORT, FOR COOL FRONT PANEL
12 8 21292-0001 SCREW, 10-16 x 3/4
13 4 35900-0259 HANGER, COOL FRONT PANEL
Page 12
12
FIGURE 7
BLOWER, SHROUDS, AND VENTS
Page 13
13
PARTS LIST FOR BLOWER, SHROUDS, AND VENTS
ITEM QTY. PART NO. DESCRIPTION
1 1 27399-0003 FAN, 16 (406mm) DIA.
2 A/R 21326-0002 BOLT, 3/8-16 x 5-1/2 HEX HD SS
3 A/R 21422-0001 WASHER, 3/8 SPLIT SS
4 A/R 21416-0001 WASHER, 3/8 FLAT SS
5 1 22450-0217 RING SHROUD
6 8 35900-0108 STAND-OFF TUBE
7 1 21651-0010 KEY, PULLEY
8 1 35900-0232 SHAFT, FAN DRIVE
9 1 37900-0088 BACK WALL
10 2 35900-0259 HANGER BRACKET, REAR SHROUD
11 A/ R 21292-0001 SCREW, 10-16 x 3/4 HEX HD
12 2 22072-0025 BEARING, PILLOW BLOCK, 5/8
13 24 21216-0001 BOLT, 3/8-16 x 1 HEX HD SS
14 1 37900-0101 BRACKET, FAN DRIVE SUPPORT
15 1 22230-0074 PULLEY, 5/8 BORE AK41 (50Hz)
16 1 22181-0034 FAN BELT
17 1 37900-0058 REAR SHROUD
18 1 35900-0200 VENT SHROUD - OPTIONAL
19 1 37900-0067 COVER, REAR CONTROL PANEL
20 1 27470-0035 GUARD, COOLING FAN
21 4 21256-0009 SCREW, 10-32 x 5/8 TRUSS CAP
22 1 37900-0042 FLUE VENT EXTENSION - DOUBLE OVENS ONLY
23 1 37900-0041 FLUE VENT CROSSOVER - DOUBLE OVENS ONLY
24 1 49400-0029 FLUE VENT
25 1 28021-0061 SWITCH, REAR SHROUD SAFETY - SEE PP. 16-17
Page 14
14
FIGURE 8
CONTROL PANEL
Page 15
15
PARTS LISTS FOR CONTROL PANEL
ITEM QTY. PART NO. DESCRIPTION
1 1 33985 KIT, THERMOCOUPLE
2 1 38340 TEMPERATURE CONTROLLER (ANALOG)
3 1 30871 KIT, TEMPERATURE CONTROLLER (DIGITAL)*
4 1 36939 KIT, TEMPERATURE CONTROLLER (DIGITAL)*
5 1 42810-0133 KIT, CONVEYOR SPEED CONTROLLER
6 1 42810-0118 THUMBWHEEL - INC. W/ITEM 5
7 3 27060-0012 CONTACT BLOCK WITH BASE
8 3 28021-0062 SWITCH KNOB, BLUE
9 1 28201-0016 PUSHBUTTON SWITCH, LIGHTED, RED
-- 1 27073-0007 NEON BULB, 220V - INC. W/ITEM 9
10 1 -- LABEL, AIR FINGER ARRANGEMENT
11 1 -- LABEL, PS200VL(CE) WIRING DIAGRAM
12 2 32825 CIRCUIT BREAKER, 8A
13 2 32210 CIRCUIT BREAKER, 6A
14 1 31503 CIRCUIT BREAKER, 2A
15 1 28041-0011 CONTACTOR
* REPLACE WITH P/N 30871 OR 36939 AS INSTRUCTED BY MIDDLEBY SERVICE.
Page 16
16
FIGURE 9
MACHINERY COMPARTMENT
Page 17
17
PARTS LISTS FOR MACHINERY COMPARTMENT
ITEM QTY. PART NO. DESCRIPTION
1 A/R 27384-0011 MOTOR, CONVEYOR GEAR - SEE PP. 20-23
2 1 28021-0047 SWITCH, DOOR SAFETY
3 1 33983 CONTROL, HIGH LIMIT
4 2 33985 KIT, THERMOCOUPLE
5 1 31504 TRANSFORMER, 230V PRI./120V SEC., 200VA
6 1 35825 KIT, IGNITION MODULE
7 1 32001 CONNECTOR, 12-PIN - INC. W/ITEM 4
8 1 33813 RFI FILTER
9 A/R 35900-0105 AIR TUBING, SILICONE, 1/4 (6.4mm) DIA.
10 1 35625 KIT, AIR PRESSURE SWITCH
11 1 28021-0061 SWITCH, REAR SHROUD SAFETY
12 1 27381-0066 MOTOR, BLOWER - 1/3 HP, 200-240V, 1 PH
13 1 30693 PUSHBUTTON, HIGH LIMIT RESET
14 1 27221-0015 BUSHING, WIRING, SNAP-IN
15 1 21651-0010 KEY, BLOWER PULLEY
16 1 22230-0074 PULLEY, 5/8 BORE AK41 (50Hz)
17 1 27399-0004 FAN, COOLING, 5/8 BORE
18 1 -- SET SCREW, COOLING FAN - INC. W/ITEM 14
19 5 21216-0001 BOLT, HEX, 3/8-16 x 1 SS
20 5 21422-0001 WASHER, SPLIT, 3/8
21 2 21416-0001 WASHER, FLAT, 3/8 SS
22 1 35900-0076 BRACKET, MOTOR SUPPORT, ADJUSTABLE
23 1 35900-0075 ROD, PIVOT, MOTOR BRACKET
24 2 21671-0007 COTTER PIN
25 1 37900-0005 BRACKET, MOTOR MOUNTING
26 4 21416-0013 BOLT, HEX, 5/16-18 x 1 SS
27 8 21412-0005 WASHER, FLAT, 5/16
28 4 21126-0004 NUT, HEX, 5/16-18 SS
Page 18
18
FIGURE 10
GAS BURNER SYSTEM
Page 19
PARTS LISTS FOR GAS BURNER SYSTEM
19
ITEM QTY. PART NO. DESCRIPTION
1 1 37770 KIT, SOLENOID VALVE REPLACEMENT*
1 1 30876 SOLENOID VALVE - INC. WITH P/N 37770
2 A/R 15125-0002 TUBING, ALUMINUM, 1/4 DIA, 1 FT.
3 1 28092-0020 GAS CONTROL VALVE, NATURAL/PROPANE
4 1 22564-0011 CAP PLUG
5 1 30185 KIT, PILOT PRESSURE TAP (PILOT TEE)
6 1 42400-0640 PITOT TUBE ASSEMBLY
7 1 27170-0287 BURNER BLOWER/MOTOR ASSEMBLY
8 1 42810-0087 KIT, EXTERNAL AIR SHUTTER
* THIS SERVICE KIT INCLUDES ADDITIONAL COMPONENTS AND INSTRUCTIONS TO BE USED IN CONVERTING FROM THE PREVIOUS-STYLE SOLENOID
VALVE. IF THE OVEN IS ALREADY EQUIPPED WITH THE CURRENT-STYLE VALVE, ORDER P/N 30876.
ITEM QTY. PART NO. DESCRIPTION
9 1 36562 KIT, BURNER MOUNTING RING
10 1 27170-0223 VENTURI ASSEMBLY
11 1 27170-0264 BRACKET, PILOT IGNITOR
12 1 27170-0204 SHIELD, PILOT
13 1 38280 WINDOW PLUG
14 1 38279 MAIN ORIFICE HOLDER/GAS INLET CONNECTOR
15 1 23052-0007 FITTING, PILOT BULKHEAD
16 1 38284 FITTING, PILOT TUBING
17 1 42810-0117 KIT, PILOT IGNITOR ASSEMBLY
CHART OF STANDARD ORIFICE SIZES AND PART NUMBERS
PS200VL
SUPPLY GAS TYPE ITEM 19: BYPASS ORIFICE ITEM 20: MAIN ORIFICE ITEM 21: PILOT ORIFICE
NATURAL
H (G20) 22174-0020 (.065/1.65mm) 22176-0006 (.197/5.00mm) 22174-0011 (.025/0.64mm)
L (G25) 22174-0020 .065/1.65mm) 22176-0006 (.197/5.00mm) 22174-0011 (.025/0.64mm)
G20, G25 22174-0006 (.059/1.50mm) 31980 (.165/4.20mm) 22174-0011 (.025/0.64mm)
PROPANE
G30 32599 (.034/0.85mm) 22176-0024 (.099/2.50mm) 22174-0010 (.015/0.38mm)
G30, G31 22174-0009 (.037/0.95mm) 31981 (.114/2.90mm) 22174-0010 (.015/0.38mm)
PS220VL and PS224VL
SUPPLY GAS TYPE ITEM 19: BYPASS ORIFICE ITEM 20: MAIN ORIFICE ITEM 21: PILOT ORIFICE
NATURAL
H (G20) 22174-0020 (.065/1.65mm) 22176-0016 (.181/4.60mm) 22174-0011 (.025/0.64mm)
L (G25) 22174-0020 (.065/1.65mm) 22176-0016 (.181/4.60mm) 22174-0011 (.025/0.64mm)
G20, G25 22174-0006 (.059/1.50mm) 31982 (.154/3.90mm) 22174-0011 (.025/0.64mm)
PROPANE
G30 32599 (.034/0.85mm) 30446 (.091/2.30mm) 22174-0010 (.015/0.38mm)
G30, G31 22174-0009 (.037/0.95mm) 22176-0023 (.106/2.70mm) 22174-0010 (.015/0.38mm)
Page 20
20
FIGURE 12
CONVEYOR ASSEMBLY -
SINGLE BELT OVENS
Page 21
PARTS LIST FOR CONVEYOR ASSEMBLY - SINGLE BELT OVENS
PS200VL PS220VL PS224VL
ITEM QTY. P/N QTY. P/N QTY. P/N DESCRIPTION
-- 1 34996 1 37668 1 35266 ASSEMBLY, CONVEYOR
1 1 34881 1 37648 1 35272 ASSEMBLY, CONVEYOR FRAME
2 1 -- 1 37665 1 -- ASSEMBLY, DRIVE SHAFT
3 1 34890 1 37651 1 35270 DRIVE SHAFT
4 6 34886 5 34886 4 34886 SPROCKET, CONVEYOR
5 6 -- 5 -- 4 -- SOCKET SET SCREW, CONVEYOR, #10-32 x 7/16 - INC. W/ITEM 4
6 1 35409 1 35409 1 35409 SPROCKET, DRIVE SHAFT
7 1 21265-00017 1 21265-00017 1 21265-00017 SET SCREW, DRIVE SHAFT SPROCKET, 1/4-20 x 1/4 - INC. W/ITEM 6
8 2 34871 2 34871 2 34871 BUSHING, CONVEYOR
9 1 -- 1 37667 1 -- ASSEMBLY, IDLER SHAFT
10 1 34889 1 37652 1 35269 IDLER SHAFT
11 6 34886 5 34886 4 34886 SPROCKET, CONVEYOR
21
12 6 -- 5 -- 4 -- SET SCREW, CONVEYOR, #10-32 x 7/16 - INC. W/ITEM 11
13 2 34871 2 34871 2 34871 BUSHING, CONVEYOR
14 1 22450-0225 1 22450-0252 1 22450-0287 CONVEYOR BELT, 146 (3708mm)
15 1 42400-0089 1 49400-0197 1 42400-0090 CONVEYOR MASTER LINKS KIT
16 -- -- -- MASTER LINK, LEFT - INC. W/ITEM 15
17 -- -- -- MASTER LINKS, CENTER - INC. W/ITEM 15
18 -- -- -- MASTER LINK, RIGHT - INC. W/ITEM 15
19 1 27384-0011 1 27384-0011 1 27384-0011 MOTOR, CONVEYOR GEAR
20 2 22450-0230 2 22450-0230 2 22450-0230 BRUSHES, CONVEYOR GEAR MOTOR - INC. W/ITEM 19
21 4 21122-0004 4 21122-0004 4 21122-0004 NUT, 10-32 HEX HD
22 4 21421-0003 4 21421-0003 4 21421-0003 WASHER, #10 SPLIT
23 4 21421-0011 4 21421-0011 4 21421-0011 WASHER, #10 FLAT
24 1 27170-0263 1 27170-0263 1 27170-0263 CONVEYOR CONTROL PICKUP KIT
25 1 22151-0003 1 22151-0003 1 22151-0003 SPROCKET, CONVEYOR GEAR MOTOR (15T)
26 1 -- 1 -- 1 -- SET SCREW, CONV DRIVE SPRKT, 1/4-20 UNC-3A KNURLED CUP PT - INC. W/ITEM 25
27 1 49400-0050 1 49400-0050 1 49400-0050 ASSEMBLY, DRIVE CHAIN, 12-3/8
28 1 22273-0002 1 22273-0002 1 22273-0002 MASTER LINK, DRIVE CHAIN - INC. W/ITEM 27
29 2 35363 2 38551 2 35322 CRUMB PAN
Page 22
22
FIGURE 13
CONVEYOR ASSEMBLY -
SPLIT BELT OVENS
Page 23
23
PARTS LIST FOR CONVEYOR ASSEMBLY - SPLIT BELT OVENS
PS200VL PS220VL PS224VL
ITEM QTY. P/N QTY. P/N QTY. P/N DESCRIPTION
-- 1 37379 1 37690 1 37645 ASSEMBLY, CONVEYOR
1 1 34881 1 37648 1 35272 ASSEMBLY, CONVEYOR FRAME
2 1 37377 1 37680 1 37643 ASSEMBLY, DRIVE SHAFT
3 2 37376 2 37376 2 37376 BUSHING, CONVEYOR
4 8 22229-0003 6 22229-0003 6 22229-0003 SPROCKET, CONVEYOR
5 8 21276-0039 6 21276-0039 6 21276-0039 SET SCREW, CONV SPRKT, 1/4-28 x 1/2 UNF-3A CONE PT - INC. W/ITEM 4
6 1 49400-0018 1 37681 1 49400-0261 DRIVE SHAFT, FRONT
7 1 21415-0001 1 21415-0001 1 21415-0001 WASHER, BRONZE
8 1 35900-0022 1 37683 1 35900-0403 DRIVE SHAFT, REAR
9 1 35000-1531 1 35000-1531 1 35000-1531 NYLON SPACER
10 1 35900-0023 1 35900-0023 1 35900-0023 BUSHING, FRONT DRIVE SPROCKET
11 1 22011-0013 1 22011-0013 1 22011-0013 COLLAR, DRIVE SHAFT
12 1 -- 1 -- 1 -- SET SCREW, DRIVE SHAFT COLLAR, 5/16-18 x 3/8 UNC-3A CUP PT - INC. W/ITEM 11
13 2 22159-0003 2 22159-0003 2 22159-0003 SPROCKET, DRIVE SHAFT
14 2 -- 2 -- 2 -- SET SCREW, DR SHAFT SPRKT #10-32 UNF-3A KNURLED CUP PT - INC. W/ITEM 13
15 1 37378 1 37685 1 37644 ASSEMBLY, IDLER SHAFT
16 2 37376 2 37376 2 37376 BUSHING, CONVEYOR
17 8 22229-0003 6 22229-0003 6 22229-0003 SPROCKET, CONVEYOR
18 8 21276-0039 6 21276-0039 6 21276-0039 SET SCREW, CONV SPRKT, 1/4-28 x 1/2 UNF 3-A CONE PT - INC. W/ITEM 17
19 1 42400-0354 1 37686 1 35900-0405 IDLER SHAFT, FRONT
20 1 37898 1 37898 1 37898 SPACER
21 1 35000-1535 1 37689 1 35900-0406 IDLER SHAFT, REAR
22 2 22450-0226 2 36541 2 22450-0204 CONVEYOR BELT, 146 (3708mm)
23 2 42400-0089 2 42400-0589 2 42400-0090 CONVEYOR MASTER LINKS KIT
24 -- -- -- MASTER LINK, LEFT - INC. W/ITEM 23
25 -- -- -- MASTER LINKS, CENTER - INC. W/ITEM 23
26 -- -- -- MASTER LINK, RIGHT - INC. W/ITEM 23
27 2 27384-0011 2 27384-0011 2 27384-0011 MOTOR, CONVEYOR GEAR
28 4 22450-0230 4 22450-0230 4 22450-0230 BRUSHES, CONVEYOR GEAR MOTOR - INC. W/ITEM 27
29 8 21122-0004 8 21122-0004 8 21122-0004 HEX NUT, 10-32
30 8 21421-0003 8 21421-0003 8 21421-0003 WASHER, #10 SPLIT
31 8 21421-0011 8 21421-0011 8 21421-0011 WASHER, #10 FLAT
32 2 27170-0263 2 27170-0263 2 27170-0263 CONVEYOR CONTROL PICKUP KIT
33 2 22159-0004 2 22159-0004 2 22159-0004 SPROCKET, CONVEYOR GEAR MOTOR (30T)
34 2 -- 2 -- 2 -- SET SCREW, CONV DRIVE SPRKT, 10-24 UNC KNURLED CUP PT - INC. W/ITEM 33
35 1 49400-0051 1 49400-0051 1 49400-0051 ASSEMBLY, REAR DRIVE CHAIN, 26-1/2
36 1 22273-0003 1 22273-0003 1 22273-0003 MASTER LINK, REAR DRIVE CHAIN - INC. W/ITEM 35
37 1 49400-0070 1 49400-0070 1 49400-0070 ASSEMBLY, FRONT DRIVE CHAIN, 15
38 1 22273-0002 1 22273-0002 1 22273-0002 MASTER LINK, FRONT DRIVE CHAIN - INC. W/ITEM 38
39 2 35363 2 38551 2 35322 CRUMB PAN
Page 24
A MIDDLEBY COMPANY
Middleby Cooking Systems Group 1400 Toastmaster Drive Elgin, IL 60120 USA (847)741-3300 FAX (847)741-4406
Middleby Corp 24-Hour Service Hotline 1-800-238-8444
www.middleby.com
Loading...