Metra Electronics 99-5700, AW-509FD, DW-5510, AT-509FD Installation Manual
TOOLS REQUIRED
Cutting tool
86-5618 - Head unit
removal keys
Phillips screwdriver
KIT COMPONENTS
rev. 130103
Radio Housing #1
Radio Housing #2
Shaft
Supports
Faceplate
ISO-DIN
Brackets
Snap Spacers
(4) #8 x ¾" Phillips
Pan-head Screws
(2) #6 Self-tapping Screws
Bracket #2
(Escort/Lynx)
Spacer Set #1
Bracket Set #1
(Econoline)
22
APPLICATIONS
FORD/JEEP/LINCOLN/MAZDA/MERCURY 1975-00
(SEE INSIDE FOR SPECIFIC APPLICATIONS)
45
Locate the factory wiring harness in the
dash. Metra recommends using the
proper mating adaptor and making
connections as shown. (Isolate and
individually tape off the ends of any
unused wires to prevent electrical short
circuit).
Re-connect the battery terminal and test the unit
for proper operation. Mount the head unit/kit
assembly to the sub-dash with those screws
previously removed.
A
B
C
D
A) Strip wire ends back ½"
B) Twist ends together
C) Solder
D) Tape
AEROSTAR 1992-97, BRONCO II 1989-90, EXPLORER 1991-94, RANGER 1989-94,
CROWN VICTORIA 1991-94, GRAND MARQUIS 1991-94, ECONOLINE 1992-96, ESCORT
1991-96, TRACER (sedan) 1991-96, F-SERIES PICKUP 1992-96, BRONCO 1992-96,
TAURUS 1990-95, SABLE 1990-95, TEMPO 1989-94, TOPAZ 1989-94, THUNDERBIRD
1989-97, COUGAR 1989-97, CONTINENTAL 1988-94, MARK VII 1990-92, TOWN CAR
1990-94, MARK VIII 1993-95, ASPIRE, B-SERIES PICKUP, CONTOUR, MYSTIQUE,
MUSTANG, PROBE, WINDSTAR, MPV, MX3, MX6, PROTEGE, 626, CAPRI XR2,
VILLAGER, QUEST: For DIN units, using the scored lines on the back of the Faceplate as a
guide, cut and remove the shaft supports and mounting clips. Slide the DIN cage into the dash
(through the Faceplate) and secure by bending the metal locking tabs down. Slide the
aftermarket head unit into the cage until secure. (see Fig. A). For 2-Shaft units, make wiring
connections and slide the aftermarket unit into the dash. Slide the Shaft Supports over the
radio shafts and position them along the inner lip of the radio opening. Place the aftermarket
faceplate against the outer lip of the radio opening and secure with shaft nuts. (see Fig. B)
Fig. A
(Taurus / Sable
application
shown)
INST 5700
99-5700
AT-509FD
AW-509FD
DW-5510
INSTALLATION
INSTRUCTIONS
Fig. B
3c
1-800-221-0932 www.metraonline.com
© COPYRIGHT 2001 METRA ELECTRONICS CORPORATION
21
TABLE OF CONTENTS
CAR PAGE
FORD
Aerostar 1992-97........................ 1
Aerostar 1985-91........................ 1
Aspire 1994-97............................ 2
Bronco 1992-96.......................... 8
Bronco (full) 1987-91................. 3
Bronco 1980-86.......................... 2
Bronco II 1989-90....................... 3
Bronco II 1985-88....................... 4
Contour 1995-00......................... 4
Crown Victoria 1992-94.............. 5
Crown Victoria 1979-90............. 5
Econoline 1992-96..................... 6
Econoline 1975-91..................... 6
Escort 1991-96............................ 7
Escort 1985-90............................ 7
Explorer 1991-94........................ 3
F-Series Pickup 1992-96.......... 8
F-Series Pickup 1987-91.......... 3
F-Series Pickup 1980-86.......... 2
Festiva 1988-93.......................... 8
LTD 1980-91................................ 5
Mustang 1994-00....................... 9
Probe 1993-97............................ 9
Ranger (mini) 1989-94.............. 3
Ranger (mini) 1983-88.............. 4
Taurus 1990-95...........................10
Taurus 1986-89...........................10
Tempo 1989-94...........................11
Tempo 1985-88...........................11
Thunderbird 1989-97................. 12
Thunderbird 1983-88................. 12
Windstar 1995-98....................... 13
JEEP
Cherokee 1984-96..................... 13
Cherokee 1996........................... 14
Commanche 1985-92................ 13
Grand Wagoneer 1987-95........ 14
Wagoneer 1984-96.................... 13
Wrangler 1984-96....................... 15
LINCOLN
Continental 1988-94................... 15
Continental 1985-87................... 16
Mark VII 1990-92........................ 15
Mark VII 1984-89........................ 16
Mark VIII 1993-95....................... 17
Town Car 1990-974..................... 15
Town Car 1984-89..................... 17
MAZDA
B-Series Pickup 1994................ 3
626 1993-00................................ 18
MPV 1996-99.............................. 18
MX3 1992-96.............................. 18
MX6 1993-97.............................. 18
Navajo 1991-94.......................... 3
Protege 1995-00......................... 19
MERCURY
Capri XR2 1991-94................... 19
CAR PAGE
MERCURY (cont.)
Cougar 1989-97..................... 12
Cougar 1983-88..................... 12
Grand Marquis 1991-94........ 5
Grand Marquis 1979-90........ 5
Lynx 1985-87.......................... 7
Mystique 1995-009................... 4
Marquis 1979-81.................... 5
Sable 1990-95........................ 9
Sable 1986-89........................ 10
Topaz 1989-94........................ 11
Topaz 1985-88........................ 11
Tracer 1991-96....................... 7
Tracer (hatch) 19869-90......... 20
Villager 1993-95...................... 20
NISSAN
Quest 1993-95........................ 20
ADDITIONAL VEHICLES:
ACURA
Integra 1986-89...................... 22
Legend 1986-89..................... 22
ALFA ROMEO
Milano 1980-89....................... 22
Spider Veloce 1987-93.......... 22
164 L/S 1991-93.................... 22
AUDI
80/90 1988-96........................ 22
100/200 1989-95.................... 22
4000 1980-87.......................... 22
5000 1978-88......................... 22
S4 1992-93.............................. 22
BMW
3-Series 1977-98.................... 22
5-Series 1975-96.................... 22
6-Series 1977-89.................... 22
7-Series 1978-98.................... 22
8-Series 19901-93.................... 22
DAIHATSU
Charade 1989-92................... 22
DODGE
Colt 1993-94............................ 22
D50 Pickup 1988-93.............. 22
EAGLE
Summit 1993-94..................... 22
FIAT
Beretpme X19 1985-88........ 22
Brava 1979-83........................ 22
Spider 1970-83....................... 22
Strada 1977-83....................... 22
X19 1979-89........................... 22
GEO
Metro 1989-91........................ 22
Tracker 1989-91..................... 22
HONDA
Accord 1982-89...................... 22
CRX 1984-91.......................... 22
Civic 1982-95........................ 22
Del Sol 1993-97.................. 22
Prelude 1983-97................... 22
CAR PAGE
JAGUAR
XJ6 19868-93....................... 22
LANCIA
Beta 1979-81...................... 22
MASERATI
Spyder 1985-90.................. 22
MERCEDES
240/280/300/380/420/450
500SLC/SEL 1970-96....... 22
MITSUBISHI
Mighty Max 1987-96......... 22
Mirage 1993-02.................. 22
PEUGEOT
405 1989-91........................22
505 1984-913........................ 22
PONTIAC
LeMans 1988-93................ 22
PORSCHE
911 1973-99........................22
924 1977-82........................22
924S 1986-88..................... 22
928 1980-96........................22
944 1983-93........................22
968 1992-96........................22
Boxter 1997-2001............... 24
RENAULT
Alliance 19824-85 ................ 22
Encore 1984-87.................. 22
Fuego 1982-85................... 22
LeCar 1973-83................... 22
18i 1979-83......................... 22
SAAB
900 1979-98........................22
9000 1986-986..................... 22
STERLING
825 1987-88........................22
827 19889-92........................ 22
SUZUKI
Samurai 1988½-93............ 22
Sidekick 1989-91................ 22
Swift 1989-91...................... 22
X-90 1996-99...................... 22
VOLKSWAGEN
Bus 1968-79....................... 22
Cabriolet 1985-93............... 22
Cabro 1995-01.................... 22
Corrado 1990-93................ 22
Dasher 1976-81................. 22
Fox 1987-93........................22
Golf 1985-00....................... 22
Passat 1990-979................. 22
Pickup 1980........................ 22
Rabbit 1975-84................... 22
Scirocco 1981-87............... 22
Super Beetle 1973-79....... 22
Quantum 1982-88.............. 22
Vanwagon 1980-92........... 22
ALL VEHICLES
AEROSTAR 1985-91, BRONCO 1987-91,
BRONCO II 1985-88, CROWN VICTORIA
1979-90, ECONOLINE 1975-91, ESCORT
1985-90, F-SERIES PICKUP 1987-91, LTD
1979-84, RANGER 1985-88, TAURUS 198689, THUNDERBIRD 1985-88, CONTINENTAL 1985-87, MARK VII 1984-89, TOWN CAR
1984-89, COUGAR 1985-88, GRAND MARQUIS 1979-90, LYNX 1985-90, MARQUIS 197990, SABLE 1986-89, TRACER (hatchback) 1988-90, all JEEPS: For 2-Shaft units, snap the
Faceplate into Radio Housing #2. Slide the aftermarket head unit into the kit and secure with
shaft nuts. (see Fig. A). For DIN units, slide the DIN cage into Radio Housing #2 and secure
by bending the metal locking tabs down. (The Snap Spacers may be added for a semirecessed installation). Slide the aftermarket head unit into the cage until secure. (see Fig. B).
For ISO-DIN units, cut and remove the shaft supports from the Faceplate. Snap the Faceplate
into Radio Housing #2 and slide the head unit into the back of the kit. Attach the ISO-DIN
Brackets to the Housing legs, align the Bracket holes with the unit holes and secure the
Brackets with (2) #6 Self-tapping Screws. (see Fig. C)
3a
3b
Fig. A
Fig. C
Fig. B
BRONCO 1980-86, F-SERIES PICKUP 1980-86, FESTIVA 1988-93, TEMPO 1985-88,
TOPAZ 1985-88: For 2-Shaft units, slide the aftermarket head unit into Radio Housing #1
and secure with shaft nuts. (see Fig. A). For Din units, cut and remove the shaft supports from
Radio Housing #1. Slide the DIN cage into the Housing and secure by bending the metal
locking tabs down. Slide the aftermarket head unit into the cage until secure. (see Fig. B)
Fig. A
Fig. B
20
1
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
(2) screws from the steering column trim
panel and (2) screws from the ashtray cavity.
Unclip the dash trim bezel. Using Metra's
86-5618, pull the factory head unit from the
dash and disconnect the wiring.
1
FORD Aerostar 1992-97
2
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
(3) Phillips screws from the top of the dash
trim bezel. Remove the ashtray and (2)
Phillips screws from the bottom of the bezel.
Remove (4) Phillips screws securing the
factory head unit and disconnect the wiring.
1
MERCURY Tracer (hatchback) 1989-90
2
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
(2) Phillips screws from the base of the dash
trim bezel. Pry down on the (2) tabs located
at the top of the dash trim bezel and remove
the bezel. Remove (4) screws securing the
factory head unit and disconnect the wiring.
1
FORD Aerostar 1985-91
2
Cut and remove all mounting tabs on Radio
Housing #2 EXCEPT tabs "D" and "F".
The mounting tabs can be identified by the
stamped letter on the back of each tab.
Locate Spacer Set #1. (The Spacers must
be placed behind the mounting tabs during
installation in step #5). Skip to the
Installation Instructions for ALL VEHICLES
on Page #21.
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
(1) screw above the climate controls. Unclip
the dash trim bezel. Using Metra's 86-5618,
pull the factory head unit from the dash and
disconnect the wiring.
1
MERCURY Villager 1993-96 / NISSAN Quest 1993-95
2
"F"
"D"
2
19
Disconnect the negative battery terminal to
prevent an accidental short circuit. Using
Metra's 86-5618, pull the factory head unit
from the dash and disconnect the wiring.
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
(2) screws from the top edge of the dash trim
bezel. Pull out on the top of the bezel,
unhook the base and remove the bezel. If a
factory head unit is NOT present, scribe the
(4) mounting holes and radio opening onto
the bezel. Drill the holes, cut the opening
and place (4) U-clips over the mounting
positions.
1
1
FORD Aspire 1994-97
FORD Bronco / Pickup 1980-86
2
2
Cut and remove all mounting tabs on Radio
Housing #1 EXCEPT tabs "B". The
mounting tabs can be identified by the
stamped letter on the back of each tab. Skip
to the Installation Instructions for ALL
VEHICLES on Page #21.
Disconnect the negative battery terminal to
prevent an accidental short circuit. Remove
the ashtray and (2) screws from the ashtray
cavity. Using Metra's 86-5618, pull the
factory head unit from the dash and
disconnect the wiring.
1
MAZDA Protege 1995-00
2
Disconnect the negative battery terminal to
prevent an accidental short circuit. Using
Metra's 86-5618, pull the factory head unit
from the dash and disconnect the wiring.
1
MERCURY Capri XR2 1991-94
2
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
Cut and remove the shaft supports from the
Faceplate. Skip to step #3c in the
Installation Instructions for ALL VEHICLES
on Page #22.
"B"
"B"
Loading...