Metra Electronics 99-5810 Installation Manual

Page 1
INSTALLATION INSTRUCTIONS FOR PART 99-5810
99-5810
KIT FEATURES
• DIN Head Unit Provision with Pocket
• ISO DIN Head Unit Provision with Pocket
A) Radio Housing • B) ISO Brackets • C) ISO Trim Plate
KIT COMPONENTS
Small Flat Blade Screwdriver/ Panel Removal Tool
• Socket Wrench Set
1-800-221-0932
© COPYRIGHT 2007 METRA ELECTRONICS CORPORA
TION
www.metr
aonline.com
TOOLS REQUIRED:
APPLICATIONS
LINCOLN Town Car
2003-2007
Page 2
Dash Disassembly
- LINCOLN Town Car 2003-2007 . ....................................1
Kit Assembly
- DIN Head Unit Provision with Pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
- ISO DIN Head Unit Provision with Pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Final
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
TABLE OF CONTENTS
99-5810
*Note: Refer also to the instructions included with the aftermarket radio.
Page 3
99-5810 DASH DISASSEMBLY
LINCOLN TOWN CAR 2003-2007
1
10
0
20
30
40
50
60
70
80
90
100
100
60
20
140
180
11
0
120
P
C
H
R
N
2
1
MPH
0.0
MI
L
ES
LINCOLN
Disconnect the negative battery ter-
minal to prevent an accidental short circuit.
1
Remove (2) 7mm bolts facing upward above instrument cluster/gauges.
(Figure A)
2
Carefully unsnap and remove dash panel surrounding radio and instru­ment cluster/gauges.
(Figure B)
3
Remove (2) 7mm bolts above clock panel and remove panel).
(Figure C)
4
Remove (4) 7mm bolts securing radio.
5
Continue to kit assembly.
A
C
B
Page 4
2
99-5810 KIT ASSEMBLY
B
A
DIN HEAD UNIT PROVISION WITH POCKET
Slide the DIN cage into the Radio Housing and secure by bending the metal locking tabs down.
(Figure A)
1
Slide the after-market head unit into the cage and secure.
(Figure B)
2
Continue to final assembly.
*Note: Refer also to the instructions included with the aftermarket radio.
Page 5
3
99-5810 KIT ASSEMBLY
B
A
ISO DIN HEAD UNIT PROVISION WITH POCKET
Mount the ISO Brackets to the head unit with the screws supplied with the unit.
(Figure A)
1
Slide the head unit into the radio opening until the side clips engage.
(Figure B)
2
Snap the Trim plate into the Radio Housing.
(Figure B)
3
Continue to final assembly.
*Note: Refer also to the instructions included with the aftermarket radio.
Page 6
99-5810 FINAL ASSEMBLY
FINAL ASSEMBLY
(A) Strip wire ends back 1/2"
B) Twist ends together
C) Solder
D) Tape
A
B
C
D
Locate the factory wiring harness in the dash. Metra recommends using the proper mating adapter and making connections as shown. (Isolate and individ­ually tape off the ends of any unused wires to prevent electrical short circuit.)
Re-connect the negative battery terminal and test the unit for proper operation.
Reassemble radio and dash assemblies in reverse order of disassembly.
1
2
3
4
FINAL WIRING CONNECTIONS
Make wiring connections using the EIA color code chart shown below and the instructions included with the head unit. Metra recommends making connections as shown below; Strip, Splice, Solder, Tape. Isolate and
individually tape off ends of any unused wires to prevent electrical short circuit.
METRA / EIA WIRING CODE
12V Ignition / Acc. . . . . . . . . . Red
12V Batt / Memory. . . . . . . . . Yellow
Ground. . . . . . . . . . . . . . . . . . Black*
Power Antenna. . . . . . . . . . . . Blue
Amp Turn-On . . . . . . . . . . . . . Blue / White
Amp Ground. . . . . . . . . . . . . . Black / White
Illumination . . . . . . . . . . . . . .
Orange
Dimmer . . . . . . . . . . . . . . . . . Orange / White
Right Front (+) . . . . . . . . . . . . Gray
Right Front (-). . . . . . . . . . . . . Gray/ Black
Left Front (+) . . . . . . . . . . . . . White
Left Front (-). . . . . . . . . . . . . . White / Black
Right Rear (+) . . . . . . . . . . . . Violet
Right Rear (-) . . . . . . . . . . . . . Violet / Black
Left Rear (+)
. . . . . . . . . . . . .
Green
Left Rear (-) . . . . . . . . . . . . . . Green / Black
*NOTE: When a Black wire is not present,
ground radio to vehicle chassis.
All colors may not be present on all leads due to manufacturer’s specifications.
Page 7
99-5810
NOTES
5
Page 8
99-5810 INSTRUCTIONS
1-800-221-0932
REV. 5/01/07 © COPYRIGHT 2007 METRA ELECTRONICS CORPORATION INST99-5810
www.metraonline.com
Loading...