Metalloid Metkleen 2120 User Manual

Date Prepared :

SDS No :

SAFETY DATA SHEET

1. PRODUCT AND COMPANY IDENTIFICATION

PRODUCT FORMULATION NAME: Metkleen 2120
CHEMICAL FAMILY: Cleaner

MANUFACTURER 24 HR. EMERGENCY TELEPHONE NUMBERS

Metalloid Corporation
1160 White St
Sturgis, MI 49091

Emergency Contact: Robert Kowalski
Emergency Phone: [phone]
E-Mail: [e-mail]

2. HAZARDS IDENTIFICATION

Poison Control Center (Medical) : [phone]

CHEMTREC (US Transportation) : [phone]

Page 1 of 5

08/04/2014
Metkleen 2120

GHS CLASSIFICATIONS

Health:

Acute Toxicity (Oral), Category 4
Corrosive to Metals, Category 1
Skin Corrosion, Category 1B
Skin Irritation, Category 2
Eye Irritation, Category 2

GHS LABEL

Corrosion Health

hazard

SIGNAL WORD: DANGER
HAZARD STATEMENTS

H319: Causes serious eye irritation.
H315: Causes skin irritation.
H302: Harmful if swallowed.

PRECAUTIONARY STATEMENTS

Prevention:

P280: Wear protective gloves/protective clothing/eye protection/face protection.
P262: Do not get in eyes, on skin, or on clothing.
P260: Do not breathe dust/fume/gas/mist/vapours/spray.
P270: Do not eat, drink or smoke when using this product.

Response:

P305+P351+P338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and

easy to do. Continue rinsing.
P337+P313: If eye irritation persists: Get medical advice/attention.
P310: Immediately call a POISON CENTER/doctor/...

Storage:

P403+P233: Store in a well-ventilated place. Keep container tightly closed.

Disposal:

Page 2 of 5

Metkleen 2120

P501: Dispose of contents/container in accordance with Local/State/Federal regulations

POTENTIAL HEALTH EFFECTS

EYES: Contact causes severe eye irritation.
SKIN: Contact causes severe skin irritation and possible burns.
INGESTION: May cause severe irritation and injury to the mouth, throat and digestive tract

INHALATION: May cause damage to nasal and respiratory passages
MEDICAL CONDITIONS AGGRAVATED: May aggravate skin irritation/dermatitis
ROUTES OF ENTRY: Inhalation, Skin absorption, Skin Contact, Eye Contact, Ingestion

3. COMPOSITION / INFORMATION ON INGREDIENTS

Chemical Name Wt.% CAS

Potassium Hydroxide 2.52 1310-58-3

Nonylphenol (branched), Ethoxylated ≥ 3.88 127087-87-0

Ethoxylated Alkyl Amine 2.99 61791-14-8

2- Butoxyethanol 4 111-76-2

Benzenesulfonic Acid, 4-methyl- ~ 2.256 104-15-4

Sodium Dodecylbenezene Sulfonate 0.117 - 0.1209 25155-30-0

Phosphoric Acid 0.605 - 1.045 7664-38-2

4. FIRST AID MEASURES

EYES: Immediately flush with plenty of water for at least 15 minutes. Get medical attention immediately.
SKIN: Immediately flush skin with water for at least 15 minutes while removing contaminated clothing and shoes. Seek

immediate medical attention. Wash clothing before reuse and discard contaminated shoes.

INGESTION: Get immediate medical attention. Do not induce vomiting unless instructed to do so by poison center or

physician.

INHALATION: Move person to fresh air; if effects occur, consult a physician.
NOTES TO PHYSICIAN: Based on the individual reactions of the patient, the physician's judgement should be used to

control symptoms and clinical condition.

5. FIRE FIGHTING MEASURES

EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, foam
HAZARDOUS COMBUSTION PRODUCTS: Can include carbon oxides
FIRE FIGHTING PROCEDURES: Use water spray to cool containers exposed to flames. Fire fighting personnel should wear

respiratory protection.

6. ACCIDENTAL RELEASE MEASURES

SMALL SPILL: Absorb with an inert material and place in an appropriate waste disposal container.
LARGE SPILL: Stop spill at the source. Pump liquid to salvage container. Recover product if possible. Remaining liquid can

be taken up with absorbent material and placed into appropraite containers.

7. HANDLING AND STORAGE

GENERAL PROCEDURES: Keep container closed when not in use
HANDLING: Avoid contact with eyes. Avoid prolonged or repeated skin contact with the concentrate. Wash thoroughly after

handling. Do not swallow. Do not transfer to an unlabeled container.

8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Page 3 of 5

Metkleen 2120

EXPOSURE GUIDELINES

OSHA HAZARDOUS COMPONENTS (29 CFR1910.1200)

EXPOSURE LIMITS

OSHA PEL ACGIH TLV Supplier OEL

Chemical Name ppm mg/m

3

ppm mg/m

3

ppm mg/m

3

2- Butoxyethanol

TWA 50 240 20 97 NL NL

STEL NL NL

TWA NL NL

Benzenesulfonic Acid, 4-methyl-

STEL NL NL

TWA NL NL

Sodium Dodecylbenezene Sulfonate

STEL NL NL

TWA 1 1 NL NL

Phosphoric Acid

STEL 3 NL NL

ENGINEERING CONTROLS: General room ventilation should be sufficient. If mists are present, provide adequate ventilation

to control level below PEL.

PERSONAL PROTECTIVE EQUIPMENT

EYES AND FACE: Face Shield or chemical resistant goggles must be worn. Ensure that eyewash stations and safety

showers are close to the workstation location.

SKIN: When prolonged or frequently repeated contact scould occur, use protective clothing chemically resistant to this

material. Selection of specific items such as facesheild, boots, apron or full-body suit will depend on the task.

RESPIRATORY: Not normally needed. If significant mists, vapors or aerosols are generated an approved respirator is

recommended.

WORK HYGIENIC PRACTICES: Use good hygiene. Do not consume or store food in the work area. Wash hands before

smoking or eating.

OTHER USE PRECAUTIONS: If there is a likelihood of splashing, an oil resistant apron should be worn to prevent clothing

contamination. If clothing is contaminated, remove clothing and thoroughly wash the affected area. Launder contaminated
clothing before reuse. Keep an eyewash fountain available. Keep a safety shower available.

9. PHYSICAL AND CHEMICAL PROPERTIES

Chemical Name

Flash
Point

(°C)

Boiling

Point (°C)

Freezing

Point (°C)

Ethoxylated Alkyl Amine 300

Phosphoric Acid 11 22 33 44

ODOR: Mild odor
APPEARANCE: Liquid
COLOR: Clear light amber
BOILING POINT: > (200°F) at 760 mm HG
SOLUBILITY IN WATER: Complete
EVAPORATION RATE: 1 water=1
SPECIFIC GRAVITY: 1.06 at (70°F)

10. STABILITY AND REACTIVITY

HAZARDOUS POLYMERIZATION: Will not occur
STABILITY: Stable under normal conditions
CONDITIONS TO AVOID: None known.

Specific

Gravity

Page 4 of 5

Metkleen 2120

HAZARDOUS DECOMPOSITION PRODUCTS: Products of combustion can include carbon oxides.
INCOMPATIBLE MATERIALS: Strong oxidizing agents. Strong acids.

11. TOXICOLOGICAL INFORMATION

ACUTE

Chemical Name ORAL LD50

Ethoxylated Alkyl Amine 750

CARCINOGENICITY

Chemical Name

2- Butoxyethanol 3

Phosphoric Acid None known.

12. ECOLOGICAL INFORMATION

COMMENTS: No specific ecological data is available for this product.

13. DISPOSAL CONSIDERATIONS

DISPOSAL METHOD: Dispose of according to Local, State and Federal regulations. Not a RCRA hazardous waste if

uncontaminated. If "used" RCRA criteria must be determined. Do not flush to drain/storm sewer.

EMPTY CONTAINER: Empty containers have same safety concerns as full drum

IARC

Status

General Toxicity

14. TRANSPORT INFORMATION

DOT (DEPARTMENT OF TRANSPORTATION)

OTHER SHIPPING INFORMATION: This product is not considered hazardous according to DOT

15. REGULATORY INFORMATION

UNITED STATES

CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND LIABILITY ACT)

Chemical Name Wt.%

Potassium Hydroxide 2.52 1,000

Sodium Dodecylbenezene Sulfonate 0.117 - 0.1209 1,000

Phosphoric Acid 0.605 - 1.045 5,000

TSCA (TOXIC SUBSTANCE CONTROL ACT)

Chemical Name CAS

Potassium Hydroxide 1310-58-3

Nonylphenol (branched), Ethoxylated 127087-87-0

Ethoxylated Alkyl Amine 61791-14-8

2- Butoxyethanol 111-76-2

CERCLA

RQ

Benzenesulfonic Acid, 4-methyl- 104-15-4

Sodium Dodecylbenezene Sulfonate 25155-30-0

Phosphoric Acid 7664-38-2

16. OTHER INFORMATION

APPROVED BY: Robert Kowalski TITLE: Vice President of Research and Development
PREPARED BY: Alissa Simon Date Prepared: 08/04/2014

Metkleen 2120

INFORMATION CONTACT: 1-800-686-3201

HMIS RATING

HEALTH

2

Page 5 of 5

FLAMMABILITY

PHYSICAL HAZARD

PERSONAL PROTECTION

GENERAL STATEMENTS: This information is for use of the purchaser only. This document should not be given to any

outside organization without expressed consent from Metalloid Corporation.

MANUFACTURER DISCLAIMER: This product's safety data sheet provides health and safety information. The product is to

be used in applications consistent with our product literature. Individuals handling this product should be informed of the
recommended safety precautions and should have access to this information.

0

0

C