Mercia Garden Products 02CHY0404-V5-PEFC Instruction manual

General Instructions

Please retain product label and instructions for future reference

WARNING: Only for domestic use

02CHY0404-V5-PEFC

Cherry Playhouse

BEFORE YOU START PLEASE THE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed in the parts list provided.

- When you are ready to start, make sure you have the right tools at hand (not supplied) including a
Phillips screwdriver, Flathead screwdriver, Stanley knife, Wood saw, Step ladder, Hammer, Spirit level and
a Drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

- Ensure you have enough time to build the product to ensure the building is water tight.

TIMBER

As with all natural materials, timber can be aected during various weather conditions. For the duration
of heavy or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may
also occur during excessive dry spells due natural processes. Unfortunately, these processes cannot be
avoided but can be helped. It is suggested that the outdoor building is sprayed with water during
extended periods of hot weather and sheltered as much as possible during rain or snow.

Our buildings are pre treated with a water based treatment**; this only helps to prevent discolouration
whilst in stock. To validate your guarantee and ensure longevity of the product, it is ESSENTIAL the
building is treated with a suitable preservative in accordance with the manufacturers recommendations.
Care must be taken to ensure the product is placed on a suitable base.
We recommended using a suitable protection for your playhouse. As the product is destined for use by
children, a water based treatment that is EN71 tested for children is ESSENTIAL.

We also recommend treating the building prior to construction.

Not suitable for children under 36 months due to
small parts and danger of falling from heights.
To be used under direct supervision of an adult

!

2mm Drill bit

12mm CSK

x2

WARNING

• ONLY SUITABLE FOR DOMESTIC USE.

• TO BE USED UNDER DIRECT SUPERVISION OF AN ADULT.

• THIS PRODUCT SHOULD NOT BE MODIFIED IN ANY WAY. ANY MODIFICATIONS SHOULD BE

DETERMINED BY THE MANUFACTURER AND CARRIED OUT ACCORDING TO THE INSTRUCTIONS.

• DO NOT ALLOW YOUR CHILD TO PLAY WITH ANY COMPONENT PARTS PRIOR TO ASSEMBLY.

• MAX AGE OF 14 YEARS.

• THIS TOY IS FOR OUTDOOR USE ONLY.

• USE A WATER BASED TREATMENT THAT IS EN71 TESTED

CAUTION

Wood is a natural product and can change post manufacture. So despite every eort being
made to ensure the material used are cut and machined to a clean and smooth nish, care
must be taken when handling the product and preparing for use by your child.

Any areas of concern, in the play areas, can be rubbed over with sandpaper to achieve a
smoother nish. Alternatively, call the customer service department who will be happy to

arrange replacement panels/parts.

All buildings should be erected by
atleast two adults.

DO NOT ALLOW
CHILDREN TO ASSIST.

To prevent damage during
assembly, you MUST pilot
drill all screw holes and

ensure all screw heads are
countersunk.

Winter = High Moisture = Expansion
Summer = Low Moisture = Contraction

For ease of assembly, you will
need a tape measure to check
dimensions of components.

POSITIONING YOUR PLAYHOUSE

When thinking about where the building and base is going to be constructed:
Ensure that there will be access to all sides for maintenance work and annual treatment.

We recommend a minimum space of 2m around a playhouse, away from any structure or obstructions
such as fences, garages, houses, overhanging branches, washing lines or electrical wires.

It is recommended that the position of the Playhouse, Slide and Swing is not in direct sunlight.

Activity toys such as swings and slides for towers shall not be installed over concrete, asphalt or
any hard surface.

BUILDING A BASE

Ensure the base is level and is built on rm ground, to prevent distortion, checking with a spirit level.
Refer to diagrams for the base dimensions. The base should be slightly smaller than the external
measurement of the building, i.e. The cladding should overlap the base, creating a run o for water. It is
also recommended that the oor be at least 25mm above the surrounding ground level to avoid
ooding.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

- Wooden base.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens products
independently tested to EN71, we cannot accept responsibility for your safety whilst erecting this product.

**Protim Aquatan T

Your building has been treated with Aquatan.

Aquatan is a water-based concentrate which is diluted with water, the building as been treated by the correct application of
Aquatan solution and then allowed to dry.

Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and garden buildings.

Aquatan undiluted contains: boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl sulphosuccinat and
alcohols: 2, 4, 6-trichlorophenol.

In all instances for assistance with your product, please contact customer care on :
01636 880514 or [e-mail]

Mercia Garden Products Limited,
Sutton On Trent,
Newark,
Nottinghamshire,
NG23 6QN

www.merciagardenproducts.co.uk P1

02CHY0404-V5-PEFC

Please retain product label and instructions for future reference

Look for the symbols and follow the safety guidlines below.

Ensure screw heads
are subush and

1!

sand down any
splinters created.

2!

50kg

50kg per user

Overall Dimensions:

Width = 1416mm
Depth = 1253mm
Height = 1398mm

Base Dimensions:

Width = 1171mm
Depth = 1110mm

Ensure the screws are
xed squarely and do
not protrude.

3!

12mm gap
surrounding the
door.

4

Floor Sheet Roof Sheet Door

PI-03-0004 PI-03-0002 AI-02CHY0404-V4D

8

Ridge Bar - 28x28x1048mm

9

Eaves Frame - 28x28x1205mm

FS2828-1048mm

QTY x2

FS2828-1205mm

5

QTY x2

6

7

Window

AI-02PHOW-V1

QTY x3

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

1

10

Floor Joist - 28x28x1110mm

QTY x4

FS2828-1110mm

11

Fascia - 95x12x800mm

QTY x4

FAS800

12

Fascia Block - 28x28x200mm

2

3

13

15

17

Finial

SHED DIAMOND FINIAL

Door Flower

PI-04-0016

Wooden Door Handle

PI-04-0024

QTY x2

F2828-240mm (ANGLED)

14

16

18

Door Styrene

PI-05-0014

Window Cross

PI-04-0013

Corner Brace

PI-07-0012

QTY x3

QTY x2

QTY x2

Door Gable Plain Gable Window Side

AI-02CHY0404-V4DG AI-02CHY0404-V4PG AI-02CHY0404-V4WS

DO NOT ALLOW YOUR CHILD TO PLAY WITH ANY

COMPONENT PARTS PRIOR TO ASSEMBLY.

19

Hinge

PI-07-0113

QTY x2

20

Window Block

PI-07-0011

QTY x6

www.merciagardenproducts.co.uk P2

Nail Bag

Felt Tacks x 60

Pre Assembly

Please retain product label and instructions for future reference

10mm Screw x 4

20mm Screw x 14

30mm Screw x 56

30mm Black Screw x 14

40mm Screw x 34

50mm Screw x 28

60mm Screw x 2

Before assembling remove the transportation
blocks from the bottom of each panel.

Take care removing the blocks as to not damage
the panels. Tap with a at headed screwdriver
and hammer.

Dispose of the blocks once removed.

DO NOT ALLOW YOUR CHILD TO PLAY WITH ANY

COMPONENT PARTS PRIOR TO ASSEMBLY.

www.merciagardenproducts.co.uk P3