Mercia Garden Products 01OVLPA0510PB-V1, 01OSBA510PB-V1, 01SHPA0510PB-V1 Instruction manual

01OVLPA0510PB-V1 01OSBA510PB-V1 01SHPA0510PB-V1

Please retain product label and instructions for future reference

Before assembly

please make sure you have a

suitable base ready to erect your

building

MADE IN GREAT BRITAIN

Overall Dimensions:

Length = 1502mm

Width = 2259mm

Height = 3094mm

Base Dimensions:

Length = 1487mm

Width = 3094mm

01OSBA0510PB-V1

01SHPA0510PB-V1

BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY

- Check the pack and make sure you have all the parts listed.

- When you are ready to start, make sure you have the right tools at hand
(not supplied) including a Phillips screwdriver, Stanley knife, wood saw,
step ladder and drill with 2mm bit.

- Ensure there is plenty of space and a clean dry area for assembly.

TIMBER

As with all natural materials, timber can be aected during various weather
conditions. For the duration of heavy or extended periods of rain, swelling of the
wood panels may occur. Warping of the wood may also occur during excessive
dry spells due to an interior moisture loss. Unfortunately, these processes cannot
be avoided but can be helped. It is suggested that the outdoor building is
sprayed with water during extended periods of warm sunshine and sheltered as
much as possible during rain or snow.

Our buildings are delivered pre-treated with a water based timber treatment
however this only helps to protect during transit of your garden item. To

validate your guarantee and for better protection against weathering it is
ESSENTIAL that you treat the garden building with a wood preserver within 3

months of assembly. This will need to be re-applied annually to ensure longevity
of your building. Care must be taken when constructing the garden building
that it is not touching the ground and is on a suitable base.

01OVLPA0510PB-V1

**Protim Aquatan T5 (621)**

Your building has been treated with Aquatan.
Aquatan is a water-based concentrate which is
diluted with water, the building as been treated
by the correct application of Aquatan solution
and then allowed to dry. Aquatan is a decorative
nish to colour the wood, which is applied
industrially to timber fence panels and garden
buildings. Aquatan undiluted contains: boric
acid, sodium hydroxide 32% solution, aqueos
mixture of sodium dioctyl sulphosuccinat and
alcohols: 2, 4, 6-trichlorophenol.

x2

2mm Drill bit

This building should be erected by
two adults

For ease of assembly, you must pilot
drill all screw holes and ensure all
screw heads are countersunk.

Winter = High Moisture = Expansion
Summer = Low Moisture = Contraction

CAUTION

Every eort has been made during the
manufacturing process to eliminate the
prospect of splinters on rough surfaces
of the timber. You are strongly advised
to wear gloves when working with or
handling rough sawn timer.

Building content for:
01OVLPA0510PB-V1 & 01OSBA0510PB-V1

Plain Side Window Side

Truss

Ridge Bar - 1486mm Qty 2

Truss Block - 140mm Qty 2

Felt

Plastic Window Cill

Floor
Qty 2

Building content for:
01SHPA0510PB-V1

Plain Side Window Side

(Check building label for product code)

Floor
Qty 2

(Check building label for product code)

Roof Sheet

Qty 2

Cover Trim - 1575mm Qty 2

Window Strip - 546mm Qty 5

Floor Blocks - 400mm Qty 8

Eaves Frame - 1502mm Qty 2

Styrene

Qty 2

Middle Roof

Qty 2

BUILDING A BASE

When thinking about where the building and base is going to be constructed:
Ensure that there will be access to all sides for maintenance work and annual
treatment.

TYPES OF BASE

- Concrete 75mm laid on top of 75mm hard-core.

- Slabs laid on 50mm of sharp sand.

Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base dimensions, The base should be
slightly smaller than the external measurement of the building, i.e. The cladding should overlap the base, creating a run o for water. It is also
recommended that the oor be at least 25mm above the surrounding ground level to avoid ooding.

Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens products independently tested to EN71
level, we cannot accept responsibility for your safety whilst erecting or using this product.

Mercia Garden Products Limited, Sutton On Trent, Newark, Nottinghamshire, NG23 6QN

www.merciagardenproducts.co.uk

For Assistance Please

Contact Customer Care on

01636 880514

Truss

Ridge Bar - 1486mm Qty 2

Truss Block - 140mm Qty 2

Casement Stay

Felt

Cover Trim - 1575mm Qty 2

Opening Window Strip - 1155mm Qty 1

Floor Blocks - 400mm Qty 8

Eaves Frame - 1502mm Qty 2

Opening Window

Qty 2

Butt Hinge

Qty 2

Nail Bag (Same for all products)

Pre Assembly

Remove transportation
blocks from the bottom
of each panel before
beginning assembly. Each
Panel should have two

40mm Screw x 48

50mm Screw x 24

70mm Screw x 6

100mm Screw x 3

Felt Tacks x 72

16mm Screws x14

20mm Screw x 14

30mm Screw x 40

See 01OVLPA1010DDFW, 01OSBA1010DDFW-V1
& 01SHPA1010SDDOW-V1 Instuctions for Assembly