MEGUIAR'S M05 User Manual

M05, New Car Glaze (Original Formulation): M0516

__________________________________________________________________________________________

Page: 1 of 11

Safety Data Sheet

Copyright, 2011, Meguiar's, Inc. All rights reserved. Copying and/or downloading of this information for the purpose of
properly utilising Meguiar's, Inc. products is allowed provided that: (1) the information is copied in full with no changes
unless prior written agreement is obtained from Meguiar's, Inc., ve (2) neither the copy nor the original is resold or otherwise
distributed with the intention of earning a profit thereon.

Document group:

28-6093-0

Version number:

1.00

Revision date:

29/07/2011

Supersedes date:

Initial issue.

Transportation version number: 1.00 (29/07/2011)

This Safety Data Sheet has been prepared in accordance with the REACH Regulation (EC) 1907/2006 and its modifications.

SECTION 1: Identification of the substance/mixture and of the
company/undertaking

1.1. Product identifier

M05, New Car Glaze (Original Formulation): M0516

1.2. Relevant identified uses of the substance or mixture and uses advised against

Identified uses

Automotive.

1.3. Details of the supplier of the substance or mixture
Address:

Meguiars United Kingdon Limited, 3 Lamport Court, Heartlands, Daventry, Northants, NN11 8UF

Telephone:

[phone]

E Mail:

[e-mail]

Website:

www.meguiars.co.uk

1.4. Emergency telephone number

[phone]

SECTION 2: Hazard identification

2.1. Classification of the substance or mixture

Dangerous substances(67/548/EEC)/preparations(1999/45/EC) directive

This product is not classified as hazardous according to EU Directive 1999/45/EC.

2.2. Label elements

Dangerous substances(67/548/EEC)/preparations(1999/45/EC) directive

Symbols None.

Contains:

M05, New Car Glaze (Original Formulation): M0516

__________________________________________________________________________________________

Page: 2 of 11

No ingredients are assigned to the label.

Risk phrases None.
Safety phrases None.

Special provisions concerning the labelling of certain substances

Safety data sheet available for professional user on request.

Notes on labelling

R65 is not required on the label due to the product's viscosity.

Nota N applied for CAS 64742-46-7.
N; R51/53 classification of CAS 64742-47-9 not applied based on vendor data.

2.3. Other hazards

None known.

SECTION 3: Composition/information on ingredients

Ingredient CAS Nbr EU Inventory % by Wt Classification

Non hazardous ingredient Mixture 50 - 70
Kieselguhr, soda ash flux-calcined 68855-54-9 EINECS 272-

489-0

10 - 30

Distillates (petroleum), hydrotreated light 64742-47-8 EINECS 265-

149-8

7 - 13 Xn:R65 - Nota 4,H (EU)

R66; R67 (Self Classified)
N:R51/53 (Concawe no. 01/54)

Asp. Tox. 1, H304 (CLP)
STOT SE 3, H336 (Self

Classified)
Processed oil Trade Secret 1 - 5
Conditioners Trade Secret < 5
Distillates (petroleum), hydrotreated middle 64742-46-7 EINECS 265-

148-2

1 - 5 Nota H,N (EU)

Xn:R20-65; R66 (Self

Classified)

Nota H,N (CLP)

Acute Tox. 4, H332; Asp. Tox.

1, H304; STOT SE 3, H336 (Self

Classified)
Glycerin 56-81-5 EINECS 200-

289-5

1 - 5

Please see section 16 for the full text of any R phrases and H statements referred to in this section
Please refer to section 15 for the any applicable Notas that have been applied to the above components

For information on ingredient occupational exposure limits or PBT or vPvB status, see sections 8 and 12 of this SDS

SECTION 4: First aid measures

4.1. Description of first aid measures

Eye contact

Flush with large amounts of water. Remove contact lenses if easy to do. Continue rinsing. If signs/symptoms persist, get

M05, New Car Glaze (Original Formulation): M0516

__________________________________________________________________________________________

Page: 3 of 11

medical attention.

Skin contact

Wash with soap and water. If signs/symptoms develop, get medical attention.

Inhalation

No need for first aid is anticipated.

If swallowed

No need for first aid is anticipated.

4.2. Most important symptoms and effects, both acute and delayed

See Section 11.1 Information on toxicological effects

4.3. Indication of any immediate medical attention and special treatment required

Not applicable

SECTION 5: Fire-fighting measures

5.1. Extinguishing media

In case of fire: Use a fire fighting agent suitable for flammable liquids or gases such as dry chemical or carbon dioxide.

5.2. Special hazards arising from the substance or mixture

Closed containers exposed to heat from fire may build pressure and explode.

Hazardous Decomposition or By-Products

Substance Condition

Hydrocarbons. During combustion.
Carbon monoxide. During combustion.
Carbon dioxide. During combustion.
Irritant vapours or gases. During combustion.

5.3. Advice for fire-fighters

Water may not effectively extinguish fire; however, it should be used to keep fire-exposed containers and surfaces cool and
prevent explosive rupture.

SECTION 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures

For large spill, or spills in confined spaces, provide mechanical ventilation to disperse or exhaust vapours, in accordance with
good industrial hygiene practice. Warning: A motor could be an ignition source and could cause flammable gases or vapours
in the spill area to burn or explode.

6.2. Environmental precautions

Avoid release to the environment.

6.3. Methods and material for containment and cleaning up

Collect as much of the spilled material as possible.

6.4. Reference to other sections

Refer to Section 8 and Section 13 for more information

SECTION 7: Handling and storage

M05, New Car Glaze (Original Formulation): M0516

__________________________________________________________________________________________

Page: 4 of 11

7.1. Precautions for safe handling

Vapours may travel long distances along the ground or floor to an ignition source and flash back. For industrial or
professional use only. Avoid contact with oxidising agents (eg. chlorine, chromic acid etc.)

7.2. Conditions for safe storage including any incompatibilities

Store away from acids. Store away from oxidising agents.

7.3. Specific end use(s)

See information in Section 7.1 and 7.2 for handling and storage recommendations. See Section 8 for exposure controls and
personal protection recommendations.

SECTION 8: Exposure controls/personal protection

8.1 Control parameters

Occupational exposure limits

Ingredient CAS Nbr Agency Limit type Additional comments

Glycerin 56-81-5 Health and

Safety Comm.
(UK)

TWA(as mist):10 mg/m3

Silica, amorphous 68855-54-9 Health and

Safety Comm.
(UK)

TWA(as inhalable dust):6
mg/m3;TWA(as respirable
dust):2.4 mg/m3

Health and Safety Comm. (UK) : UK Health and Safety Commission
TWA: Time-Weighted-Average
STEL: Short Term Exposure Limit
ppm: parts per million
mg/m³: milligrams per cubic metre
CEIL: Ceiling

8.2. Exposure controls

8.2.1. Engineering controls

Use general dilution ventilation and/or local exhaust ventilation to control airborne exposures to below relevant Exposure
Limits and/or control dust/fume/gas/mist/vapours/spray. If ventilation is not adequate, use respiratory protection equipment.

8.2.2. Personal protective equipment (PPE)

Eye/face protection

The following eye protection(s) are recommended: Safety glasses with side shields.

Skin/hand protection

Gloves made from the following material(s) are recommended: Nitrile rubber.

Respiratory protection

Select one of the following approved respirators based on airborne concentration of contaminants and in accordance with
regulations:
Half face piece or full face air-purifying respirator with organic vapour cartridges.

SECTION 9: Physical and chemical properties

9.1. Information on basic physical and chemical properties