Megamaster Blaze-300, SIZZLER 400 Instructions Manual

800

700

600

500

400300

200

100

WARNING

To reduce the risk of fire, burn hazard or other injury,
read the manual carefully and completely before
using your grill.

WARNING

FOR OUTDOOR USE ONLY.

WARNING

This grill is not intended to be
installed in or on recreational
vehicles and/or boats.

LPGSASA Permit Number (1185/16/RSA-08/A)

www.megamaster.co.za

Manufactured in China · Distributed by Mega Group · PO Box 15, Woodlands, 0072, South Africa · Tel: [phone]

ASSEMBLY & OPERATING INSTRUCTIONS

Important: Read these instructions for use carefully so as to familiarize yourself with the

appliance before connecting it to its gas container. Keep these instructions for future

reference

2

Safety Information.............................................................................................................3

Package Contents List......................................................................................................7

Preparation.......................................................................................................................8

Assembly Instructions.......................................................................................................9

Installation Instructions......................................................................................................16

Operating Instructions.......................................................................................................19

Care and Maintenance......................................................................................................22

Troubleshooting................................................................................................................23

Warranty...........................................................................................................................25

Replacement Parts List.....................................................................................................27

Recipe List…………………………………………………………………………………………29

TABLE OF CONTENTS

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.

WARNING

1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.

2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.

3

SAFETY INFORMATION

WARNING – Hazards or unsafe

practices which COULD result in severe
personal injury or death.

CAUTION – Hazards or unsafe practices
which COULD result in minor personal
injury.

WARNING

CAUTION

WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIONS” section of this
manual.

WARNING

Do not use the grill if the odor of gas is present. Contact customer service at ([phone].

WARNING

Never attempt to use damaged equipment. See your local liquid propane dealer for repair.

WARNING

Check all gas supply fittings for leaks before each use. Do not use the grill until all connections have been
checked and do not leak. Do not smoke while leak testing. Never leak test with an open flame.

WARNING
Do not install this unit into combustible enclosures.
There should be a minimum clearance of 60 cm
from all sides to combustible materials.

WARNING
This grill is not intended to be installed in or on
recreational vehicles and/or boats.

WARNING

When lighting, keep your face and hands as far
away from the grill as possible.

WARNING
Maximum LP gas cylinder size is 30cm in diameter
by 52cm tall. Do not use a tank without an
approved LP gas 2,8 kPa regulator.

WARNING
Do not store grill indoors unless the cylinder is
disconnected. Do not store cylinder in a building,
garage, or any other enclosed area, and keep out
of reach of children at all times.

4

BEFORE LIGHTING

Inspect the gas supply hoses prior to turning on the gas. If there is evidence of cuts, wear, or abrasion, it must
be replaced prior to use. . It must be used with a 2, 8 kPa regulator that complies with the requirements

of SANS1237.

Only the pressure regulator and hose assembly supplied with the unit should be used. Never substitute
regulators for those supplied with the grill. Contact customer service for proper replacement.

Screw the regulator onto the cylinder. Leak check the hose and regulator connections with a soap and water
solution before operating the grill (See “Leak Testing” instructions on page 18).

Do not turn on the gas at the LP gas cylinder unless the gas hose is properly connected to the side burner gas
pipe system and all burner valves are in the “OFF” position.

Keep a spray bottle of soapy water near the grill and check the connections before each use.

WARNING
Failure to properly place the burner over the orifice
could cause a fire to occur behind and beneath the
valve panel, thereby damaging the grill and making
it unsafe to operate.

CAUTION
When using a match to light the grill, make sure to
use the attached lighting rod.

CAUTION
Before cleaning, make sure the gas supply and
control knobs are in the “OFF” position and the
burners have cooled.

CAUTION
The grill head is heavy and will require two or
more people to lift and position onto grill cart.

LP GAS CYLINDER WARNING

1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other
appliance.

2. A LP gas cylinder not connected for use should not be stored in the vicinity of this or any other appliance.

3. Do not store spare LP gas cylinders under or near this appliance.

4. Never fill the cylinder beyond 80 percent capacity.

5. Liquid propane cylinders must be provided with a listed overfilling prevention device.

6. If the information above is not followed exactly, a fire resulting in death or serious injury could occur.

WARNING
Spiders and insects can nest inside the burners
of the grill and disrupt gas flow.

Inspect the grill at least twice a year.

WARNING

Do not leave the grill unattended while cooking.

5

Do not use indoors.

SAFETY PRACTICES TO AVOID INJURY

When properly cared for, your grill will provide safe, reliable service for many years. However, extreme care
must be used as the grill produces intense heat that can increase accident potential.

When using this appliance basic safety practices must be followed, including the following:
Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service

should be referred to a qualified technician.
The grill is for outdoor use only.
The grill is not intended to be installed in or on recreational vehicles and/or boats.
Children should not be left alone or unattended in an area where the grill is being used. Do not allow children

to sit, stand or play on or around the grill at any time.
Do not store items of interest to children around or below the grill or cart. Do not allow children to crawl inside

the cart.
Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate,

burner or hot surface until it has cooled. The fabric could ignite, causing serious personal injury.
For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using

this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.
Only certain types of glass, ceramic, earthenware, or other glazed utensils are suitable for grill use. Other

types of materials may shatter with sudden temperature changes. Use only low or medium heat settings in
accordance with the manufacturer’s guidelines.

Do not heat unopened food containers as a build-up of pressure may cause the containers to burst.
Use a covered hand when opening the grill lid. Never lean over an open grill.
When lighting a burner, always pay close attention to what you are doing. Make certain you are aware of

which burner you are lighting so that your body and clothing remain clear of open flames.
When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas

become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot
surfaces may cause steam burns. Do not use a towel or bulky cloth in place of potholders. Do not allow
potholders to touch hot portions of the grill rack.

Grease is flammable. Let hot grease cool before attempting to handle it. Do not allow grease deposits to
collect in the grease tray at the bottom of the grill’s firebox. Clean the grease tray often.
Do not use aluminum foil to line the grill racks or grill bottom. This can severely upset combustion airflow or
trap excessive heat in the control area.

For proper lighting and performance of the burners, keep the burner ports clean. It is necessary to clean them
periodically for optimum performance. The burners will only operate in one position and must be mounted
correctly for safe operation.

WARNING
Do not try lighting this appliance without first
reading the “LIGHTING INSTRUCTIONS” section
of this manual.

6

WARNING

Do not install this unit in combustible enclosures. There should be a minimum clearance of 24 inches from all
sides to combustible materials.

Exercise caution when cleaning grill. To avoid steam burns, do not use a wet sponge or cloth to clean the grill
while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.

Never use a dented or rusty propane cylinder.
Turn off all control knobs and make certain the grill is cool before using any type of aerosol cleaner on or

around it. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal
parts to corrode.

Do not use the grill to cook excessively fatty meats or other products, which promote flare-ups.
Do not operate the grill under unprotected combustible constructions. Use only in well ventilated areas. Do not

use in buildings, garages, sheds, breezeways or other such enclosed areas.
This unit is intended for outdoor use only.
Keep the areas surrounding the grill free from combustible materials including, fluids, trash, and vapors such

as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. If the unit is
stored indoors, make sure it is cool.

Do not use briquettes of any kind in the grill.
This liquid propane gas grill is designed for optimum performance without the use of briquettes. Do not place

briquettes on the flame tamers as this will block the vent to the grill burners. Adding briquettes can damage
ignition components, thus voiding the warranty.

Keep the back of the cart free and clear from debris. Keep any electrical supply cord and the fuel supply hose
away from any heated surface.

Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront,
mountaintop, etc.), a windbreak will be required. Always adhere to the clearance specifications.

PLACEMENT OF THE GRILL

Outdoor cooking appliances should not be used under overhead combustible construction.
When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic

paths, and keeping gas supply lines as short as possible.
Place the grill in well-ventilated areas. Never place the grill in a building, garage, breezeway, shed or other

such enclosed areas. During heavy use, the grill will produce a lot of smoke.
Be aware that small insects, spiders, etc. can make nests in the mixing tubes and burners of the appliance

which can cause a burn back to occur.
In the event of burn back, where the flame burns back to the jet, immediately turn off the gas supply at the

burner control valve.
After ensuring that the flame is extinguished, re-light the appliance as described in below. Should the

appliance again burn back, close the valves and examine the mixing tube or burner for any obstruction. If there
are no obstructions and the burn back still occurs, call a technician to examine the appliance and make any
necessary repairs.

Do not make any unnecessary adjustments or modifications to this grill, a qualified LP gas technician should
do any adjustments.

7

PACKAGE CONTENTS LIST

A. Firebox Assembly -------­1pc.

B. Bottom Panel--------1pc.

C. Wheel-------------------2pcs.

D. Side Burner Shelf & Control
panel-------1pc.

E. Left Side Shelf & Control
Panel------1pc.

F. Cart Leg, Front Left--------1pc.

G. Cart Leg, Back Left-------­1pc.

H. Cart Frame ------------2 pcs.

I. Cart Leg, Front Right -----1pc.

J. Cart Leg, Back Right ----­1pc

K. Cart Caster Insert---------2
pcs.

L. Grease Tray----------1pc.

M. Side Burner Control Knob --

-----1pc.

N. Cooking Grids----------2pcs. O. Triangle Bracket, Left---1pc.

P. Triangle Bracket, Right-­1pc.

Z. Flame Tamers-------3pcs

R. Cart Beam ------------------1pc.

S. Front Panel ------------2pcs.

T. Warming Rack ----------1pc.

U. Side Tube Burner --------1pc.

100

200

300

400

500

600

700

800

8

V. 1.5 Volt “AA” Size Alkaline
Battery----------1pc.

W. Grease Box ----------1pc.

AA BB CC DD EE

Before beginning assembly, make sure all parts are present. Compare parts with package contents list
and diagram above. If any part is missing or damaged, do not attempt to assemble the product. Contact
customer service for replacement parts.

• Estimated Assembly Time: 40 minutes

• Tools Required for Assembly:

Phillips Screwdriver (not included) and Wrench (not included)

• Note: The right and left sides of the grill are designated as if you are facing the front of the grill.

HARDWARE CONTENTS - Pre-installed as noted in instructions that follow.

REF# Description QTY

AA 5/32-in. x 10-mm Truss Head Screw

32pcs.

BB 1/4-in. x 15-mm Truss Head Screw with washer

18pcs.
CC 1/4-in. Flat Washer 16pcs.
DD 1/4-in. Axle Flat Washer

2pcs.

EE 1/4-in. Nut

2pcs.

PREPARATION

Phillips Screwdriver

Wrench

9

1. Cart Assembly
a) Place the Cart Caster Inset (K) into the Cart Leg,

Front Left (F) and Cart Leg, Back Left (G).
As shown in Fig. 1.

b) Loosen, but do not remove the screws that

are pre-assembled on the Cart Leg, Front

Left (F) and Cart Leg, Back Left (G). Attach
Cart Leg, Front left (F) and Cart Leg, Back
Left (G) to Cart Frame (H) by aligning the holes
on the Cart Frame (H). Tighten the screws that
were loosened above.

Note: Make sure the flat side of Cart Frame (H)
faces out to the left when attaching.
As shown in Fig. 2.

c) Loosen, but do not remove the screws that are

pre-assembled on the Cart Leg, Front Right (I)

and Cart Leg, Back Right (J). Attach Cart Leg,

Front Right (I) and Cart Leg, Back Right (J) to

Cart Frame (H), by aligning the holes on the

Cart Frame (H). Tighten the screws that were

loosened above.
Note: Make sure the flat side of Cart Frame (H)

faces out to the right when attaching.
As shown in Fig. 3

ASSEMBLY INSTRUCTIONS

Fig. 1

Fig. 3

H

J

G

K

F

H

I

Fig. 2

G

F