Megamaster BakerBox Instructions Manual

BakerBox

TM

Multi-Purpose Pizza and Broiling Oven

ASSEMBLY & OPERATION INSTRUCTIONS

IMPORTANT: Read these instructions carefully so that you familiarize yourself with the appliance

before putting it to your gas or charcoal grill. Keep these instructions for future reference.

www.megamaster.co.za

•Manufactured in China· Tui Products Ltd, Mount Maunganui, NZ. Tel: [phone].

•

WARNING

To reduce the risk of fire, burn hazard or other injury, read the manual carefully and
completely before using your BakerBox.

WARNING

This BakerBox is not intended to be installed in or on recreational vehicles and/or boats.

df WARNING

For outdoor use only.

Table of Contents

Installation Final Check List

Operating Instructions

Care and Maintenance

Troubleshooting Instructions

Warranty Information

9

10-11

12

13

14

Safety Instructions

Package Content List

Hardware Contents

Exploded View

Parts List

Assembly Instructions

2-3

4

4

5

6

7-9

Safety Instructions

Please read the following instructions carefully before attempting to assemble, operate or
install the product. Failure to follow these instructions may result in serious bodily injury and/or
property damage. If you have questions regarding the product please call our Customer
Service Department at ([phone].

WARNING

This outdoor cooking appliance is not intended to be installed in or on boats and other
recreational vehicles.

2

Safety Instructions

1. During operation, always wear oven mitts or gloves as the BakerBox and the lid
handle get extremely hot during use.

2. BakerBox may only be used on an outdoor grill with proper air circulation around
the unit and where applicable keep the lid fully open during operation.

3. Children should not be left alone or unattended in an area where the BakerBox
is being used. Do not allow them to sit, stand or play in or around the BakerBox
while the grill is in operation.

4. Do not touch the BakerBox while the BakerBox is in operation or until the
BakerBox has cooled down after use.

5. Allow the BBQ and BB to heat up simultaneously. Only ignite/pre-heat BBQ
after placing BB on the grill in correct position.

6. Do not use any kitchen utensils that will melt, crack, or attempt to cause damage
to the BB unit. Refrain from using any plastic, silicone or glass while cleaning or
baking with the BB.

7. The BB will reach very high temperatures. Refrain from touching any part of the
BB until enough time is allowed for cooling as described in part 9 below.

8. Cleaning – heat BB for 15 min after food has been prepared. Remove any
leftover residue by carefully scraping off from the surface of the stones.

9. Allow for at least 90 minutes cool-off period, from when the grill is switched off.
When using a charcoal grill, allow for additional cooling time. No water or other
solvent/liquids may be used to cool-off the BB.

10. Do not place any combustible products/liquids inside or close to the BB while in
operation.

11. The BakerBox must never be used indoors or for heating purposes.

12. Do not repair or replace any part of the BakerBox unless specifically
recommended in this manual. All other service should be referred to a qualified
technician. This BakerBox is not intended to be installed in or on recreational
vehicles or boats.

13. Turn off grill controls and make sure the BakerBox is cool before using any type
of aerosol cleaner on or around the BakerBox. Some cleaners produce toxic
fumes or can ignite if applied to a hot surface.

3

Package Content List

Hardware Contents

REF# Description Specification QTY

A

W5/32” -32 x2/5”mm 8 Pcs.

Screw

Before beginning assembly, make sure all parts are present. Compare parts with package

contents list and diagram. If any part is missing or damaged, do not attempt to assemble

the product. Contact Customer Service for replacement parts.

Estimated Assembly Time: 10 minutes.

Tools for required for assembly: Philips Screwdriver(not included)

Philips
Screwdriver

1. Main lid and fire box assembly
(Qty. 1)

2. Top stone (Qty. 1)

3. Side stone (Qty. 2) 4. Rear stone (Qty. 1)

5. Bottom stone (Qty. 1)

6. Top stone support bracket,
front (Qty. 1)

7. Top stone support bracket,
rear (Qty. 1)

8. Stone support bracket,
side (Qty. 2)

4

Exploded View

1

2

3

4

5

6

7

8

4

9

10

11

12

13

14

15

16

15

17

18

14

18

19

19

20

5

Item

No.

Part Description

Warranty

coverage

(year)

Quantity

1 Main Lid 1 1

2 Temperature Gauge 1 1

3 Temperature Gauge seat 1 1

4 Main Lid screw 1 2

5 Main Lid left panel 1 1

6 Top Stone support bracket, rear 1 1

7 Top Stone 1 1

8 Main Lid right panel 1 1

9 Top Stone support bracket, front 1 1

10 Main Lid handle seat, left 1 1

11 Logo 1 1

12 Main Lid handle seat, right 1 1

13 Main Lid handle 1 1

14 Stone support bracket, side 1 2

15 Side Stone 1 2

16 Rear Stone 1 1

17 Bottom Stone 1 1

18 Main Lid block screw 1 2

19 Main Lid rubber bumper 1 2

20 Firebox Assembly 1 1

Part List

6

1. Loosen and remove the screws which were
pre-assembled, to separate firebox and Main
Lid as shown in Fig.1

2. Use 4 pieces screws (A), Top Stone front
support bracket (6), Top Stone rear support
bracket (7) to attach the Top Stone (2) to
main lid inside as shown in Fig.2

3. Tighten all the screws (A). As shown in Fig.3

Fig. 3

Assembly Instructions

Fig. 1

Fig. 2

6

2

7

7

Fig. 4

Fig. 5

Fig. 6

4. Place Bottom Stone (5), Side Stones (3),
Rear Stone (4) inside Firebox Assembly as
shown in Fig.4

5. Attach 2 pieces stone support brackets,
side (8) to Firebox Side Panel left and right
corner then tighten the 4 screws (A) as
shown in Fig.5

6. Re-attach the 2 screws which were
removed in Step 1, as shown in Fig.6

Assembly Instructions

8

3

3

4

5

8

Note: The main lid will self-engage on the

locking pin to hold the main lid in the
OPEN position as shown in Fig.7

Note: The BakerBoxTMfeatures a two-step

lift-and-release lid as shown in Fig.8

1. Lift lid straight up to release from
locking pin.

2. Close Lid slowly until lid comes to a rest.

Fig. 7

Installation Final Check List

1. Stones are secured into proper position with all included brackets and hardware.

2. The main lid can rest in the OPEN position as shown in Fig.7 above.

Your BakerBoxTMis ready to use!

Assembly Instructions

Fig. 8

9

How to use your BakerBoxTMon your gas grill.

1. Open the main lid of the gas grill that will be used with the BakerBoxTM.

2. Place the BakerBox

TM

on the cooking grid, centered above 3 burners (for 4 burner or larger
units, center BakerBoxTMon any 4 burners. Leave at least 15mm of space between the
front edge of the BakerBox

TM

and the front edge of the grill firebox. There should also be at

least 26mm of clearance between the BakerBox

TM

sides and the sides of the grill firebox.

3. With the gas grill main lid completely open and proper spaces surrounding the BakerBox

TM

listed in Step 2, light your grill by following the instructions that come with your gas grill.

4. Set all burners to HIGH and preheat the BakerBox for approx. 15 minutes.

5. Once the temperature crosses into the designated cooking zone (see Troubleshooting
Instructions if this doesn’t occur), place your uncooked pizza or other selected food in the
oven for baking. Use a dusting of flour on the pizza stone to ensure the pizza base does
not stick and to minimise the risk of overcooking the base.

6. Rotate the food as necessary to for even cooking.

Warning: Please read the following instructions carefully before attempt to
assemble, operate or install the product. The BakerBox becomes extremely hot and
can cause burning. Failure to comply with these instructions may result in serious
bodily injury. Always wear heat resistant oven mitts or gloves for outdoor cooking
when handling the BakerBox

TM

.

Fits a 57cm Kettle Charcoal Grill? Yes

Fits into a 50cm+ Gas Grill? Yes

Accepts a 22cm Pizza? Yes

Accepts a 30cm Pizza? Yes

22cm Pizza Average Cook Time? 5 min.

30cm Pizza Average Cook Time? 8 min.

Assembly Time? 10 min.

Note: Remove all packaging, including straps, before using the BakerBoxTM.

Gas Grill Operating Instructions

Fitment and Time Guide

(Times may vary by grill size)

10

Note: Remove all packaging, including straps, before using the BakerBoxTM.

How to use your BakerBoxTMon a 57cm charcoal kettle.

1. Remove the charcoal kettle main lid. You can hang or store the main lid, as it will not be
used while using the BakerBoxTM. Remove the cooking grid.

2. Place charcoal briquettes or lump charcoal as needed (approx. 1.5kg), in order to get a
good even coverage of coals in your charcoal tray. Make sure to follow the instructions
that come with your charcoal for lighting instructions.

3. Ensure that there are sufficient coals to enable cooking temperature to be achieved and
maintained for cooking the pizza.

4. IMPORTANT: when adjusting/opening the hood, be careful not to dis-lodge from the
BBQ

5. After your coals are red hot, spread the coals for optimum heat distribution. Make sure
to follow the instructions that come with your charcoal for safety instructions on working
with hot charcoal. We recommend to place LESS coals in the center in order to achieve
proper heat distribution for the desired BakerBoxTMcooking zone. Refer to Figure 9.

6. Re-install cooking grids. Place the BakerBoxTMon the cooking grid to start pre-heating.

7. Once the temperature reaches the proper BakerBoxTMcooking zone, you may now
place your uncooked pizza or alternate food into the oven for baking.

8. Rotate the food as necessary to for even cooking.

Charcoal Kettle Operating Instructions

Warning: Please read the following instructions carefully before attempt to
assemble, operate or install the product. The BakerBox becomes extremely hot and
can cause burning. Failure to comply with these instructions may result in serious
bodily injury. Always wear heat resistant oven mitts or gloves for outdoor cooking
when handling the BakerBoxTM.

11

Fig. 10

Fig. 9

Ranch Chicken Pizza, with Bacon & Artichoke

Care and Maintenance

Cleaning

1. Turn off the gas supply, and make sure all the knobs are in the “OFF” position.

2. Wait for the grill and BakerBox to cool.

3. Clean the exterior of the BakerBox with a wire brush. Use a metal scraper for stubborn

stains.

4. Wipe outer housing with a soft damp cloth only when completely cooled.

5. Clean clogged port with a straightened paper clip. Never use a wooden toothpick as it

may break off and clog the port.

Caution

1. Keep outdoor cooking gas appliance area clear and free from combustible materials,

gasoline and other flammable vapors and liquids.

2. Do not obstruct the flow of combustible and ventilation air.

3. Keep the ventilation openings of the cylinder enclosure free and clear from debris.

4. Never leave the BakerBox unattended during use.

12

Megamaster Gourmet Pizza Recipe

Dough

1½ cup warm water
2 tablespoons sugar
2 x 8g pkt. instant dry yeast
3½ cup flour
1 teaspoon salt
2 tablespoons tomato paste

Gourmet Toppings of your choice

Cooked Chicken
Bacon or Parma Ham
Artichoke
Peppadews

1. Preheat the BakerBox to desired temperature.

2. To make the dough: Mix all the ingredients together until smooth. Set aside and allow to raise for 10 minutes

3. Roll out dough and place in the pizza pan

4. Spread with tomato paste

5. Arrange other ingredients

6. Insert pizza directly onto the bottom stone of the BakerBox

7. Bake in the Baker Box for 4-7 minutes until dough is golden brown.

Problem Solution

Can I close the lid of my grill
while using the BakerBox?

We advise you to keep to lid of your grill in the fully opened
position while using the BakerBox in order to protect you
and your grill. If you fully or partially close your grill lid while
using the BakerBox, it may cause components of your grill
to over-heat which may result in damage to your grill and/or
bodily injury should you touch the overheated components.

How do I clean the BakerBox? After baking your final pizza, you can clean the BakerBox

by letting the burners remain on high for approximately 15
minutes. Any residue should burn off and remains can be
scrapped off and pushed to the back of the oven by using a
long handled BBQ brush. Once the oven has cooled
completely, a damp cloth can be used to wipe off any char
left in the oven. The stone will remain blackened and/or
darkened which is natural. If this does not clean the stone
to your satisfaction, you can also remove the support
brackets and flip the base stone over and replace the
support brackets, This will give you a clean base stone to
use and the next time you use the BakerBox, any
remaining residue will burn off.

My Temperature Gauge is not
reaching the cooking zone
(red zone).

3B Gas Grill

- Make sure your BakerBox

TM

is centered on the burners

4B (or larger) Gas Grill

- Make sure your BakerBox

TM

is centered above 4 burners

57cm Charcoal Kettle

- Make sure your fuel (lump charcoal or briquettes) are

spread evenly across the pan, leaving LESS in the center.

In all cases, it will take the temperature gauge about 20
minutes to reach the desired cooking zone. The needle will
continue to rise, the longer the BakerBoxTMis on the grill.

Some BBQs may not reach the desired cooking zone, this
will not affect the performance of your BakerBoxTM, start
cooking after preheating for 20 minutes.

Before calling Customer Service

If the BakerBox

TM

does not function properly, use the following check list before contacting

your dealer for service. You may save the cost of a service call.

Preheating: It is necessary to preheat the BakerBox before cooking pizza, depending on the
type of food and the cooking temperature. The grill lid should always remain open during the
use of the BakerBoxTM.

Troubleshooting Instructions

13

14

Problem Solution

My pizza base burns before
the toppings are cooked
correctly.

BBQ temperature and type of pizzas vary, you may need to
adjust the temperature and baking time accordingly. Your
BakerBoxTM is designed for homemade pizza bases which
require high heat, pre-made or frozen pizzas may require a
lower cooking temperature (yellow zone).

Your Megamaster BakerBoxTMcarries a one (1) year limited warranty.

The warranty period is valid from the date of purchase. Please retain your proof of
purchase.

This is subject to correct assembly, use, storage and regular maintenance of the product.

It is the responsibility of the product owner to safely store and protect the BakerBox from

the elements.

This warranty does not cover the following:

- Rust

- Corrosion

- Discolouration

- Damage caused by improper use not according to instructions set out above

•Please contact our Customer Service Department Tui Products Ltd, Mount Maunganui,
NZ. Tel: [phone].

•

.

Warranty Information

14

FOR OUTDOOR USE ONLY

WARNING

Read and follow all Safety, Assembly, and Use & Care Instructions in this guide before
assembling and cooking with this BakerBoxTM.

Failure to follow all instructions in this Use & Care Guide may lead to fire or explosion, which
could result in property damage, personal injury or death.

www.megamaster.co.za

•Manufactured in China· Tui Products Ltd, Mount Maunganui, NZ. Tel: [phone].

•

BakerBox

TM

15