Megamaster 570 Elite Instructions Manual

ASSEMBLY& OPERATING INSTRUCTIONS

Important: Read these instructions for use carefully so as to familiarize yourself with the

appliance before using your charcoal kettle grill. Keep these instructions for future reference

.

WARNI NG

To reduc e t he ri s k of f ire burn haz ard or ot her injury, read t he manual c aref ully and
completely before using your charcoal kettle.

df WARNI NG

FOR OUTDOOR USE ONLY.

www.megamaster.co.za

Manuf actu red in China· Di strib ut ed by Mega Group · PO B ox 15, Woodland s, 0 027, So ut h Af rica· Tel: [phone]

Installation Final Check List

Operating Instructions

Care and Maintenance

Trouble Shooting

Warranty Information

16

17-20

20

21

22

Safety Instructions

Package Content List

Explode View

Part List

Hardware Contents

Assembly Instructions

2-3

4-5

6

7

8

9-15

2

Please read the following instructions carefully before attempting to assemble,operate or
install the product.Failure to follow these instructions may result in serious bodily injury
and/or property damage. If you have questions regarding the product please call customer
service at ([phone].

WARNI NG

This outdoor cooking appliance is not intended to be installed in or on boats and other
recreational vehicles.

Safety Instructions

Tabl e o f Con tents

3

1. The charcoal kettle must never be used indoors or for heating purposes.

2. Do not repair or replace any part of the charcoal kettle unless specifically recommended in
this manual. All other service should be referred to a qualified technician. This charcoal
kettle is not intended to be installed in or on recreational vehicles or boats.

3. Children should not be left alone or unattended in an area where the charcoal kettle is
being used. Do not allow them to sit, stand or play in or around the charcoal kettle at any
time.

4. Do not touch the charcoal kettle while the charcoal kettle is in operation, or until the
charcoal kettle has cooled down after use.

5. Do not use gas oline, alcohol, or other highly volatile fluids to ignite charcoal. If using
charcoal starter fluid(not recommended),remove any fluid that may have drained through
the bowl vents before lighting the charcoal.

6. Do not add charcoal starter fluid or charcoal infused with charcoal lighter fluid to already
hot or warm charcoal. Cap starter fluid after use and place a safe distance away from the
grill.

7. Use heat-resistant braai mitts or gloves while cooking, adjusting air vents(dampers), adding
charcoal and handling thermometer or lid.

8. Extinguish charcoal when finished cooking. To extinguish, close bowl vent and lid damper
and place lid on bowl. Do not use water to control flare-ups or to extinguish charcoal.

9. Never dump hot charcoal where it might be stepped on or be a fire hazard. Never dump
ashes or charcoal before they are fully extinguished.

10. Do not use this charcoal kettle unless all parts are in place. This charcoal kettle must be
properly assembled according to the assembly instructions. Improper assembly may be
dangerous.

11. Do not leav e the charcoal kettle unattended while cooking.

12. Do not operate the charcoal kettle under unprotected combustible constructions. Use only
in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such
enclosed areas.

13. Keep the area surrounding the charcoal kettle free from combustible materials including,
fluids, trash and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow
of combustion and ventilation air.

Safety Instructions

Package Content List

1

4

Bowl ---1pc

2

Leg cap, top ---3pcs

3

Top l eg ---3pcs

4

5

6

7

8

9

10

Bottom leg C---1pc

Bottom leg B ---1pc

Bottom leg A ---1pc

Cart bottom grate

---1pcs

Wheel ---2pcs

Wheel cap ---2pcs Lid handle assembly ---1pc

Package Content List

5

11 12

13

14

15

16

17

18

19

20

Bowl vent assembly ---1pc Ash catcher ---1pc

Charcoal grate ---1pc

Cooking grate ---1pc

Temperature gauge ---1pc

Lid assembly ---1pc

Lid hook ---1pc

Lid handle decorative sheet

---1pc

Bowl handle assembly---1pc

Heat shield piece---1pc

Parts Diagram

14

15

16

17

18

26

23

25

27

28

29

24

12

19

21

22

11

10

9

5

3

2

1

8

6

7

13

20

4

6

7

No. Part(Descreption)

Warranty

coverage(year)

QTY

1

Lid handle assembly

1

1

2

Mica plate

1

2

3

Lid handle decorative sheet

1

1

4

Heat shield piece

1

1

5

Lid damper

1

1

6

Temperature gauge

1

1

7

Lid

1

1

8

Lid hook

1

1

9

Hinged cooking grate

1

2

10

Cooking grate

1

1

11

Charcoal grate

1

1

12

Bowl handle assembly

1

1

13

Cooking grate support bracket

1

3

14

Bowl

1

1

15

Bowl pad

1

3

16

Leg cap, top

1

3

17

Top l eg as sembly

1

3

18

Bottom leg C

1

1

19

Bowl vent assembly

1

1

20

Handle of bowl vent

1

1

21

Ash catcher hook

1

2

22

Ash catcher

1

1

23

Bottom leg A

1

1

24

Leg cap, bottom

1

1

25

Cart bottom grate

1

1

26

Bottom leg B

1

1

27

Wheel

1

2

28

Wheel axle

1

2

29

Wheel cap

1 2

Part List