MBS Thermo Magnum PLUS Installation Manual

INSTRUCTIONS FOR INSTALLATION AND MANUAL
Solid fuel cooker for central heating THERMO MAGNUM PLUS

To respected customer,

We are very pleased for your trust and your decision to buy our product.
You made a good choice, because Thermo Magnum has technical characteri sti c s

which classify it into the very top of its class, providing advantage within its
competition.

Please, read carefully this instructions before you use Thermo Magnum, in order to
find hints and tips for proper handling and maintenance.
We also believe that you will put your signature in the book of satisfied customers of
our products.

"Milan Blagojević" AD
Smederevo

CONTENTS

Warning before use ................................................................1

Cooker description...................................................................2

Installation................................................................................4

Installation of the stove into the water heating system ............6

Managing operation…..............................................................10

Ignition and lighting... ...................…….................……………..11

Cleaning and mainten ance.......................................................12

General notes ..........................................................................13

Advices for environmental protection .......................................13

WARNING BEFORE USE

In order to put cooker Thermo Magnum in proper operation mode, it is important to
read this instructions and strictly observe instructions for use a nd ma nual .

For combustion, use s ol id fu els like wood and briquettes. For maximal performance
of the cooker, use dry wood (max. humidity 20%).

It is forbidden to put explosive devices and materials into the burner or onto the
cooker hotplate.

It is forbidden to keep inflammable materials within the close vicinity of the cooker.
For proper combustion, within the normal operational mode, draught in the chimney

should be 15-17 Pa. In case if draught is higher then 20Pa, it is necessary to install
chimney flap.

Room in which cooker is located should be regularly ventilated due to flow of fresh
air necessary for combustion.

Parts of the cooker are heated within period of operation and appropriate handling
precaution is necessary. Do not allow children to handle and play in the vicinity of the
cooker.

Do not allow handling with the cooker to the persons with limited physical and
psychical abilities.

Do not allow pets to be close to the device.
Only spare parts approved by the manufacturer may be installed onto the cooker.

One may not make any changes to the furnace.
Upon the first heating, smoke and various scents may occur, especially on the

surfaces protected with the color and other anti-corrosive primers. Ventilate the
room.

Thermal regulator is integral part of the cooker and set-up at the factory. Do not
make any adjustments of thermal regulator by yourself.

When adding fuel, open fire door for only few degrees, wait 4-5 seconds until
pressure in the burner and room comes equal, then open it wide very slowly. Do not
open the door abruptly, so when flame is strong in the burner it may come out of the
burner. Do not open fire door unnecessarily, always paying attention to open it when
flame is weak.

In case of non-observance of these instructions for use, manufacturer will not
be liable for any damage on cooker.

COOKER DESCRIPTION

Figure 1. Integral parts of the Thermo Magnum cooker
1 – hotplate

2 – secondary air regulation
3 – fire door
4 – grate
5 – ashtray door
6 – ashtray
7 – fume outlet
8 – oven door
9 - thermometer
10 - drawer
11 – thermo-regulator button

Solid fuel cooker for central heating Thermo Magnum is made and tested accor ding
to the European standard EN 12815. Figure 1 shows appearance of cooker with
integral parts important for handling and use. Table 1 gives its technical
characteristics.