Maytag UMTK27B, UMTK30S, UMTK30W, AMC2206BAB, AMC2206BAS Installation Instructions

...
MICROWAVE OVEN BUILT-IN TRIM KIT
INSTALLATION INSTRUCTIONS
Built-In Trim Kit Models UMTK27, UMTK30
UL listed for use over built-in electric ovens:
27 (68.6 cm): MEW5527, MEW6527
30 (76.2 cm): MEW5530, MEW6530, JJW8130DD, JJW8330DD, JJW9130DD, JJW9330DD
Table of Contents
INSTALLATION INSTRUCTIONS ..................................................... 2
Tools and Parts............................................................................... 2
Location Requirements................................................................... 2
Minimum Cutout Dimensions ......................................................... 2
Trim Kit Frame Dimensions ............................................................ 2
Electrical Requirements.................................................................. 3
Microwave Oven Preparation ......................................................... 3
Duct Assembly................................................................................ 3
Microwave Oven Installation........................................................... 4
Install Top and Bottom Brackets.................................................... 4
Install Trim Kit Frame...................................................................... 4
MICROWAVE OVEN SAFETY
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages.
This is the safety alert symbol.
This symbol alerts you to potential hazards that can kill or hurt you and others.
All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”
These words mean:
You can be killed or seriously injured if you don't immediately
DANGER
WARNING
All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can happen if the instructions are not followed.
follow instructions.
can be killed or seriously injured if you don't
You instructions.
follow
W10308503A
INSTALLATION INSTRUCTIONS
Tools and Parts
Tools Needed
Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here.
Measuring tape
Pencil
Phillips screwdriver
Drill
7/64" drill bit
Ta pe
Parts Supplied
Duct base Trim kit frame
2
1
Left duct Templates 1 and 2
Bottom bracket Top bracket
13/16" screws (2) 9/16" screws (16) 1/2" screws (4 - painted)
Location Requirements
The microwave oven may be installed over a built-in oven. If installing over a built-in oven, make sure there is a minimum of 3" (7.6 cm) between the top of the lower oven cutout and the microwave oven cutout floor.
The microwave oven may also be installed in a cabinet by itself (without a built-in oven below). For best usability, we recommend a minimum distance of 36" (91.4 cm) from the floor to the cutout floor.
Make sure the surrounding cabinetry has clearance to open and close freely. Allow a clearance of at least 1" (2.5 cm) below the cutout floor (3" [7.6 cm] for installation above a built-in oven), and a clearance of at least 2" (5.1 cm) above the cutout opening.
2"
(5.1 cm)
A
B
B
2"
(5.1 cm)
Minimum Cutout Dimensions
23³⁄₄"
(60.3 cm)
1⁹⁄₁₆"
(4.0 cm)
16⁷⁄₈"
(42.9 cm)
3"
(7.6 cm)
WidthWidth
25" (63.5 cm)
(1.8 cm)
A
¹¹⁄₁₆"
B
A. Trim kit frame overhang B. Cutout for lower oven
NOTES:
Height, width and depth measurements have ±1/16" (2 mm)
tolerance.
3" (7.6 cm) minimum dimension is from lower oven cutout
ceiling to microwave oven cutout floor.
Trim kit frame extends 11/16" (1.8 cm) below, and 1⁹⁄₁₆"
(4.0 cm) above the cutout opening.
Trim Kit Frame Dimensions
26
⁷⁄₈
" (68.3 cm)*
29
³⁄₄
" (75.6 cm)**
" (3.7 cm)*
19¹⁄₈"
(48.6 cm)
24" (61.0 cm)
*27" (68.6 cm) trim kit
**30" (76.2 cm) trim kit
1⁷⁄₁₆
" (7.3 cm)**
⁷⁄₈
2
⁷⁄₈"
(2.2 cm)
3" (7.6 cm)
1"
(2.5 cm)
2
D
E
A. Upper cabinet B. Microwave oven cutout C. Lower oven cutout
3"
(7.6 cm)
C
36"
(91.4 cm)
D. Lower cabinets
E. Floor
Loading...
+ 2 hidden pages