Maytag UCTK27ST Installation Guide

MICROWAVE OVEN BUILT-IN TRIM KIT

INSTALLATION INSTRUCTIONS

Built-In Trim Kit Models UCTK27, UCTK30

UL listed for use over built-in electric ovens:

27 (68.6 cm): MEW5527, MEW6527

30 (76.2 cm): MEW5530, MEW6530, AEW3530, AEW4530, JJW8130DD, JJW8330DD, JJW9130DD, JJW9330DD

Table of Contents

MICROWAVE OVEN SAFETY ..................................................1

INSTALLATION INSTRUCTIONS.............................................1

Tools and Parts ...................................................................... 1

Location Requirements..........................................................2

Trim Kit Frame .......................................................................2

Minimum Cutout Dimensions................................................. 2

MICROWAVE OVEN SAFETY

Your safety and the safety of others are very important.

We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages.

This is the safety alert symbol.

This symbol alerts you to potential hazards that can kill or hurt you and others.

All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”

These words mean:

Electrical Requirements ..........................................................2

Microwave Oven Preparation .................................................3

Bottom Duct Assembly...........................................................3

Microwave Oven Installation...................................................4

Install Top and Bottom Brackets ............................................4

Install Trim Kit Frame ..............................................................4

You can be killed or seriously injured if you don't immediately

DANGER

WARNING

All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can happen if the instructions are not followed.

follow instructions.

can be killed or seriously injured if you don't

You instructions.

INSTALLATION INSTRUCTIONS

Tools and Parts

Tools Needed

Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here.

■ Measuring tape

■ Pencil

■ Phillips screwdriver

■ Drill

■ 7/64" drill bit

■ Ta pe

Parts Supplied

Duct base Bottom duct Rear duct bracket

Aluminum tape Rear duct Upper duct

Templates 1 and 2 Top bracket Bottom bracket

W10308504A

Trim kit frame

13/16" screws 9/16" screws 1/2" screws

(2) (16) (4 - painted)

Location Requirements

The microwave oven may be installed over a built-in oven. If installing over a built-in oven, make sure there is a minimum of 3" (7.6 cm) between the top of the oven cutout and the microwave oven cutout floor.

The microwave oven may also be installed in a cabinet by itself (without a built-in oven below). For best usability, we recommend a minimum distance of 36" (91.4 cm) from the floor to the cutout floor.

Make sure the surrounding cabinetry has clearance to open and close freely. Allow a clearance of at least 1" (2.5 cm) below the cutout floor (3" [7.6 cm] for installation above a built-in oven), and a clearance of at least 2" (5.1 cm) above the cutout opening.

NOTES:

■ Height, width and depth measurements have ±1/16" (2 mm)

tolerance.

■ 3" (7.6 cm) minimum dimension is from lower oven cutout

ceiling to microwave oven cutout floor.

■ Trim kit frame extends 11/16" (1.8 cm) below, and 1⁹⁄₁₆"

(4.0 cm) above the cutout opening.

Electrical Requirements

WARNING

(5.1 cm)

(2.5 cm)

A. Upper cabinet B. Microwave oven cutout C. Lower oven cutout

Trim Kit Frame Dimensions

19¹⁄₈"

(48.6 cm)

*27" (68.6 cm) trim kit

**30" (76.2 cm) trim kit

Minimum Cutout Dimensions

23³⁄₄"

(60.3 cm)

16⁷⁄₈"

(42.9 cm)

(7.6 cm)

A. Trim kit frame overhang B. Cutout for lower oven

(91.4 cm)

⁷⁄₈

" (68.3 cm)*

³⁄₄

" (75.6 cm)**

24" (61.0 cm)

25" (63.5 cm)

36"

D. Lower cabinets

E. Floor

WidthWidth

1⁷⁄₁₆

" (7.3 cm)**

⁷⁄₈

(2.2 cm)

3" (7.6 cm)

1⁹⁄₁₆"

(4.0 cm)

¹¹⁄₁₆"

(1.8 cm)

" (3.7 cm)*

⁷⁄₈"

(5.1 cm)

(7.6 cm)

Electrical Shock Hazard

Plug into a grounded 3 prong outlet.

Do not remove ground prong.

Do not use an adapter.

Do not use an extension cord.

Failure to follow these instructions can result in death, fire, or electrical shock.

Observe all governing codes and ordinances.

Required:

■ A 120 Volt, 60 Hz, AC only, 15- or 20-amp electrical supply

with a fuse or circuit breaker.

Recommended:

■ A time-delay fuse or time-delay circuit breaker.

■ A separate circuit serving only this microwave oven.

GROUNDING INSTRUCTIONS

■

For all cord connected appliances:

The microwave oven must be grounded. In the event of an electrical short circuit, grounding reduces the risk of electric shock by providing an escape wire for the electric current. The microwave oven is equipped with a cord having a grounding wire with a grounding plug. The plug must be plugged into an outlet that is properly installed and grounded.

WARNING: Improper use of the grounding plug can

result in a risk of electric shock. Consult a qualified electrician or serviceman if the grounding instructions are not completely understood, or if doubt exists as to whether the microwave oven is properly grounded.

Do not use an extension cord. If the power supply cord is too short, have a qualified electrician or serviceman install an outlet near the microwave oven.

SAVE THESE INSTRUCTIONS

Microwave Oven Preparation

1. Unplug microwave oven before proceeding with installation.

2. Remove any loose items inside microwave oven.

+ 2 hidden pages