Maytag MGC5430ADQ, MGC5430ADW, MGC5430ADB, MGC5430ADC Installation Guide

INSTALLER: LEAVE THESE INSTRUCTIONS WITH THE APPLIANCE

GAS INSTALLATION MANUAL

30" And 36" Built-in Cooktop

PLEASE KEEP THIS MANUAL FOR FUTURE REFERENCE

THE MANUAL IS INTENDED TO ASSIST IN THE INITIAL INSTALLATION AND ADJUSTMENTS OF THE RANGE.

SPECIAL WARNING

ONLYQUALIFIED PERSONNELSHOULDINSTALL OR SERVICETHIS COOKTOR

READ "SAFETY INSTRUCTIONS"IN USE & CARE BOOK BEFORE USING COOKTOP.

IMPROPER INSTALLATION,ADJUSTMENT,ALTERATION,SERVICE, MAINTENANCE OR USE
OF COOKTOP CAN RESULT IN SERIOUS INJURY OR PROPERTY DAMAGE.

IMPORTANT

Remove all packing material and literature from cooktop before connecting gas and electrical supply.
* NOTE: 30 inch dimension between cooking top and wall cabinet shown on illustration may be reduced to not less than

24 inches when the wall cabinets in a domestic home are protected with fireproof materials in accordance with American
National Standards - National Fuel Gas Code or in mobile homes when they are protected with fireproof materials in

accordance with the Federal Standard for Mobile Home Construction and Safety.
To eliminate the risk of burns or fire by reaching over heated surface units, cabinet storage space located above the

surface units should be avoided. If cabinet storage is to be provided, the risk can be reduced by installing a range hood
that projects horizontally a minimum of 5 inches beyond the bottom of the cabinets.

A WIRING DIAGRAM IS ENCLOSED IN THE ENVELOPE WITH THIS BOOKLET; ALSO THERE IS A DIAGRAM GLUED

TO THE UNIT.

MODEL AND SERIAL NUMBER LOCATION

The serial plate for your cooktop is located on the extreme bottom of unit, visible from inside cabinet when installed. In addition
to the model and serial number, it tells you the ratings of the burners and type of fuel and pressure for which the cooktop was

adjusted when it left the factory.
CAUTION: SOME CABINETS AND BUILDING MATERIALS ARE NOT DESIGNED TO WITHSTAND THE HEAT

PRODUCED BY THE NORMAL SAFE OPERATION OF A LISTED APPLIANCE. DISCOLORATION OR DAMAGE, SUCH

AS DELAMINATION, MAY OCCUR.

YOUR COOKTOP MAY NOT BE EQUIPPED WITH SOME OF THE FEATURES REFERRED
TO IN THIS MANUAL.

8101 P121-60

(05-99-03)

INSTALLATION DRAWINGS

FOR SEALED BURNER MODELS

Clearances To Combustible Construction

These units can be installed in a cabinet made of wood or
other combustible material.

Maximum depth of cabinets installed above cooktop to be 13

inches.
*30" min. See NOTE on front page.
3 inches minimum to any combustible side wall.

30" AND 36" SEALED BURNER WITH PORCELAIN TOP

25" NORMAL

CABINET

TOP DEPTH. _-

IN

6 inches minimum spacing between individual top sections

in a dual installation.

DIM "C"

MIN

COMBUST I BLE

WALL

PROVIDE FOR 120 ELECTRI

GROUNDED) OUTLET IN CENTER

F CABINET BELOW COOKTOP

OVERALL WIDTH

OF UNIT A B C

30" 2" MIN. 1" MtN. 30" MIN.
36" 1 112" MIN. 1 112" MIN. 36" MIN.

DIM "B"

36"

HE I GHT OF

CAB I NET

"-4

-2-

30" SEALED BURNER WITH GLASS TOP

13 _ MAX.

COMBUSTIBL_

WALL

25" NORMAL

CABINET TOP DEPTH

f

3G _ HEIGHT
OF CABINET

MIN.

.,L

I

MIN. [

COMBUSTIBLE

WALL

IB a MIN,

jl _ _

PROVIDE FOR I_O VAC
ELECTRIC OUTLET \

(GROUNDED) IN _

CENTER OF CABINET

BELOW COOKTDP. OF CABINET \ \

36" SEALED BURNER WITH GLASS TOP

COMBUSTIBLE

WALL

25" NORMAL

CABINET TOP DEPTH

36" HEIGHT I" NIN.
OF CABINET

COMBUSTIBLE

WALL

IB" NIN,

PROVIDE FOR 120 VAC

ELECTRIC OUTLET

(GROUNDED) IN
CENTER OF CABINET
BELOW COOKTOP,

OF CABINET

-3-

Cutout Dimensions

30" SEALED BURNER WITH PORCELAIN TOP

NOTE= WHEN INSTALLED OVER A

30" WALL OVEN, ATTACH 90" ELBOW

TO SURFACE UNIT PIPING AND LOCATE

REGULATOR & SHUTOFF VALVE IN
ADJACENT (ACCESSIBLE) CABINET.

REGULATOR SUPPLIED WITH
UNIT AND SHUTOFF VALVE
MUST BE INSTALLED IN AN
ACCESSIBLE LOCATION.

3/8" DEPTH

REGULATOR INLET IS

FEMALE 1/2" NPT.

1 5/8" MIN.

*MINIMUM TO ANY

COMBUSTIBLE WALL
ABOVE COOKTOP.

FRONT OF UNIT

28 5/16"

3 7/8"

MIN,

36" SEALED BURNER WITH PORCELAIN TOP

*MINIMUM TO ANY COMBUSTIBLE

WALL ABOVE COOKTOP.

*2 1/8" MIN.--

193

35/16" DEPTH

REGULATOR SUPPLIED WITH
UNIT AND SHUTOFF VALVE

MUST BE INSTALLED IN AN
ACCESSIBLE LOCATION.

REGULATOR INLET IS

FEMALE 1/2" NPT.

34 7/8" MIN.

7/8"

-4-

36" SEALED BURNER WITH GLASS TOP

21 "

36"

I
i

• 2 5IS"

MIN.

* MINIMUM TO ANY

COMBUSTIBLE WALL
ABOVE COOKTOP

19

-_' MIN,

NOTE: ADD CLEARANCE INSIDE FOR

* 3 7/8" MIN.

GAS & ELECTRICAL CONNECTIONS.

30" SEALED BURNER WITH GLASS TOP

3 3/B"
DEPTH

21" 30" NOTE: WHEN INSTALLED OVER A

30" WALL OVEN, ATTACH 90" ELBOW
TO SURFACE UNIT PIPING AND LOCATE

WITH UNIT AND A SHUTOFF

VALVE MUST BE INSTALLED

IN AN ACCESSIBLE LOCATION.

NOTE: REGULATOR SUPPLIED

COOKTOP SUPPLIED WITH

1/2" NPT FEMALE

INLET ON REGULATOR.

2" TO _ OF PIPE

REGULATOR & SHUTOFF VALVE IN
ADJACENT (ACCESSIBLE) CABINET.

19

28 3/8"

* MINIMUM TO ANY

COMBUSTIBLE WALL
ABOVE COOKTOP

* 3 7/8" MIN.

-5-

NOTE: REGULATOR SUPPLIED

WITH UNIT AND A SHUTOFF
VALVE MUST BE INSTALLED

IN AN ACCESSIBLE LOCATION.

COOKTOP SUPPLIED WITH

1/2" NPT FEMALE

INLET ON REGULATOR,

2" TO _ OF PIPE

3 MIN.

NOTE: ADD CLEARANCE INSIDE FOR
GAS & ELECTRICAL CONNECTIONS.