Max Burton 1214 User Manual

PRODUCT NAME

A. PRODUCT NAME

USE OF PRODUCT

LIMITATIONS

COMPANY

ADDRESS EMERGENCY PHONE NUMBER

SYMBOLS

SIGNAL WORDS

PRECAUTIONARY STATEMENTS

DISPOSAL

SAFETY DATA SHEET

1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION

B. RECOMMENDED USE OF PRODUCT AND LIMITATIONS

B. LABEL ELEMENTS, INCLUDING PRECAUTIONARY STATEMENTS

P501 Depose of contents/container in accordance with local/regional /national regulations

P271 Use only outdoors or in a well-ventilated area

STORAGE

P403 Store in a well-ventilated place

P403+P233 Store in a well-ventilated place. Keep container tightly closed

P405 Store locked up

P410+P403 Protect from sunlight. Store in a well ventilated place

BUTANE GAS CARTRIDGE

For use Only in Portable Gas Appliances

C. MANUFACTURER,SUPPLIER

2. HAZARDS IDENTIFICATION

A. CLASSIFICATION

Flammable gases : Category 1

Gases under pressure : Liquified gas

Specific target organ toxicity - single exposure : Category 3(Anesthesia effects) Extremely flammable

DAE RYUK CAN CO.,LTD. ,MAXSUN CO.,LTD

5th Floor, Korean Women Entrepreneurs Asso, Bldg., 221, Yeoksam-ro, Kangnam-Ku, Seoul, KOREA

+82-2-6003-0600, +82-2-6003-0700

DANGER,WARNING

HAZARD STATEMENTS

H220 Extremely flammable gas

H280 Contains gas under pressure ; May explode if heated

H336 May cause drowsiness or dizziness

RESPONSE

P304+P340 IF INHALED : Remove victim to fresh air and keep at rest in a position compotable for breathing

P312 Call a POISON CENTER or doctor/physician if you feel unwell

P377 Leaking gas fire : Do not extinguish, unless leak can be stopped safely

P381 Eliminate all ignition sources if safe to do so

PREVENTION

P210 Keep away from heat/sparks/open flames/hot surface - No smoking

P251 ressurized container : Do not pierce or burn, even after use

P261 Avoid breathing dust/fume/gas/mist/vapours/spray

REACTIBILITY

000

CHEMICAL NAME CONTENT(w%)

ISO-BUTANE 25 ~35

N-BUTANE 50 ~70

PROPANE 0 ~ 5

E. MOST IMPORTANT SYMPTOMS/EFFECT, ACUTE AND DELAYS

F. INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF NECESSARY

5. FIRE FIGHTING MEASURES

D.SPECIAL FIREFIGHTING PROCEDURES E.UNSUAL FIRE AND EXPLISION HAZARDS

A. MIXTURE

Contact with skin or eyes can cause frostbite. Low electrical conduction may cause static electricity, and ignited by spark.

If suffer from frostbite,flush with plenty of lukewarm water immediately.

cover up contaminated skin with a blanket. seek medical attention if ill effect or irritation develops

2-METHYL PROPANE

75-28-5

A. SUITABLE EXTINGUISH MEDIA

B. SPECIFIC HAZARDS ARISING FROM THE CHEMICAL

Thermal decomposition may produce carbon monoxide and other toxic vapors

Heavier than the air, and there is a possibility of ignition and backfire.

May cause explosion if heat up cylinder.

Mixture of gas & air may explode.

May cause pollution by opened contents

Warning, becouse contents are lighter than water

Remove cylinder from danger distance if not be dangerous

Use Equipment or Shielding required to protect personnel against bursting, rupturing or venting containers.

Do not heat container. Store below 110℉ in a Ventilated area.

At elevated temperatures(over 54℃/130℉) CRV of containers will be operated,

but rapidly excess heating or fire will be caused burst or rupture of a container.

3. COMPOSITION/INFORMATION ON INGREDIENTS

C. INHALATION

Get medical advice/attention if you feel unwell

Ventilate with fresh air if open exceed mist and fume, get a medical treatment if have a cough and others

D. INGESTION

Prompt medical action is essential.

Use a breathing eqipment if get breathless by ingestion and inhalation

4. FIRST AID MEASURES

A. EYE CONTACT

Get emergency a medical treatment

Wash skin and eyes with plenty of flowing water over 20 minutes

B. SKIN CONTACT

n-Propane, Propylhydride

74-98-6

SYNONYM

CAS No./ID

C. OTHER HAZARDS WHICH DO NOT RESULT IN CLASSIFICATION (NFPA)

In case of inhalation, consider supplying oxygen.

PROPANE

1

4 HEALTH

FIRE0414

Butane, Liquefied Petroleum Gas

106-97-8

Extremely Flammable. Do not use near fire or flame.

ISOBUTANE

BUTANE

May burst or explode if exposed to heat or spark.

Water spray or Fog for surrounding area. Standard form, Special Alcohol-stable foam, Carbon Dioxide-CO2 , Dry Chemical

Use dried sand and soil if have extinguishment by smothering

C. SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE FIGHER

Fire fighters/rescures must put on apposive protector

Get fire fighting on safty distance

May be damaged if skin and eyes contact

B. ENVIRONMENTAL PRECAUTIONS

Iso-Butane:

OSHA TWA

ACGIH TWA

NIOSH recommended TWA 10 hour(s)

Propane:

OSHA TWA

ACGIH TWA

NIOSH recommended TWA

N-Butane:

OSHA TWA

ACGIH TWA

NIOSH recommended TWA

EXPOSURE STANDARD

B. APPROPRIATE ENGINEERING CONTROLS

No data

2500ppm

1000ppm(1800mg/㎥)

800ppm(1900mg/㎥)

800ppm

800ppm(1900mg/㎥)

Industry safety & health law

Provide adequate ventilation Ventilation equipment should be explosion-resistant if explosive concentrations of material are present. Ensure compliance with applicable exposure limits.

A. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES

C. METHOD AND MATERIALS FOR CONTAINMENT AND CLEANING UP

A. PRECAUTIONS FOR SAFE HANDLING

B. CONDITIONS FOR SAFE STORAGE

8. EXPOSURE CONTROLS/PESONAL PROTECTION

6. ACCIDENTAL RELEASE MEASURE

7. HANDLING AND STORAGE

A. EXPOSURE LIMITS IN THE AIR OF THE WORKPLACE, BIOLOGICAL LIMIT VALUES

1000ppm(1800mg/㎥)

Do not touch spilled material.

Stop leak if possible without personal risk.

Reduce vapors with water spray.

Keep unnecessary people away, isolate hazard area deny entry. Remove sources of ignition. Ventilate closed spaces before entering.

Store in cool, well-ventilated area away from heat, spark or fire

Keep away from foods and drinks

Absorb leaked materials with soil and sand, and throw away it to waste treatment

If spill is indoors, remove all possible sources of ignition and ventilate area immediately until all gases and vapors have been removed

Stop leak if you can do it without risk

Avoid heat, flames, sparks and other sources of ignition.

800ppm(1900mg/㎥)

Protect against direct sun radiation and storage under 40℃

Get handling after read all precautionary statements

Avoid breathing dust/fume/gas/mist/vapours/spray

Do not spray to flash resource point or flammable

Avoid contact with skin and eyes

Empty containers should not be re-used

Protect cylinders from physical damage

Use in a well-ventilated area

Keep away from heat/sparks/open flames/hot surface - No smoking

Store in locking machanism system and not youth handling

Prevent flow to sewer/public waters. stop release

C. INDIVIDUAL PROTECTION MEASURE

RESPIRATORY PROTECTION

Eye Protection

Body Protection Hand Protection

A. APPEARANCE FORM

APPEARANCE COLOR

B. ODOR

C. ODOR THRESHOLD

D. pH

E. MELTING/FREEZING POINT

F. INITIAL BOILING POINT AND RANGE

G. FLASH POINT

H. EVAPORATION RATE

I. FLAMMABILITY(SOLID, GAS)

J. UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS

K. VAPOR PRESSURE

L. SOLUBILIY

M. VAPOR DENSITY

N. RELATIVE DENSITY

O. PARTITION COEFFICIENT OF n-OCTANOL/WATER

P. AUTO-IGNITION TEMPERATURE

Q. DECOMPOSITION TEMPERATURE

R. VISCOSITY

S. EXPLOSIVE PROPERTIES

A. CHEMICAL STABILITY

B. POSSIBILITY OF HAZARDOUS REACTIVITY

C. CONDITION TO AVOID D. INCOMPATIBLE MAERIALS

E. HAZARDROUS DECOMPOSITION PRODUCT

colorless

faint odor

No data

Not applicable

-138℃

-160℃

-187℃

-1℃

-12℃

-42℃

3.25mL/100mL(at

No data

0.007g/100mL (at 20℃)

-60 ℃ (c.c.)

-88℃

-104℃

No data

flammable gas

1.8-8.4 vol%

2.2-9.5 vol%

1557mmHg (at 20℃)

2280mmHg (at 20℃)

5625mmHg (at 20℃)

No data

liquid & vapor

colorless

For the gas: Protective clothing is not required. For the liquid: Wear appropriate protective, cold insulating clothing.

For the gas: Eye protection not required, but recommended. For the liquid: Wear splash resistant safety goggles. Contact lences should not be worn. Provide an emergency eye wash fountain and quick drench shower in

Wear insulated gloves.

An approved breathing apparatus may be appropriate. in case of emergency or leak, use a respirator

Avoid heat, flames, sparks and other sources of ignition. Minimize contact with material. Containers may rupture or exposed to heat

Strong oxidizers such as hydrogen peroxide,nitric acid,sulphuric acid,etc.

Toxic carbon compounds(CO2,etc)

10. STABILITY AND REACTIVITY

Material is stable under normal conditions. Ignition by high temperature surface or flame.

Stable at a normal temperature and pressure. If contact with strong oxidizers, ignition or explosion may be caused by violent reaction.

No data

2.10 g/cm3(air=1)

2.59 g/cm3(air=1)

1.55 g/cm3(air=1)

0.578 (20℃/4℃ liquid)

0.501 (20℃/4℃ liquid)

log Pow 2.89

log Pow 2.80

log Pow 2.36

9. PHYSICAL AND CHEMICAL PROPERTIES

N-Butane

Iso-Butane

Propane

287℃

460℃

466℃

No data

PROPERTIES

11. TOXICOLOGICAL INFORMATION

A. INFORMATION ON THE LIKELY ROUTES OF EXPOSURE

INHALATION EXPOSURE

INGESTION EXPOSURE

SKIN EXPOSURE

EYE EXPOSURE

ACUTE TOXIC

ORAL

SKIN

INHALATION

SKIN CORROSION/IRRITATION

SERIOUS EYE DAMAGE/IRRITANT

RESPIRATORY SENSITIZATION

SKIN SENSITIZATION

CARCINOGENICITY

KOREAN INDUSTRIAL RAW OF SAFETY AND HEALTH

KOREAN DEPARTMENT OF LABOR

IARC

OSHA

ACGIH

NTP

EU CLP

GERM-CELL MUTAGENICITY

GENERATIVE TOXICITY

SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE

SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE

ASPIRATION HAZARD

12. ECOLOGICAL INFORMATION

FISH

DAPHNIA

ALGAE

B. PERSISTENCE AND DEGRADABILITY

PERSISTENCE

DEGRADABILITY

C. BIOACCUMULATIVE POTENTIAL

BIODEGRADATION

BIOACCUMULATION

D. MOVILITY IN SOIL

E. OTHER HAZARDROUS EFFECTS

A. AQUATIC/TERRESTRIAL ECOLOGY TOXICITY

No data

Adsorbs to soil and has low mobility

No data

Not applicable

Frostbite.

No data

Irritation, vomiting, difficulty in breathing, irregular heart beating, headache, sleepiness, dizziness, spasm, coma.

No data

B. DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG TERM EXPOSURE

No data

LD50(rabbit) :No data

LD50(rat) :658,000mg/m3,LD50(mouse) :680,000mg/m3

LD50(rat) :No data

No data

May cause ingestion irritation.

Frostbite.

No data No data

No data

No data No data

13. DISPOSAL CONSIDERATIONS

A. DISPOSAL METHODS

B. PRECAUTIONS

14. TRANSPORT INFORMATION

A. UN NUMBER

B. UN PROPER SHIPPING NAME

C. HAZARD CLASS(ES)

D. PACKING GROUP

E. MARINE POLLUTANT SUBSTANCES

F. SPECIAL PRECAUTIONS FOR USER

15. REGULATORY INFORMATION

A. REGULATORY INFORMATION

1)USA

CERCLA SECTION 103 (40CFR302.4)

SARA SECTION 302(40CFR355.30)

SARA SECTION 304(40CFR355.40)

SARA SECTION 313(40CFR372.65)

SARA SECTION 311/312 (40CFR370.21)

OSHA PROCESS SAFETY(29CFR1910.119

2)EU classification and Labelling information

CLASSIFICATION

RISK PHRASES

SAFTY PHRASES

16. OTHER INFORMATION

A. SOURCE OF DATA

Passenger plane or train:Prohibited

This safety datasheet complies with the requirements of Regulation (EC) No. 1907/2006.

http://www.nema.go.kr/hazmat/

HSDB, U.S. National Library of Medicine(http://toxnet.nlm.nih.gov)

IUCLID Chemical Data Sheet, EC-ECB

International Chemical Safety Cards(ICSC)

ECB-ESIS(European chemical Substances Information System)(http://ecb.jrc.it/esis)

NLM;ChemIDPlus

TOMES;Loli

TOPKAT;Skin Irritation

http://ncis.nier.go.kr

Corporate Solution From Thomson Micromedex(http://csi.micromedex.com)

TOXNET, U.S. National Library of Medicine(http://toxnet.nlm.nih.gov)

The Chemical Database, The Department of Chemistry at the University of Akron (http://ull.chemistry.uakron.edu/erd)

NLM;HSDB

ECB-ESIS(European chemical Substances Information System)(http://ecb.jrc.it/esis)

ECOTOX Database, EPA(http://cfpub.epa.gov/ecotox)

International Chemical Safety Cards(ICSC)(http://www.nihs.go.jp/ICSC)

Not regulated

B. SAFETY, HEALTH AND ENVIRONMENTAL REGULATIONS SPECIFIC FOR THE PRODUCT IN QUESTION: All disposal practices must be in compliance with all law and regulations

Consult local, state, and federal regulations for specific requirements

the contents of containers must be disposed according to related regulations Disposal should be in accordance with applicable regional,national and local laqs and regulation

UN2037

-PROPANE:UN1075

-ISO-BUTANE:UN1999

-N-BUTANE:UN1011

RECEPTACLES, SMALL, CONTAINING GAS(GAS CARTRIDGES) without a release device, non-refillable

Class 2.1

No data

Not applicable

Not regulated

Acute:Yes Chronic:No Fire:Yes Reactivity:No Sudden Pressure:Yes

Not regulated

F

R12:Extremely flammable

S2:Keep out of the reach of children

S9:Keep container in a well-ventilated place

S16:Keep away from sources of ignition - No smoking

B. THE DATE OF PREPARATION OF THE SDS

THE NUMBER OF TIMES REVISED

THE DATE OF PREPARATION OF THE LATEST REVISION

D. OTHERS

No. 1

January. 23. 2015 Globally Harmonized System of classification and labeling of chemical(GHS), United Nations.

C. THE NUMBER OF TIMES REVISED AND THE DATE OF PREPARATION OF THE LATEST REVISION

The information contained herein is to the best of our knowledge and belief accurate. However, since the conditions of handling and use are beyond our control, we make no guarantee for result obtained, and assume no responsibility for damages incurred by use of this product. It is the responsibility of the user to comply with all federal, state and local laws and regulations.

Ecological Structure Activity Relationships(ECOSAR)

EPI Suite

Quantitative Structure Activity Relation(QSAR)

December. 22. 2012 Korea Occupational Safety & Health Agency

Max Burton 1214 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual