Masterbuilt 20030209 Owner's Manual

Masterbuilt Manufacturing, Inc

A Georgia Company

1 Masterbuilt Court

Columbus, Georgia 31907

Customer Service 1-800-489-1581

Failure to follow these warnings and instructions properly could result in fire or explosion, which could

cause property damage, personal injury, or death.

Burning wood chips gives off carbon

monoxide, which has no odor and can

cause death.

DO NOT burn wood chips inside homes,

vehicles, tents, garages or any enclosed

areas.

Use only outdoors where it is well

ventilated.

ASSEMBLY, CARE & USE MANUAL

WARNING & SAFETY INFORMATION

MODELS 20030209, 20030309

VERANDA GAS GRILL

THIS PRODUCT IS FOR OUTDOOR USE ONLY

CARBON MONOXIDE HAZARD

This instruction manual contains

important information necessary for the

proper assembly and safe use of this grill.

Read and follow all warnings and

instructions before assembling and using

grill and during use.

Follow all warnings and instructions

when using this grill.

Keep this manual for future reference.

WARNING

Tools required for assembly: Phillips Head Screwdriver.

Manual Code: 03080010 081105

Approximate assembly time: 10 minutes.

COMPLETE & RETURN TO

ATTN: WARRANTY REGISTRATION

Masterbuilt Manufacturing, Inc.

1 Masterbuilt Court, Columbus, GA 31907

Name:

Address:

City:

State/Province: Postal Code:

Phone Number: E-Mail Address:

Model Number: Serial Number:

Purchase Date: Place of Purchase:

LIMITED WARRANTY INFORMATION

Masterbuilt warrants its products to be free from defects in material and workmanship under proper assembly, normal use and recommended care for 90 days from the date of original retail purchase.

Masterbuilt warranty does not cover paint finish as it may burn off during normal use. Masterbuilt warranty does not cover rust of the unit. Masterbuilt requires reasonable proof of purchase for warranty claims and suggests that you keep your receipt.

Upon the expiration of such warranty, all such liability shall terminate. Within the stated warranty period, Masterbuilt, at its discretion, shall repair or replace defective components free of

charge with owner being responsible for shipping. Should Masterbuilt require return of component(s) in question for inspection Masterbuilt will be responsible for shipping charges to return requested item.

This warranty excludes property damage sustained due to misuse, abuse, accident, damage arising out of transportation, or damage incurred by commercial use of this product.

This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties, expressed or implied including implied warranty, merchantability, or fitness for a particular purpose.

Neither Masterbuilt nor the retail establishment selling this product, has authority to make any warranties or to promise remedies in addition to or inconsistent with those stated above.

Masterbuilt’s maximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer/ purchaser. Some states do not allow the exclusion or limitation of incidental or consequential damages. In such a case, the above limitations or exclusions may not be applicable.

California residents only: Not withstanding this limitation of warranty, the following specific restrictions apply; if service, repair, or replacement of the product is not commercially practical, the retailer selling the product or Masterbuilt will refund the purchase price paid for the product, less the amount directly attributable to use by the original buyer prior to the discovery of the nonconformity. Owner may take the product to the retail establishment selling this product in order to obtain performance under warranty.

This expressed warranty gives you specific legal rights, and you may also have other rights which vary from state to state.

1. Never operate this appliance unattended.

2. Never operate this appliance within 10 feet (3m) of any structure, combustible material or other gas cylinder.

3. Never operate this appliance within 25 feet (7.5m) of any flammable liquid.

4. If fire should occur keep away from

appliance and immediately call your fire department. Do not attempt to extinguish an oil/grease fire with water.

FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS

PROPERLY COULD RESULT IN FIRE OR EXPLOSION, WHICH COULD

CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from the appliance and immediately call your Fire Department.

DANGER

CAUTION

• Fatty foods (hamburgers,etc.) can have excess grease and cause flare ups. When cooking fatty foods, use a low setting with lid open.

• Clean internal base pan before each use. This will cut down on build-up and flare ups.

• When outside temperature is cooler than 65°F (18°C) and/or altitude is above 3,500 ft. (1067m),

additional cooking time may be required. To insure that meat is completely cooked use a meat thermometer to test internal temperature.

•

Lifting grill lid during cooking process may extend cooking time due to heat loss.

APPROXIMATE GRILLING TIMES

BEEF SIZE GRILLING TIME INTERNAL TEMP

Steaks

” (2cm) thick

3 to 4 min. /side med rare 145°F (62°C)

4 to 5 min. /side med 160°F (71°C)

Kabobs 1” (2.5cm) cubes 3 to 4 min. /side 145°-160°F (62-71°C)

Hamburger patties

/2” (12mm) thick 3 to 4 min. /side med 160°F (71°C))

Roast, rolled rump 4-6 lbs. (1.8-2.7kg) 18 to 22 min /lb. 145°-160°F (62-71°C)

Sirloin tip 3 1/2--4 lbs. (1.5-1.8kg) 20 to 25 min. /lb. 145°-160°F (62-71°C)

Ribs, back cut in 1-rib portions 10 min. /side med 160°F (71°C)

half, 2-3 lbs. (0.9-1.3kg) 10 to 12 min. /side med rare 145°F (62°C)

Tenderloin whole, 4-6 lbs. (1.8-2.7kg) 12 to 15 min. /side med 160°F (71°C)

PORK SIZE GRILLING TIME INTERNAL TEMP

Chops, bone-in

/4” (2cm) thick 3 to 4 min. /side med 160°F (71°C)

Chops, bone-out 11/2

” (4cm) thick

7 to 8 min. /side med 160°F (71°C)

Tenderloin

/2-11/2 lbs. (0.2-0.6kg) 15 to 25 min. total med 160°F (71°C)

Ribs (indirect heat) 2-4 lbs. (0.9-1.8kg) 1 1/2 to 2 hrs. med 160°F (71°C)

VENISON SIZE GRILLING TIME INTERNAL TEMP

Roast, saddle or leg 6-7 lbs. (2.7-3.1kg) 25 to 30 min. /lb. 145°-160°F (62-71°C)

Steaks

/4” (2cm) thick 6 to 7 min. /side med 160°F (71°C)

CHICKEN SIZE GRILLING TIME INTERNAL TEMP

Broiler fryer (indirect heat)

3-4 lbs. (1.3-1.8kg) 60 to 75 min. in thigh 180°F (82°C)

Cornish hens 18-24 oz. (510-680g) 45 to 55 min. in thigh 180°F (82°C)

Breast halves, bone-in 6-8 oz. ( 170-226g) each 10 to 15 min. /side 170°F (77°C)

Breast halves, boneless 4 oz. (113g) each 6 to 8 min. /side 170°F (77°C)

Legs or thighs 4-8 oz. (113-226g) 10 to 15 min. /side 180°F (82°C)

Drumsticks 4 oz. (113g) 8 to 12 min. /side 180°F (82°C)

Wings 2-3 oz. (56-85g) 8 to 12 min. /side 180°F (82°C)

GENERAL WARNINGS AND SAFETY INFORMATION

• Unit is for outdoor use only.

• Never use inside enclosed areas such as patios, garages, buildings or tents.

• Never use inside recreational vehicles or on boats.

• Never operate unit under overhead construction such as roof coverings, carports, awnings, or overhangs.

• Never use unit as a heater.

• Maintain a minimum distance of 10ft (3m) from overhead construction, walls, rails or other structures.

• Keep a minimum 10ft (3m) clearance of all combustible materials such as wood, dry plants, grass, brush, paper, or canvas.

• Keep appliance clear and free from combustible materials such as gasoline and other flammable vapors and liquids.

• Use unit on a level, non-combustible, stable surface such as dirt, concrete, brick or rock.

• Keep children and pets away from unit at all times. Do NOT allow children to use unit.

• Unit has an open flame. Keep hands, hair, and face away from burner flame. Do NOT lean over burner when lighting. Loose hair and clothing may catch fire.

• Allow unit to cool below 115°F (45°C) before moving or storing.

• Avoid bumping or impacting unit.

• This unit is HOT while in use and during cooling process. Wear protective gloves/mitts.

• Use of alcohol, prescription or non-prescription drugs may impair user's ability to properly assemble or safely operate unit.

• Never use glass, plastic or ceramic cookware in unit.

• Do NOT allow anyone to conduct activities around unit during or following its use until it has cooled.

• Accessory attachments not supplied by Masterbuilt Manufacturing, Inc. are not recommended.

• Never use unit for anything other than its intended use. This unit is NOT for commercial use.

• Use in accordance with local, state and federal fire codes.

• This appliance is not for frying turkeys.

+ 5 hidden pages